automatic transmission TOYOTA SEQUOIA 2001 Service User Guide

PP42M±01
PP±34
± PREPARATIONAUTOMATIC TRANSMISSION (A750E, A750F)
92 Author: Date:
2005 SEQUOIA (RM1146U)
EQUIPMENT
OBD II scan tool
Torque wrench
CalipersTorque converter clutch
Straight edgeTorque converter clutch
Dial indicatorDrive plate runout

PP42N±01
± PREPARATIONAUTOMATIC TRANSMISSION (A750E, A750F)
PP±35
93 Author: Date:
2005 SEQUOIA (RM1146U)
LUBRICANT
ItemCapacityClassification
Automatic transmission fluid
Dry fill
Drain and refill
10.4 liters (11.0 US qts, 9.2 lmp qts)
3.0 liters (3.2 US qts, 2.6 lmp qts)Toyota Genuine ATF WS

PP±46
± PREPARATIONSUSPENSION AND AXLE
104 Author: Date:
2005 SEQUOIA (RM1146U)
09350±20015TOYOTA Automatic Transmission
Tool SetFront differential
(09369±20040)Piston Spring Compressor Set
09502±12010Differential Bearing ReplacerFront differential
Front suspension
09504±22012Differential Side Bearing
ReplacerRear differential
09506±30012Differential Drive Pinion Rear
Bearing Cone ReplacerFront differential
09506±35010Differential Drive Pinion Rear
Bearing ReplacerRear differential
09520±01010Drive Shaft Remover AttachmentFront drive shaft
09520±24010Differential Side Gear Shaft
PullerFront drive shaft
(09520±32040)Shocker Set
09521±24010Drive Shaft Boot Clamping ToolFront drive shaft
09521±25011Rear Axle Shaft PullerRear axle
09521±25021Rear Axle Shaft Puller
AttachmentRear axle
09523±36010Rear Axle Hub Guide ToolRear differential

SS1M9±01
SS±24
± SERVICE SPECIFICATIONSAUTOMATIC TRANSMISSION (A750E, A750F)
166 Author: Date:
2005 SEQUOIA (RM1146U)
AUTOMATIC TRANSMISSION (A750E, A750F)
SERVICE DATA
2UZ±FE (A750E/A750F)
Line pressure (Wheel locked)
Engine idling
D position
R position
AT stall (Throttle valve fully opened)
D position
R position
361 ± 421 kPa (3.7 ± 4.3 kgfVcm2, 52 ± 61 psi)
495 ± 576 kPa (5.0 ± 5.9 kgfVcm2, 72 ± 84 psi)
1,236 ± 1,332kPa (12.6 ± 13.6 kgfVcm
2, 179 ± 193 psi)
1,229 ± 1,349 kPa (12.5 ± 13.8 kgfVcm2, 178 ± 196 psi)
Engine stall revolution D and R positions2,200
150 rpm
Time lag N " D position
N " R positionLess than 1.2 seconds
Less than 1.5 seconds
Engine idle speed
(A/C OFF) N position
700
50 rpm
Drive plate runoutMax.
Torque converter runout Max.0.20 mm (0.0079 in.)
0.30 mm (0.0118 in.)
Shift schedule
D position
(Throttle valve fully opened) 1 " 2
2 " 3
3 " 4
4 " 5
5 " 4
4 " 3
3 " 2
2 " 1
(Throttle valve fully closed) 4 " 5
5 " 4
4 position (O/D OFF)
(Throttle valve fully opened) 1 " 2
2 " 3
3 " 4
5 " 4
4 " 3
3 " 2
2 " 1
3 position
(Throttle valve fully opened) 1 " 2
2 " 3
4 " 3
3 " 2
2 " 1
2 position
(Throttle valve fully opened) 1 " 2
3 " 2
2 " 1
L position
(Throttle valve fully opened) 2 " 1
45 ± 57 km/h (28 ± 35 mph)
84 ± 97 km/h (52 ± 60 mph)
120 ± 138 km/h (75 ± 86 mph)
163 ± 179 km/h (101 ± 111 mph)
158 ± 174 km/h (98 ± 108 mph)
110 ± 124 km/h (68 ± 77 mph)
75 ± 83 km/h (47 ± 52 mph)
35 ± 41 km/h (22 ± 25 mph)
44 ± 50 km/h (27 ± 31 mph)
22 ± 28 km/h (14 ± 17 mph)
45 ± 57 km/h (28 ± 35 mph)
84 ± 97 km/h (52 ± 60 mph)
120 ± 138 km/h (75 ± 86 mph)
173 ± 190 km/h (108 ± 118 mph)
110 ± 124 km/h (68 ± 77 mph)
75 ± 83 km/h (47 ± 52 mph)
35 ± 41 km/h (22 ± 25 mph)
45 ± 57 km/h (28 ± 35 mph)
84 ± 97 km/h (52 ± 60 mph)
121 ± 135 km/h (75 ± 84 mph)
75 ± 83 km/h (47 ± 52 mph)
35 ± 41 km/h (22 ± 25 mph)
45 ± 57 km/h (28 ± 35 mph)
80 ± 92 km/h (50 ± 57 mph)
35 ± 41 km/h (22 ± 25 mph)
35 ± 41 km/h (22 ± 25 mph)
Lock±up point Throttle valve opening 5 %
D position
5th gear Lock±up ON
Lock±up OFF
4 position
4th gear Lock±up ON
Lock±up OFF
63 ± 71 km/h (39 ± 44 mph)
57 ± 64 km/h (35 ± 40 mph)
102 ± 112 km/h (63 ± 70 mph)
96 ± 105 km/h (60 ± 65 mph)

SS1MA±01
± SERVICE SPECIFICATIONSAUTOMATIC TRANSMISSION (A750E, A750F)
SS±25
167 Author: Date:
2005 SEQUOIA (RM1146U)
TORQUE SPECIFICATION
Part tightenedN´mkgf´cmft´lbf
Drain plug x Oil pan2020415
Overflow plug x Oil pan2020415
Refill plug x Transmission case3940029
No.1 vehicle speed sensor A750E
A750F9.8
11.5100
11 786 in.Vlbf
8
Speed sensor NT x Automatic transmission5.45548 in.Vlbf
Speed sensor SP2 x Automatic transmission5.45548 in.Vlbf
Transmission wire set bolt x Automatic transmission5.45548 in.Vlbf
Transmission wire clamp x Valve body A
B11
1011 2
1008
7
Oil pan x Transmission case4.44539 in.Vlbf
Park/neutral position switch Bolt
Nut13
6.9130
7010
61 in.Vlbf
Shift solenoid valve S1 x Valve body6.46556 in.Vlbf
Shift solenoid valve S2 x Valve body101027
Shift solenoid valve SR x Valve body6.46557 in.Vlbf
Shift solenoid valve SLU, SL2 x Valve body6.46557 in.Vlbf
Shift solenoid valve SLT, SL1 x Valve body6.46557 in.Vlbf
Valve body x Transmission case1111 28
Oil strainer x Valve body101007
Parking lock pawl bracket x Transmission case7.47565 in.´lbf
Oil cooler x Body1111 08
Transmission oil cooler bracket x Oil cooler4.95043 in.´lbf
Oil cooler tube clamp x Body5.05048 in.´lbf
Shift lever x Shift lever housing1818013
Shift lever housing x Steering column assemby121209
Parking lock cable No. 1 x Shift lever housing2.92925 in.´lbf
Parking lock cable No. 2 x Column upper bracket2.22319 in.´lbf
Parking lock cable housing x Steering column assembly10.511 08
Front suspension member bracket x Body3333624
Heat insulator1616412
Shift control cable x Transmission14.514811
Shift control cable bracket x Transmission19.519914
Oil cooler pipe clamp x Transmission121229
Oil cooler pipe x Transmission3434625
Stabilizer bar3737727
Rear end plate x Transmission1818513
Torque converter clutch x Drive plate4849035
Engine rear mounting insulator x Crossmember1818513
Crossmember x Frame7273453
Engine rear mounting insulator x Extension housing6566048
Automatic transmission x Engine 17 mm head
14 mm head71
37720
38053
27

DID7M±01
± DIAGNOSTICSENGINE
DI±1
195 Author: Date:
2005 SEQUOIA (RM1146U)
ENGINE
PRECAUTION
NOTICE:

When disconnecting the battery terminal, initialize the following system after the terminal is re-
connected.
System NameSee Page
Back Door Power Window Control SystemBE±77

Perform the RESET MEMORY (AT initialization) when replacing the automatic transmission as-
sembly, engine assembly or ECM (See page DI±543).
HINT:
Initialization can not be completed by only removing the battery.

DI±4
± DIAGNOSTICSENGINE
198 Author: Date:
2005 SEQUOIA (RM1146U) Speed sensor, Vehicle speed sensor ºAº, Speed sensor for
skid control ECU
Vehicle speed sensor
ATF temperature sensor, Trans. fluid temp. sensor, ATF
temperature sensor ºAºTransmission fluid temperature sensor
Electronic controlled automatic transmission, ECTElectronically controlled automatic
Intermediate shaft speed sensor ºAºCounter gear speed sensor
Output speed sensorOutput shaft speed sensor
Input speed sensor, Input turbine speed sensor ºAº, Speed
sensor (NT), Turbine speed sensorInput turbine speed sensor
PNP switch, NSWPark/neutral position switch
Pressure control solenoidTransmission pressure control solenoid
Shift solenoidTransmission shift solenoid valve
Transmission control switch, Shift lock control unitShift lock control module
Engine immobiliser system, Immobiliser systemVehicle anti±theft system
Air switching valve (ASV)Secondary air injection control valve
AI systemSecondary air injection system
Air pumpSecondary air injection pump
Air switching valve No.2 (ASV No.2)Secondary air injection bypass valve Bank 1, 2
VSV for air injection controlSecondary air injection vacuum switching valve
Air injection driverSecondary air injection driver

± DIAGNOSTICSENGINE
DI±67
261 Author: Date:
2005 SEQUOIA (RM1146U)P0617
(DI±298)
Starter Relay Circuit High

Park/neutral position switch

Starter relay circuit

Ignition switch

ECM

P0630
(DI±302)VIN not Programmed or Mis-
match±ECM/PCM
ECM
P0657
(DI±296)Actuator Supply Voltage Circuit/
Open
ECM
P0705
(DI±576)Transmission Range Sensor Cir-
cuit Malfunction (PRNDL Input)
Electronic Controlled Automatic Transaxle (ECT)
P0710
(DI±582)Transmission Fluid Temperature
Sensor ºAº Circuit
Electronic control automatic transmission (ECT)
P0711
(DI±588)Transmission Fluid Temperature
Sensor ºAº Performance
Electronic control automatic transmission (ECT)
P0712
(DI±582)Transmission Fluid Temperature
Sensor ºAº Circuit Low Input
Electronic control automatic transmission (ECT)
P0713
(DI±582)Transmission Fluid Temperature
Sensor ºAº Circuit High Input
Electronic control automatic transmission (ECT)
P0717
(DI±591)Input/Turbine Speed Sensor ºAº
Circuit No Signal
Electronic control automatic transmission (ECT)
P0722
(DI±596)Output Speed Sensor Circuit No
Signal
Electronic control automatic transmission (ECT)
P0724
(DI±600)Brake Switch ºBº Circuit High
Electronic control automatic transmission (ECT)
P0748
(DI±603)Pressure Control Solenoid ºAº
Electrical (Shift Solenoid Valve
SL1)

Electronic control automatic transmission (ECT)
P0751
(DI±608)Shift Solenoid ºAº Performance
(Shift Solenoid Valve S1)
Electronic control automatic transmission (ECT)
P0756
(DI±614)Shift Solenoid ºBº Performance
(Shift Solenoid Valve S2)
Electronic control automatic transmission (ECT)
P0771
(DI±620)Shift Solenoid ºEº Performance
(Shift Solenoid Valve SR)
Electronic control automatic transmission (ECT)
P0776
(DI±625)Pressure Control Solenoid ºBº
Performance (Shift Solenoid
Valve SL2)

Electronic control automatic transmission (ECT)
P0778
(DI±631)Pressure Control Solenoid ºBº
Electrical (Shift Solenoid Valve
SL2)

Electronic control automatic transmission (ECT)
P0781
(DI±636)1±2 Shift (1±2 Shift Valve)
Electronic control automatic transmission (ECT)
P0973
(DI±641)Shift Solenoid ºAº Control Circuit
Low (Shift solenoid Valve S1)
Electronic control automatic transmission (ECT)
P0974
(DI±641)Shift Solenoid ºAº Control Circuit
High (Shift solenoid Valve S1)
Electronic control automatic transmission (ECT)
P0976
(DI±646)Shift Solenoid ºBº Control Circuit
Low (Shift solenoid Valve S2)
Electronic control automatic transmission (ECT)
P0977
(DI±646)Shift Solenoid ºBº Control Circuit
High (Shift solenoid Valve S2)
Electronic control automatic transmission (ECT)
P0985
(DI±651)Shift Solenoid ºEº Control Circuit
Low (Shift Solenoid Valve SR)
Electronic control automatic transmission (ECT)

DI±68
± DIAGNOSTICSENGINE
262 Author: Date:
2005 SEQUOIA (RM1146U)P0986
(DI±651)
Shift Solenoid ºEº Control Circuit
High (Shift Solenoid Valve SR)
Electronic control automatic transmission (ECT)
P1340
(DI±304)Camshaft Position Sensor ºAº
Circuit (Bank 1 Sensor 2)

Open or short in camshaft position sensor circuit

Camshaft position sensor

LH camshaft timing pulley

ECM

P1341
(DI±304)Camshaft Position Sensor ºAº
Circuit Range/Performance
(Bank 1 Sensor 2)
Open or short in camshaft position sensor circuit

Camshaft position sensor

LH camshaft timing pulley

ECM

P1440
(DI±309)Scondary Air Injection System
Control Valve Circuit Bank 1
Open or short in VSV for air injection control circuit

ECM
P1441
(DI±314)Scondary Air Injection System
Switching Valve No.2 Bank 1
Stuck Open
VSV for air injection control circuit (Bank 1)

Air switching valve No.2 (Bank 1)

VSV for air injection system (Bank 1)

ECM

P1442
(DI±330)Scondary Air Injection System
Switching Valve No.2 Bank 1
Stuck Close

VSV for air injection control circuit (Bank 1)

Vacuum hose (VSV for air injection control ± air switching
valve No.2)

Air injector pipe (Air switching valve No.2 ± exhaust manifold)

Air switching valve No.2 (Bank 1)

VSV for air injection control (Bank 1)

ECM

P1443
(DI±309)Scondary Air Injection System
Control Valve Circuit Bank 2
Open or short in VSV for air injection control circuit

ECM
P1444
(DI±314)Scondary Air Injection System
Switching Valve No.2 Bank 2
Stuck Open
VSV for air injection control circuit (Bank 2)

Air switching valve No.2 (Bank 2)

VSV for air injection system (Bank 2)

ECM

P1445
(DI±330)Scondary Air Injection System
Switching Valve No.2 Bank 2
Stuck Cloes

VSV for air injection control circuit (Bank 2)

Vacuum hose (VSV for air injection control ± air switching
valve No.2)

Air injector pipe (Air switching valve No.2 ± exhaust manifold)

Air switching valve No.2 (Bank 2)

VSV for air injection control (Bank 2)

ECM

P1613
(DI±343)Air Injection System Air Injection
Driver

Short between air pump circuit and body ground

Open in air pump drive circuit

Short between air pump circuit and +B circuit

Air injection driver

ECM

P2102
(DI±354)Throttle Actuator Control Motor
Circuit Low
Open in throttle control motor and sensor circuit

Throttle control motor and sensor

ECM

P2103
(DI±354)Throttle Actuator Control Motor
Circuit High

Short in throttle control motor and sensor circuit

Throttle control motor and sensor

Throttle valve

Throttle body

ECM

P2111
(DI±358)Throttle Actuator Control System
± Stuck Open

Throttle control motor and sensor circuit

Throttle control motor and sensor

Throttle valve

Throttle body


DI±72
± DIAGNOSTICSENGINE
266 Author: Date:
2005 SEQUOIA (RM1146U)P2445
(DI±426)
Secondary Air Injection System
Pump Stuck On Bank 1

Air pump fuse

Vacuum hose

Air pump assembly

Open in air pump circuit

Air injection system piping

Pressure sensor

Open or short in pressure sensor circuit

ECM

P2610
(DI±442)ECM/PCM Internal Engine Off
Timer Performance
ECM
P2714
(DI±656)Pressure Control Solenoid ºDº
Performance (Shift Solenoid
Valve SLT)

Electronic control automatic transmission (ECT)
P2716
(DI±662)Pressure Control Solenoid ºDº
Electrical (Shift Solenoid Valve
SLT)

Electronic control automatic transmission (ECT)
P2740
(DI±666)Transmission Fluid Temperature
Sensor ºBº Circuit
Electronic control automatic transmission (ECT)
P2742
(DI±666)Transmission Fluid Temperature
Sensor ºBº Circuit Low Input
Electronic control automatic transmission (ECT)
2743
(DI±666)Transmission Fluid Temperature
Sensor ºBº Circuit High Input
Electronic control automatic transmission (ECT)
P2757
(DI±672)
Torque Converter clutch Pres-
sure Control Solenoid Perfor-
mance (Shift Solenoid Valve
SLU)

Electronic control automatic transmission (ECT)
P2759
(DI±680)Torque Converter clutch Pres-
sure Control Solenoid Electrical
(Shift Solenoid Valve SLU)

Electronic control automatic transmission (ECT)
P2772
(DI±685)Transfer L4 SW Circuit
Electronic control automatic transmission (ECT)
P2A00
(DI±451)A/F Sensor Circuit Slow Re-
sponse (Bank 1 Sensor 1)
Open or short in A/F sensor (sensor 1) circuit

A/F sensor (sensor 1)

ECM

P2A03
(DI±451)A/F Sensor Circuit Slow Re-
sponse (Bank 2 Sensor 1)
Open or short in A/F sensor (sensor 1) circuit

A/F sensor (sensor 1)

ECM

B2799
(DI±1580)Engine Immobilizer System Mal-
function
Immobilizer system±
U0001
(DI±444)High Speed CAN Communica-
tion Bus
ECM
*1: ± .... MIL does not light up.  .... MIL lights up.
*2: MIL lights up or blinks.