fuses TOYOTA RAV4 2005 XA30 / 3.G Owners Manual

'05 Rav4_U (L/O 0409)
279
2005 RAV4 from Sep. '04 Prod. (OM42570U)
Spare fuses
If you perform maintenance by yourself,
be sure to follow the correct procedure
given in this Section.
You should be aware that improper or in-
complete servicing may result in operating
problems.
Performing do- it- yourself maintenance
during the warranty period may affect your
warranty coverage. Read the separate
Toyota Warranty statement for details and
suggestions.
This Section gives instructions only for
those items that are relatively easy for an
owner to perform. As explained in Section
6, there are still a number of items that
must be done by a qualified technician
with special tools.
For information on tools and parts for do-
it- yourself maintenance, see Parts and
toolsº on page 281 in this Section.
Utmost care should be taken when work-
ing on your vehicle to prevent accidental
injury. Here are a few precautions that
you should be especially careful to ob-
serve:
Fuse locationsDo- it- yourself service
precautions

'05 Rav4_U (L/O 0409)
282
2005 RAV4 from Sep. '04 Prod. (OM42570U)
CHECKING AND REPLACING FUSES
Parts (if replacement is necessary):

Fuse with same amperage rating as
original
ADDING WASHER FLUID
Parts:

Water

Washer fluid containing antifreeze
(for winter use)
Tools:

Funnel
REPLACING LIGHT BULBS
Parts:

Bulb with same number and wattage
rating as original (See charts in
Replacing light bulbsº on page 304 in
Section 7- 3.)
Tools:

Screwdriver
Front
Rear (two- wheel drive models)
Rear (four- wheel drive models)
Positioning the jack

'05 Rav4_U (L/O 0409)
299
2005 RAV4 from Sep. '04 Prod. (OM42570U)
DO- IT- YOURSELF MAINTENANCE
Electrical components
Checking battery condition300
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 301
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 302
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 303
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . .
Replacing light bulbs 304
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
SECTION 7- 3

'05 Rav4_U (L/O 0409)
302
2005 RAV4 from Sep. '04 Prod. (OM42570U)
GoodBlown
Ty p e A
Good Blown
Ty p e B
If the headlights or other electrical
components do not work, check the
fuses. If any of the fuses are blown,
they must be replaced.
See Fuse locationsº on page 279 in Sec-
tion 7- 1 for locations of the fuses.
Turn the ignition switch and inoperative
component off. Pull the suspected fuse
straight out and check it.
Determine which fuse may be causing the
problem. The lid of the fuse box shows
the name of the circuit for each fuse. See
page 316 in Section 8 for the functions
controlled by each circuit. Type A fuses can be pulled out by using
the pull- out tool. The location of the pull-
out tool is shown in the illustration.
If you are not sure whether the fuse has
blown, try replacing the suspected fuse
with one that you know is good.
If the fuse has blown, push a new fuse
into the clip.
Only install a fuse with the amperage rat-
ing designated on the fuse box lid.
If you do not have a spare fuse, in an
emergency you can pull out the RADIOº
or A/Cº fuse, which may be dispensable
for normal driving, and use it if its amper-
age rating is the same.
If you cannot use one of the same amper-
age, use one that is lower, but as close
to the rating as possible. If the amperage
is lower than that specified, the fuse
might blow out again but this does not
indicate anything wrong. Be sure to get
the correct fuse as soon as possible and
return the substitute to its original clip.
It is a good idea to purchase a set of
spare fuses and keep them in your ve-
hicle for emergencies.
Checking and replacing fuses

'05 Rav4_U (L/O 0409)
311
2005 RAV4 from Sep. '04 Prod. (OM42570U)
SPECIFICATIONS
Specifications
Dimensions and weights312
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Engine 313
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . .
Fuel 313
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Service specifications 313
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . .
Tires 316
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . .
Fuses 316
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . .
SECTION 8

'05 Rav4_U (L/O 0409)
316
2005 RAV4 from Sep. '04 Prod. (OM42570U)
Tire size:215/70R16 99S
235/60R16 100H
Cold tire inflation pressure, kPa
(kgf/cm
2 or bar, psi):
200 (2.0, 29)
Wheel size: Steel wheel 16
61/2J
Aluminum Wheel 16
7JJ
Wheel nut torque, N
´m (kg f´m, ft´lbf):
103 (10.5, 76)
NOTE: For a complete information on tires (e.g. replacing tires
or replacing wheels), see
Checking tire inflation pres-
sureº through Aluminum
wheel precautionsº, pages
291 through 298 in Section
7- 2.
Engine compartment
Instrument panel
Fuses (type A)
1. RADIO 15 A: Audio system
2. DOME 10 A: Clock, personal light, in-
terior lights, vanity lights, garage door
opener, air conditioning system, wire-
less remote control system, gauges
and meters
3. CUT 30 A: RADIOº and DOMEº fuses
4. A/C 5 A: Air conditioning system
5. MAIN 30 A: H- LP RHº and H- LP LHº
fuses
6. HAZ 10 A: Emergency flashers
Tires Fuses

'05 Rav4_U (L/O 0409)
317
2005 RAV4 from Sep. '04 Prod. (OM42570U)
7. ALT- S 5 A: Charging system
8. IGN 15 A: Starting system, multiport
fuel injection system/sequential multi-
port fuel injection system
9. EFI3 10 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, emission control system
10. EFI2 5 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system
11. RADIO NO.2 30 A: Audio system
12. ABS 2 30 A: Anti- lock brake system,
vehicle stability control system, traction
control system, brake assist system
13. EFI1 20 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, automatic transmission fluid
temperature sensor, EFI2º and EFI3º
fuses
14. H- LP RH 15 A: Right- hand headlight
15. H- LP LH 15 A: Left- hand headlight
16. ETCS 10 A: Electronic throttle control
system
17. ST 5 A: Starting system 18. STOP 10 A:
Stop lights, high- mounted
stoplight, anti- lock brake system, shift
lock control system, multiport fuel in-
jection system/sequential multiport fuel
injection system, cruise control system
19. CIG 15 A: Cigarette lighter
20. POWER OUTLET 15 A: Power outlets
21. S- HTR 10 A: Seat heaters
22. PANEL 7.5 A: Instrument panel lights,
gauges and meters, front fog lights,
instrument panel light control, outside
rear view mirror defoggers, air condi-
tioning system
23. FR FOG 15 A: Front fog lights
24. HORN 10 A: Horn
25. TAIL 7.5 A: Tail lights, license plate
lights
26. TAIL&PANEL 15 A: PANELº and
TAILº fuses
27. ACC 7.5 A: Audio system, shift lock
control system, clock, power rear view
mirrors
28. DEF 20 A: Rear window defogger
29. GAUGE 10 A: Back- up lights, electric
cooling fans, air conditioning system,
automatic transmission indicator lights,
charging system 30. OBD 7.5 A:
On- board diagnosis sys-
tem
31. IG2 10 A: Discharge warning light,
multiport fuel injection system/sequen-
tial multiport fuel injection system,
starting system, gauges and meters,
SRS airbag system
32. DOOR 20 A: Power door lock system
33. MIR HTR 10 A: Outside rear view mir-
ror defoggers
34. RR WIP 15 A: Rear window wiper and
washer
35. WIP 25 A: Windshield wipers and
washer
36. ECU IG 10 A: Emergency flashers,
gauges and meters, anti- lock brake
system, vehicle stability control system,
traction control system, SRS airbag
system, shift lock control system,
cruise control system
Fuses (type B)
37. RDI 30 A: Electric cooling fan
38. CDS 30 A: Electric cooling fan
39. AM2 30 A: Discharge warning light,
multiport fuel injection system/sequen-
tial multiport fuel injection system,
starting system, SRS airbag system,
IG2º fuse

'05 Rav4_U (L/O 0409)
318
2005 RAV4 from Sep. '04 Prod. (OM42570U)
40. ABS 1 50 A: Anti- lock brake system
41. HTR 40 A: Air conditioning system
42. F- HTR or H- LP CLN 30 A: No circuit
43. PWR 30 A: Electric moon roof, power
windows
44. AM1 40 A: Power outlets, rear window
defogger, ACCº, CIGº, ECU IGº,
GAUGEº, RR WIPº, S- HTRº and
WIPº fuses