immobilizer TOYOTA RAV4 2008 XA30 / 3.G Owners Manual

’08 Rav4_U (L/O 0802)
3
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
1. Instrument panel light control dial
2. Headlight, turn signal and front foglight switches
3. Wiper and washer switches
4. Four −wheel drive lock switch
(four −wheel drive models) or “AUTO
LSD” switch (two −wheel drive models)
5. Audio system
6. Emergency flasher switch
7. Front passenger occupant classification indicator light
8. Air conditioning controls
9. Clock display
10. Rear window and outside rear view mirror defogger switch
11. Power outlet
12. Windshield wiper de −icer switch
13. Seat heater switch
14. Downhill assist control switch
15. Front passenger ’s seat belt reminder light
16. Engine immobilizer system indicator light

View B (with manual air conditioning system)

’08 Rav4_U (L/O 0802)
5
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
1. Instrument panel light control dial
2. Headlight, turn signal and front foglight switches
3. Wiper and washer switches
4. Four −wheel drive lock switch
(four −wheel drive models) or “AUTO
LSD” switch (two −wheel drive models)
5. Audio system
6. Emergency flasher switch
7. Front passenger occupant classification indicator light
8. Air conditioning controls
9. Rear window and outside rear view mirror defogger switch
10. Clock and air conditioning display 11. Power outlet
12. Windshield wiper de −icer switch
13. Seat heater switch
14. Downhill assist control switch
15. Front passenger ’s seat belt reminder light
16. Engine immobilizer system indicator light

View B (with automatic air conditioning system)

’08 Rav4_U (L/O 0802)
11
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
OPERATION OF INSTRUMENTS AND
CONTROLS
Keys and Doors
Keys12
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . .
Engine immobilizer system 15
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wireless remote control 16
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Side doors 22
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . .
Power windows 24
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . .
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . .
Hood 27
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Fuel tank cap 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
Electric moon roof 30
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . .
SECTION 1 2

’08 Rav4_U (L/O 0802)
12
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Your vehicle is supplied with two kinds
of keys.1. Master keys—These keys work in ev- ery lock.
2. Sub key—This key will not work in the glove box.
To protect items locked in the glove box
when using valet parking, leave the sub
key with the attendant.
Since the side doors can be locked with-
out a key, you should always carry a
spare key in case you accidentally lock
your keys inside the vehicle.KEY NUMBER PLATE
Your key number is shown on the plate.
Keep the plate in a safe place such as
your wallet, not in the vehicle.
If you should lose your keys or if you
need additional keys, duplicates can be
made by a Toyota dealer using the key
number.
We recommend writing down the key num-
ber and storing it in a safe place.Your vehicle is supplied with two kinds
of keys. 1. Master keys—These keys work in ev- ery lock. Your Toyota dealer will need
one of them to make a new key with
a built −in transponder chip.
2. Sub key—This key will not work in the glove box.
A transponder chip for engine immobilizer
system has been placed in the head of
the master and sub keys. These chips are
needed to enable the system to function
correctly, so be careful not to lose these
keys. If you make your own duplicate key,
you will not be able to cancel the system
or start the engine.
Keys (without engine
immobilizer system) Keys (with engine immobilizer
system)

’08 Rav4_U (L/O 0802)
15
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
The engine immobilizer system is a
theft prevention system. When you in-
sert the key in the engine switch, the
transponder chip in the key’s head
transmits an electronic code to the ve-
hicle. The engine will start only when
the electronic code in the chip corre-
sponds to the registered ID code for
the vehicle.
Never leave the keys inside the vehicle
when you leave the vehicle.The system is automatically set when the
key is removed from the engine switch.
The indicator light will start flashing to
show the system is set.
In the following cases, contact your Toyota
dealer.
The indicator light stays on.
The indicator light does not start flash-
ing when the key is removed from the
engine switch.
The indicator light flashes inconsistent-
ly.
Inserting the registered key in the engine
switch automatically cancels the system,
which enables the engine to start. The
indicator light will go off. The system is maintenance−
free.
For your Toyota dealer to make you a
new key with built −in transponder chip,
your dealer will need your key number
and master key. However, there is a limit
to the number of additional keys your
Toyota dealer can make for you.
If you make your own duplicate key,
you will not be able to cancel the sys-
tem or start the engine.
NOTICE
Do not modify, remove or disas-
semble the engine immobilizer sys-
tem. If any unauthorized changes or
modifications are made, proper opera-
tion of the system cannot be guaran-
teed.
Engine immobilizer system

’08 Rav4_U (L/O 0802)
142
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
“START”—Starter motor on. The key
will return to the “ON” position when
released.
For starting tips, see page 341 in Section
3.
“ON”—Engine on and all accessories
on.
This is the normal driving position.
“ACC”—Accessories such as the radio
operate, but the engine is off.
If you leave the engine switch in the
“ACC” or “LOCK” position and open the
driver ’s door, a buzzer will remind you to
remove the key.“LOCK”—Engine is off and the steering
wheel is locked. The key can be re-
moved only at this position.
You must push in the key to turn the
engine switch from the “ACC” to “LOCK”
position. The selector lever must be in the
“P” position before pushing the key.
Vehicles with engine immobilizer sys-
tem—Once you remove the key, the en-
gine immobilizer system is automatically
set. (See “Engine immobilizer system” on
page 15 in Section 1
−2.)
When starting the engine, the engine
switch may seem stuck at the “LOCK”
position. To free it, first be sure the key
is pushed all the way in, and then rotate
the steering wheel slightly while turning
the key gently.
Approximately five hours after the engine
is turned off, you may hear sound coming
from under the floor around the driver ’s
seat for several minutes. This is normal
operation and does not indicate a malfunc-
tion. (See “Leak detection pump” on page
ix.)
It is not a malfunction if the needle on all
meters and gauges move slightly when the
engine switch is turned to the “ON” or
“START” position.
NOTICE
Do not leave the engine switch in the
“ON” position if the engine is not
running. The battery will discharge
and the ignition could be damaged.
Engine (ignition) switch

’08 Rav4_U (L/O 0802)
356
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Before making these checks, make sure
you have followed the correct starting pro-
cedure given in “How to start the engine”
on page 342 in Section 3 and that you
have sufficient fuel. If your vehicle is
equipped with the engine immobilizer sys-
tem, also check whether the other keys
will start the engine. If they work, your
key may be broken. Have the key
checked at your Toyota dealer. If none of
your keys work, there may be a malfunc-
tion in the immobilizer system. Call your
Toyota dealer. (See “Keys (with engine
immobilizer system)” on page 12 in Sec-
tion 1−2.)
If the engine is not turning over or is
turning over too slowly— 1. Check that the battery terminals are tight and clean.
2. If the battery terminals are O.K., switch on the interior light.
3. If the light is out, dim or goes out when the starter is cranked, the battery
is discharged. You may try jump start-
ing. See “(c) Jump starting” on page
357 for further instructions.
If the light is O.K., but the engine still will
not start, it needs adjustment or repair.
Call a Toyota dealer or qualified repair
shop. If the engine turns over at its normal
speed but will not start—
1. Turn the engine switch to the “ACC” or “LOCK” position and try starting the
engine again.
2. If the engine will not start, the engine may be flooded because of repeated
cranking. See “(b) Starting a flooded
engine” on page 356 for further instruc-
tions.
3. If the engine still will not start, it needs adjustment or repair. Call a Toyota
dealer or qualified repair shop. If the engine will not start, your engine
may be flooded because of repeated
cranking.
If this happens, turn the engine switch to
the “START” position with the accelerator
pedal fully depressed. Keep the key and
accelerator pedal in these positions for 15
seconds and release them. Then try start-
ing the engine with your foot off the accel-
erator pedal.
If the engine does not start after 15 se-
conds of cranking, release the key, wait
a few minutes and try again.
If the engine still will not start, it needs
adjustment or repair. Call a Toyota dealer
or qualified repair shop for assistance.
NOTICE
Do not crank for more than 30 se-
conds at a time. This may overheat
the starter and wiring systems.
If your vehicle will not start—
(a) Simple checks
(b) Starting a flooded engine

’08 Rav4_U (L/O 0802)
379
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
3. Insert your finger into the hole topush down the shift lock override
button. You can shift out of “P”
position only while pushing the but-
ton.
4. Shift into “N” position.
5. Insert the cover.
6. Start the engine. For your safety, keep the brake pedal depressed.
Be sure to have the system checked by
your Toyota dealer as soon as possible. You can purchase a new key at your
Toyota dealer if you can give them the
key number. If your vehicle is equipped
with the engine immobilizer system, the
dealer will also need your master key.
Vehicles with engine immobilizer system—
Even if you lose only one key, contact
your Toyota dealer to make a new key. If
you lose all your master keys, you cannot
make new keys; the whole engine immobi-
lizer system must be replaced.
See the suggestion given in “Keys (with
engine immobilizer system)” on page 12 in
Section 1
−2.
You can use the wireless remote control
system with the new key. Contact your
Toyota dealer for detailed information.
If your keys are locked in the vehicle and
you cannot get a duplicate, many Toyota
dealers can still open the door for you,
using their special tools. If you must
break a window to get in, we suggest
breaking the smallest side window be-
cause it is the least expensive to replace.
Be extremely cautious to avoid cuts from
the glass.
If you lose your keys

’08 Rav4_U (L/O 0802)
445
2008 RAV4 from Feb. ’08 Prod. (OM42726U)
Console boxRear 293 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,8 . . . . . . . . . . . .
Controls, overhead console 7 . . . . . . . . . . . . .
Controls, steering switches 7 . . . . . . . . . . . . . .
Cooling system
Coolant level 406 . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 360 . . . . . . . . . . . . . . . . .
Radiator and reservoir 406 . . . . . . . . . . . . . .
Radiator cap 360 . . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 346 . . . . . . . . . . . . . . . . . .
Corrosion prevention 382 . . . . . . . . . . . . . . . . .
Cruise control 168 . . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 294 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 294 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Outside rear view mirror 122 . . . . . . . . . . . .
Rear window 122
. . . . . . . . . . . . . . . . . . . . . . .
Dimmer switch, Headlight 114
. . . . . . . . . . . . .
Dinghy towing 347
. . . . . . . . . . . . . . . . . . . . . . .
Directional signals 114
. . . . . . . . . . . . . . . . . . .
Do −it−yourself maintenance
Parts and tools 400
. . . . . . . . . . . . . . . . . . . . .
Service precautions 399
. . . . . . . . . . . . . . . .
Does your vehicle need repairing? 393 . . . . .
Doors
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22
. . . . . . . . . . . . . . . . . . . . . . . . .
Downhill assist control system 158
. . . . . . . . .
Driver ’s seat belt reminder buzzer 129 . . . . . .
Driver ’s seat belt reminder light 129 . . . . . . . . Driving
Automatic transmission 143,147
. . . . . . . . .
Driving tips 342
. . . . . . . . . . . . . . . . . . . . . . . .
Driving in the rain 344
. . . . . . . . . . . . . . . . . . . .
Driving tips
Driving in the rain 344
. . . . . . . . . . . . . . . . . .
Driving tips in various conditions 343 . . . . .
Driving with an automatic transmission 143,147
. . . . . . . . . . . . . . . . .
Economical driving 353
. . . . . . . . . . . . . . . . .
Good driving practice 143,147
. . . . . . . . . . .
Winter driving tips 346
. . . . . . . . . . . . . . . . . .
During
Break −in 309
. . . . . . . . . . . . . . . . . . . . . . . . . .
DVD player 194
. . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 353 . . . . . . . . . . . . . . . . . .
Electric moon roof 30 . . . . . . . . . . . . . . . . . . . . .
Electric power steering system 320 . . . . . . . .
Electric power steering system warning light 129 . . . . . . . . . . . . . . . . . . . . . . .
Electrical system
Battery 418,420 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 398 . . . . . . . . . . . . . . . . . . . . .
Fuses 420 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 116 . . . . . . . . . . . . .
Emergency, In case of
Blown fuse 420 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 116 . . . . . . . . . . .
Flat tire 361 . . . . . . . . . . . . . . . . . . . . . . . . . . . If you cannot increase
engine speed 359 . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 378 . . . . . . . .
If you lose your keys 379 . . . . . . . . . . . . . . . .
If your engine stalls while driving 359 . . . . .
If your vehicle becomes stuck 373 . . . . . . .
If your vehicle needs to be towed 373 . . . . .
If your vehicle will not start 356 . . . . . . . . . .
Jump starting 357 . . . . . . . . . . . . . . . . . . . . . .
Overheating 360 . . . . . . . . . . . . . . . . . . . . . . .
Towing 373 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and
Maintenance (I/M) programs 394 . . . . . . . . .
Engine
Before starting the engine 342 . . . . . . . . . . .
Checking the coolant level 406 . . . . . . . . . .
Emission control device 312 . . . . . . . . . . . . .
Engine compartment 396 . . . . . . . . . . . . . . .
Exhaust gas caution 313 . . . . . . . . . . . . . . . .
Hood release 27 . . . . . . . . . . . . . . . . . . . . . . .
Identification number 322 . . . . . . . . . . . . . . .
Oil consumption 314 . . . . . . . . . . . . . . . . . . . .
Oil level 404 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 360 . . . . . . . . . . . . . . . . . . . . . . .
Starting procedure 342 . . . . . . . . . . . . . . . . .
Three −way catalytic converters 312 . . . . . .
Engine coolant
Temperature gauge 126 . . . . . . . . . . . . . . . . .
Winter driving tips 346 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 126 . . . . .
Engine immobilizer system 15 . . . . . . . . . . . . .
Engine oil
Winter driving tips 346 . . . . . . . . . . . . . . . . . .