clock TOYOTA RAV4 2002 XA20 / 2.G User Guide
[x] Cancel search | Manufacturer: TOYOTA, Model Year: 2002, Model line: RAV4, Model: TOYOTA RAV4 2002 XA20 / 2.GPages: 283, PDF Size: 5.49 MB
Page 201 of 283

’02 Rav4_U (L/O 0108)
1922002 MY RAV4_U (OM42503U)
To remove the spare tire on the back
door:1. Remove the spare tire cover.
Full spare tire cover—Unhook the latch
handle which is on the bottom of the cov-
er. Pull up the cover by grasping the
clearances on both sides between the
cover and latch handle base.
Half spare tire cover—Pry off the center
cover and loose the nut with wheel nut
wrench, then remove the spare tire cover.
2. Turn the hold down nuts counterclock- wise with the wheel nut wrench and
remove them.
When storing the spare tire, put it in place
and secure it to prevent it from flying
forward during a collision or s udden brak-
ing.2. Block the wheel diagonally opposite the flat tire to keep the vehicle from
rolling when it is j acked up.
When blocking the wheel, place a wheel
block from the front for the front wheels
or from the rear for the rear wheels.
—Blocking the wheel
Page 202 of 283

’02 Rav4_U (L/O 0108)
1932002 MY RAV4_U (OM42503U)
3. Loosen all the wheel nuts.
Always loosen the wheel nuts before rais-
ing the vehicle.
Turn the wheel nuts counterclockwise to
loosen. To get maximum leverage, fit the
wrench to the nut so that the handle is
on the right side, as shown above. Grab
the wrench near the end of the handle
and pull up on the handle. Be careful that
the wrench does not slip off the nut.
Do not remove the nuts yet—just unscrew
them about one half turn.4. Position the jack at the following jack points.
1 Front suspension cross member rear mounting
2 Rear suspension arm
Make sure the jack is positioned on a
level and solid place.5. After making sure that no one is in the vehicle, raise it high enough so
that the spare tire can be installed.
Remember you will need more ground
clearance when putting on the spare tire
than when removing the flat tire.
To raise the vehicle, insert the jack handle
into the jack (it is a loose fit) and turn it
clockwise. As the jack touches the vehicle
and begins to lift, double check that it is
properly positioned.
—Loosening wheel nuts —Positioning the jack—Raising your vehicle
Page 204 of 283

’02 Rav4_U (L/O 0108)
1952002 MY RAV4_U (OM42503U)
7. Reinstall all the wheel nuts fingertight.
Reinstall the wheel nuts (tapered end in-
ward) and tighten them as much as you
can by hand. Press back on the tire back
and see if you can tighten them more.8. Lower the vehicle completely and tighten the wheel nuts.
Turn the jack handle counterclockwise to
lower the vehicle.
Use only the wheel nut wrench and turn
it clockwise to tighten the nuts. Do not
use other tools or any additional leverage
other than your hands, such as a hammer,
pipe or your foot. Make sure the wrench
is securely engaged over the nut.
Tighten each nut a little at a time in the
order shown. Repeat the process until all
the nuts are tight.
CAUTION
When lowering the vehicle, make sure
all portions of your body and all oth-
er persons around will not be injured
as the vehicle is lowered to the
ground.
—Reinstalling wheel nuts —Lowering your vehicle
Page 239 of 283

’02 Rav4_U (L/O 0108)
2302002 MY RAV4_U (OM42503U)
Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the “COLD”
range. Similarly, if it is hot, the fluid level
should be in the “HOT” range. If the level
is at the low side of either range, add
automatic transmission fluid DEXRONII or
III to bring the level within the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the reser-
voir cap, visually check the steering box
case, vane pump and hose connections
for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
The air conditioning filter is behind the
glove box.
The air conditioning filter may clog af-
ter long use. The filter may need to be
replaced if the air flow of the air condi-
tioning and heater experiences extreme
reductions in operating efficiency, or if
the windows become to fog up easily.
To maintain the air conditioning efficiency,
inspect and replace the air conditioning
filter according to the maintenance sched-
ule. (For scheduled maintenance informa-
tion, please refer to the “Scheduled Main-
tenance Guide” or “Owner ’s Manual
Supplement”.)1. Push each side of the glove box to disconnect the claws.
Checking and replacing the
air conditioning filter
Page 267 of 283

’02 Rav4_U (L/O 0108)
2582002 MY RAV4_U (OM42503U)
Engine compartment
Instrument panel
Fuses (type A)1. RADIO 15 A: Car audio system
2. DOME 10 A: Clock, personal light, in-
terior lights, air conditioning system,
wireless remote control system, head-
light high beam indicator light, gauges
and meters
3. CUT 30 A: “RADIO” and “DOME” fuses
4. A/C 5 A: Air conditioning system
5. MAIN 30 A: “H LP RH” and “H LP LH”
fuses
6. HAZ 10 A: Emergency flashers 7. ALT S 5 A:
Charging system
8. IGN 15 A: Starting system, multiport
fuel injection system/sequential multi-
port fuel injection system
9. EFI3 10 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, emission control system
10. EFI2 5 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system
11. A/F 20 A: A/F sensor
12. ABS2 30 A: Anti lock brake system
13. EFI1 20 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, “EFI2” and “EFI3” fuses
14. H LP RH 10 A: Right hand headlight
15. H LP LH 10 A: Left hand headlight
16. ST 5 A: Starting system
17. STOP 10 A: Stop lights, high mounted
stoplight, anti lock brake system, shift
lock control system, multiport fuel in-
jection system/sequential multiport fuel
injection system, cruise control system
18. CIG 15 A: Cigarette lighter
19. POWER OUTLET 15 A: Power outlets
20. S HTR 10 A: No circuit
Fuses
Page 268 of 283

’02 Rav4_U (L/O 0108)
2592002 MY RAV4_U (OM42503U)
21. PANEL 7.5 A: Instrument panel light,
gauges and meters, front fog lights,
instrument panel light control, outside
rear view mirror defoggers, air condi-
tioning system
22. FR FOG 15 A: Front fog lights
23. HORN 10 A: Horn
24. TAIL 7.5 A: Tail lights, license plate
lights, instrument cluster lights
25. TAIL&PANEL 15 A: “PANEL” and
“TAIL” fuses
26. ACC 7.5 A: Car audio system, shift
lock control system, clock, power rear
view mirrors
27. DEF 20 A: Rear window defogger
28. GAUGE 10 A: Back up lights, electric
cooling fans, air conditioning system,
automatic transmission indicator lights,
charging system
29. OBD 7.5 A: On board diagnosis sys-
tem
30. IG2 10 A: Discharge warning light,
multiport fuel injection system/sequen-
tial multiport fuel injection system,
starting system, SRS airbag system
31. DOOR 20 A: Power door lock system 32. MIR HTR 10 A:
Outside rear view mir-
ror defoggers
33. RR WIP 15 A: Rear window wiper and
washer
34. WIP 25 A: Windshield wipers and
washer
35. ECU IG 10 A: Emergency flashers,
gauges and meters, anti lock brake
system, SRS airbag system, shift lock
control system, cruise control system
Fuses (type B)
36. RDI 30 A: Electric cooling fan
37. CDS 30 A: Electric cooling fan
38. AM2 30 A: Discharge warning light,
multiport fuel injection system/sequen-
tial multiport fuel injection system,
starting system, SRS airbag system
and “IG2” fuse
39. ABS 1 40 A: Anti lock brake system
40. HTR 40 A: Air conditioning system
41. PWR 30 A: Electric moon roof, power
windows
42. AM1 40 A: Power outlets, rear window
defogger, “ACC”, “CIG”, “ECU IG”,
“GAUGE”, “RR WIP”, “S HTR” and
“WIP” fuses
Page 275 of 283

’02 Rav4_U (L/O 0108)
2662002 MY RAV4_U (OM42503U)
A
Adding washer fluid243
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 29
. . . . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 40
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air cleaner 230
. . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 128
. . . . . . . . . . . . . . .
Airbags 50
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 237
. . . . . . . . . .
Anti glare inside rear view mirror 76 . . . . . . .
Anti lock brake system warning light 90 . . . .
Anti theft steering column lock 98
. . . . . . . . .
Appearance care
Cleaning the interior 209
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 206
. . . . . . . . . . . . . . . . . . .
Washing and waxing 207
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 99
. . . . . . . . .
Shift lock override button 202
. . . . . . . . . . . .
Shift pattern 99
. . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 99
. . . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 90
. . . . . . . . . . . .
Auxiliary boxes 141
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 22
. . . . . . . . . . .
B
Back door 21
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 21
. . . . . . . . . . . . . . . . . . . . . . . . Battery
Checking battery condition 240
. . . . . . . . . .
Gas caution 240
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 240
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 241
. . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Before starting the engine 170
. . . . . . . . . . . . .
Brake pad wear limit indicators 164 . . . . . . . .
Brake system 161
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 90
. . . . . . . . . . . . .
Brakes
Fluid level 229
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 164
. . . . . . . . . . . .
Parking 104
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break in tips 155
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 82
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 110
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 159
. . . . . . . . . . . . .
Cassette player 110
. . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 242
. . . . . . . . .
Checking brake fluid 229
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 226
. . . . . . . . . .
Checking the radiator and condenser 228
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 58
. . . . . . . . . . . . . . .
Installation 60
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with ISOFIX rigid anchor 72
. . . . . . . . . . . . . . . . . . . . . .
Precautions 57
. . . . . . . . . . . . . . . . . . . . . . . . Types of child restraint system 59
. . . . . . . .
Using a top strap 69
. . . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136
. . . . . . . . .
Cleaning the interior 209
. . . . . . . . . . . . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 173
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc auto changer controller 110
. . . . . . . . . . . . . . . . . .
Compact disc player 110
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 228
. . . . . . . . . . . .
Controls, Instrument panel 2,4
. . . . . . . . . . . .
Cooling system
Coolant level 227
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 188
. . . . . . . . . . . . . . . . .
Radiator and reservoir 227
. . . . . . . . . . . . . .
Radiator cap 188
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Corrosion prevention 206
. . . . . . . . . . . . . . . . .
Cruise control 105
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Out side rear view mirror 85 . . . . . . . . . . . . .
Rear window 85
. . . . . . . . . . . . . . . . . . . . . . . .
Differential, Limited slip 165
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 80
. . . . . . . . . . . . . .
Dinghy towing 174,175
. . . . . . . . . . . . . . . . . . .
Directional signals 80
. . . . . . . . . . . . . . . . . . . .
Page 277 of 283

’02 Rav4_U (L/O 0108)
2682002 MY RAV4_U (OM42503U)
Front cup holder143
. . . . . . . . . . . . . . . . . . . . .
Front fog light switch 82
. . . . . . . . . . . . . . . . . .
Front passenger ’s seat belt reminder light 90
. . . . . . . . . . . . . . . . . . . . . . .
Front seat
Seatback flattening 38
. . . . . . . . . . . . . . . . . .
Front seats 28,29
. . . . . . . . . . . . . . . . . . . . . . . .
Fuel
Filler door o pener 24
. . . . . . . . . . . . . . . . . . .
Fuel economy 181
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 157
. . . . . . . . . .
Gauge 88
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 157 . . . . . . .
Tank cap 24
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 155
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 157
. . . . . . . . . . . .
Fuse
Fuse box 242
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 219
. . . . . . . . . . . . . . . . . . . . . . .
G
Garage door opener box 138
. . . . . . . . . . . . . .
Gauge
Engine coolant temperature 88
. . . . . . . . . .
Fuel 88
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 138
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice 99,103
. . . . . . . . . . . . . .
Grocery bag hooks 145
. . . . . . . . . . . . . . . . . . .
H
Hazard switch 81
. . . . . . . . . . . . . . . . . . . . . . . .
Head restraints 39
. . . . . . . . . . . . . . . . . . . . . . .
Headlight switch 80
. . . . . . . . . . . . . . . . . . . . . .
High speed operation
During break in 155
. . . . . . . . . . . . . . . . . . . .
Hood release, Engine 22
. . . . . . . . . . . . . . . . . .
How to start the engine 170
. . . . . . . . . . . . . . .
I
I/M test 216
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification
Engine 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 165
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 98
. . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . . . .
Instrument panel
Brightness control 82
. . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136 . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel gauge 88
. . . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . .
Odometer 89
. . . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 89
. . . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 89
. . . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 82
. . . . . . . . . . .
Instrument panel overview 2,4
. . . . . . . . . . . .
Interior light 82
. . . . . . . . . . . . . . . . . . . . . . . . . .
J
Jack
Location 190 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 185 . . . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 90
. . . . . . . . . . . . . . . . . .
Keys 8,203
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Back up lights 249 . . . . . . . . . . . . . . . . . . . . .
Front fog lights 246 . . . . . . . . . . . . . . . . . . . . .
Front side marker lights 248 . . . . . . . . . . . . .
Front turn signal lights 248,249 . . . . . . . . . .
Headlights 245 . . . . . . . . . . . . . . . . . . . . . . . .
High mounted stoplight 250 . . . . . . . . . . . . .
License plate lights 251 . . . . . . . . . . . . . . . . .
Parking lights 248 . . . . . . . . . . . . . . . . . . . . . .
Rear side marker lights 249 . . . . . . . . . . . . .
Rear turn signal lights 249 . . . . . . . . . . . . . .
Stop/tail lights 249 . . . . . . . . . . . . . . . . . . . . .
Light bulbs, Replacing 244 . . . . . . . . . . . . . . . .
Light reminder buzzer 90 . . . . . . . . . . . . . . . . .
Limited slip differential 165 . . . . . . . . . . . . . . . .
Lock
Back door 21 . . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 12 . . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 98 . . . . . . . . . . . . . . . . . . . .
Low engine oil pressure warning light 90 . . . .
Low fuel level warning light 90 . . . . . . . . . . . . .