engine TOYOTA RAV4 2000 Manual PDF

Rav4(U)
2312000 RAV4 (OM42479U)
Engine
Model:
3S−FE
Type:
4 cylinder in line, 4 cycle, gasoline
Bore and stroke, mm (in.):
86.0  86.0 (3.39  3.39)
Displacement, cm
3
(cu. in.):
1998 (121.9)
Fuel
Fuel type:
Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or
higher
Fuel tank capacity, L (gal., lmp. gal.):
58 (15.3, 12.8)
Service specifications
ENGINE
Valve clearance (engine cold), mm (in.):
Intake 0.19—0.29 (0.007—0.011)
Exhaust 0.28—0.38 (0.011—0.015)
Spark plug type:
DENSO PK20TR11
NGK BKR6EKPB11
Spark plug gap, mm (in.):
1.1 (0.043)
Drive belt tension measured with Bor-
roughs drive belt tension gauge No.
BT−33−73F (used belt), Ibf:
Generator belt 65
20
Air conditioning
compressor belt 100
20
Power steering
pump belt 80
20
ENGINE LUBRICATION
Oil capacity (drain and refill),
L (qt., Imp. qt.):
With filter
4.1 (4.3, 3.6)
Without filter
3.9 (4.1, 3.4)
ProCarManuals.com

Rav4(U)
2322000 RAV4 (OM42479U)
Oil grade:
API grade SJ, ”Energy−Conserving” or
ILSAC multigrade engine oil is recom-
mended.
Recommended oil viscosity (SAE):
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
Manual transmission
8.0 (8.5, 7.0)
Automatic transmission
7.7 (8.1, 6.8)
Coolant type:
”TOYOTA Long Life Coolant” or equiva-
lent
With ethylene−glycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights
turned off
Charging rates:
5 A max.
CLUTCH
Pedal free play, mm (in.):
5—15 (0.2—0.6)
Fluid type:
SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.):
Tw o−wheel drive models
3.9 (4.1, 3.4)
Four−wheel drive models
5.0 (5.3, 4.4)
Oil type:
Tw o−wheel drive models
Gear oil API GL−4 or GL−5
Four−wheel drive models
Gear oil API GL−5
Recommended oil viscosity:
SAE 75W−90AUTOMATIC TRANSAXLE
Fluid capacity (drain and refill),
L (qt., Imp. qt.):
Up to 3.3 (3.5, 2.9)
Fluid type:
Tw o−wheel drive models
Automatic transmission fluid
D−II or DEXRONIII (DEXRONII)
Four−wheel drive models
Toyota automatic transaxle fluid
type T or T−IV or equivalent
TRANSFER
(four−wheel drive models with an auto-
matic transaxle)
Oil capacity, L (qt., Imp. qt.):
0.7 (0.7, 0.6)
Oil type:
Gear oil API GL−5
Recommended oil viscosity:
SAE 75W−90
ProCarManuals.com

Rav4(U)
2332000 RAV4 (OM42479U)
REAR DIFFERENTIAL
(four−wheel drive models)
Oil capacity, L (qt., Imp. qt.):
0.9 (1.0, 0.8)
Oil type:
Hypoid gear oil API GL−5
Recommended oil viscosity:
Above −18 °C (0 °F)
SAE 90
Below −18 °C (0 °F)
SAE 80W or 80W−90BRAKES
Minimum pedal clearance when depressed
with the pressure of 490 N (50 kgf, 110
lbf) with the engine running, mm (in.):
75 (3.0)
Pedal free play, mm (in.):
1—6 (0.04—0.24)
Pad wear limit, mm (in.):
1.0 (0.04)
Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf):
5—8 clicks
Fluid type:
SAE J1703 or FMVSS No.116 DOT 3STEERING
Wheel freeplay:
Less than 30 mm (1.2 in.)
Power steering fluid type:
Automatic transmission fluid
DEXRONII or III
ProCarManuals.com

Rav4(U)
2352000 RAV4 (OM42479U)
Fuses
Engine compartment
(without daytime running light system)
Fuses (type A)
1. H−LP (RH) 15 A: Right−hand headlight
2. H−LP (LH) 15 A: Left−hand headlight
3. SPARE 10 A: Spare fuse
4. SPARE 15 A: Spare fuse
5. AM2 5 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, SRS airbag system, seat belt
pretensioners, starting system, dis-
charge warning light
6. ALT−S 5 A: Charging system
7. HAZ 10 A: Emergency flashers
Engine compartment
(with daytime running light system)
8. EFI 20 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system
9. DOME 15 A: Interior light, personal
lights, clock, daytime running light sys-
tem, gauge and meters, car audio sys-
tem
10. IGN 20 A: Charging system
11 . H−LP RH−H 10 A: Right−hand head-
light (high beam)
12. H−LP LH−H 10 A: Left−hand headlight
(high beam)
13. H−LP RH−L 10 A: Right−hand head-
light (low beam)
Engine compartment
14. H−LP LH−L 10 A: Left−hand headlight
(low beam)
15. PWR OUTLET 15 A: Power outlet
16. CIG 15 A: Cigarette lighter, clock, car
audio system, power rear view mirrors,
electronically controlled automatic
transmission system
17. SRS−ACC 10 A: SRS airbag system,
seat belt pretensioners
18. WIPER 20 A: Windshield wipers and
washer, rear window wiper and washer
ProCarManuals.com