cooling TOYOTA SEQUOIA 2002 1.G User Guide

02_SEQUOIA_U (L/O 0108)
2922002 MY SEQUOIA_U (OM34418U)
CAUTION
Do not exceed 50 km/h (30 mph) or
the chain manufacturer ’s recom-
mended speed limit, whichever is
lower.
Drive carefully avoiding bumps,
holes, and sharp turns, which may
cause the vehicle to bounce.
Avoid sharp turns or lockedwheel
braking, as use of chains may ad-
versely affect vehicle handling.
When driving with chains installed,
be sure to drive carefully. Slow
down before entering the curves to
avoid losing control of the vehicle.
Otherwise an accident may occur.
WHEN TO REPLACE YOUR WHEELS
If you have wheel damage such as
bending, cracks or heavy corrosion, the
wheel should be replaced.
If you fail to replace damaged wheels, the
tire may slip off the wheel or cause loss
of handling control.
WHEEL SELECTION
When replacing wheels, care should be
taken to ensure that the wheels are re-
placed by ones with the same load ca-
pacity, diameter, rim width, and offset.
Correct replacement wheels are available
at your Toyota dealer.
A wheel of a different size or type may
adversely affect handling, wheel and bear-
ing life, brake cooling, speedometer/odom-
eter calibration, stopping ability, headlight
aim, bumper height, vehicle ground clear-
ance, and tire or snow chain clearance to
the body and chassis. Replacement with used wheels is not rec-
ommended as they may have been sub-
jected to rough treatment or high mileage
and could fail without warning. Also, bent
wheels which have been straightened may
have structural damage and therefore
should not be used. Never use an inner
tube in a leaking wheel which is designed
for a tubeless tire.
Replacing wheels

02_SEQUOIA_U (L/O 0108)
3102002 MY SEQUOIA_U (OM34418U)
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):With rear heater 13.4 (14.1, 11.8)
Without rear heater 11.7 (12.4, 10.2)
Coolant type:
“TOYOTA Long Life Coolant” or equiva-
lent
With ethyleneglycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af- ter the key is removed with all the
lights turned off
Charging rates: 5 A max. AUTOMATIC TRANSMISSION
Fluid capacity (drain and ref
ill),
L (qt., Imp. qt.):
Up to 2.0 (2.1, 1.8)
Fluid type: Automatic transmission fluid DII or
DEXRON III (DEXRON II)
TRANSFER
Oil capacity, L (qt., Imp. qt.): 1.2 (1.3, 1.1)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90
DIFFERENTIAL
Oil capacity, L (qt., Imp. qt.): Front
1.15 (1.2, 1.0)
Rear 3.65 (3.9, 3.3)
Oil type: Hypoid gear oil API GL5 Recommended oil viscosity:
FrontSAE 75W90
Rear Above 18 C (0 F)
SAE 90
Below 18 C (0 F)
SAE 80W or 80W90
CHASSIS LUBRICATION
Propeller shafts: Spiders and slide yokesLithium base chassis grease, NLGI
No.2
BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine stopping and after de-
pressing the brake pedal several times,
mm (in.): 113 (4.5)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)

02_SEQUOIA_U (L/O 0108)
3132002 MY SEQUOIA_U (OM34418U)
Engine compartment
5. HLP LL 10 A (with daytime runninglight system): Lefthand headlight (low
beam)
6. CDS FAN 25 A: Electric cooling fan
7. SPARE 10 A: Spare fuse
8. SPARE 15 A: Spare fuse
9. SPARE 20 A: Spare fuse
10. ETCS 15 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system, electronic throttle control
system
Instrument panel
11. EFI NO.1 20 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system, electric throttle control
system
12. HLP RH 15 A (without daytime run- ning light system): Righthand head-
light
13. TOWING 30 A: Trailer lights (stop
lights, turn signal lights, tail lights,
backup lights)
14. ALTS 7.5 A: Charging system 15. DRL 7.5 A (with daytime running
light system): Multiplex communication
system (power door lock system, secu-
rity system, autodoor locking system,
automatic light control system, head-
light delay off system, tail light auto
cut system, illuminated entry system,
daytime running light system)
HLP LH 15 A (without daytime run-
ning light system): Lefthand head-
light
16. AM2 30 A: Starting system, multiport
fuel injection system/sequential multi-
port fuel injection system, electronic
throttle control system, “IGN 1” and
“IGN 2” fuses
17. TURNHAZ 20 A: Turn signal lights,
emergency flashers
18. RAD NO.3 20 A: Car audio system
19. HORN 10 A: Horns
20. EFI NO.2 10 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system, electronic throttle control
system

02_SEQUOIA_U (L/O 0108)
3152002 MY SEQUOIA_U (OM34418U)
36. PANEL 7.5 A: Instrument panel lights,
glove box light, lights of seat heaters,
cigarette lighter, ashtrays, multiinfor-
mation display, car audio system,
gauge and meters and air conditioning
systems
37. PWR NO.1 25 A: Driver ’s door lock
system
38. WIP 25 A: Wiper and washers
39. IGN 1 10 A: Charging system
40. SUN ROOF 25 A: Electric moon roof
41. PWR NO.2 25 A: Front passengers’
door lock system
42. HTR 10 A: Air conditioning systems,
electric cooling fan, back window de-
fogger, outside rear view mirror heater
43. FOG 15 A: Front fog lights
44. GAUGE 10 A: Backup lights, seat
heaters, gauge and meters, air condi-
tioning systems
45. PWR OUTLET 15 A: Power outlets
46. SEAT HEATER 15 A: Seat heaters
Fuses (type B)
47. RR HEATER 30 A: Rear air condition-
ing system
48. HEATER 40 A: Front air conditioning
system 49. DEFOG 40 A:
Back window defogger
50. MAIN 40 A: Starting system, “HLP
RH”, “HLP LH” and “STA” fuses
51. DOOR NO.2 30 A: Multiplex commu-
nication system (power door lock sys-
tem, security system, autodoor locking
system)
52. PWR SEAT 30 A: Power front seats
53. AM1 40 A: “HTR”, “CIG”, “GAUGE”,
“RAD NO.2”, “ECUIG”, “WIPER”,
“WSH” and “4WD” fuses
54. PWR NO.5 30 A: Power door lock sys-
tem, back door lock system
Fuses (type C)
55. ALT 120 A: “AM1”, “PWR SEAT”,
“TAIL”, “STOP”, “SUN ROOF”, “PANEL”,
“OBD”, “FOG”, “PWR NO.1”, “PWR
NO.2”, “PWR NO.5”, “PWR NO.3”,
“PWR NO.4”, “PWR OUTLET” and
“SEAT HTR” fuses
56. ABS 60 A: Antilock brake system,
vehicle skid control system, traction
control system (twowheel drive mod-
els), active traction control system
(fourwheel drive models)

02_SEQUOIA_U (L/O 0108)
3232002 MY SEQUOIA_U (OM34418U)
Cooling systemCoolant level 285 . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 248 . . . . . . . . . . . . . . . . .
Radiator and reservoir 285 . . . . . . . . . . . . . .
Radiator cap 248 . . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Corrosion prevention 264 . . . . . . . . . . . . . . . . .
Cruise control 148 . . . . . . . . . . . . . . . . . . . . . . .
Cup holders 205 . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Back window 119 . . . . . . . . . . . . . . . . . . . . . .
Outside rear view mirror 119 . . . . . . . . . . . .
Dimmer switch, Headlight 110,112 . . . . . . . . .
Dinghy towing 233 . . . . . . . . . . . . . . . . . . . . . . .
Directional signals 110,112 . . . . . . . . . . . . . . .
Discharge warning light 125 . . . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 281 . . . . . . . . . . . . . . . . . . . . .
Service precautions 280 . . . . . . . . . . . . . . . .
Does your vehicle need repairing? 275 . . . . .
Doors
Side doors 12 . . . . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 125 . . . . . .
Driver ’s seat belt reminder light 125 . . . . . . . .
Driving
Automatic transmission 133 . . . . . . . . . . . . .
Driving tips 228 . . . . . . . . . . . . . . . . . . . . . . . .
Driving tips
Driving tips in various conditions 229 . . . . .
Driving with an automatic transmission 133 . . . . . . . .
Economical driving 240 . . . . . . . . . . . . . . . . . Good driving practice 133
. . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
During
Breakin 213 . . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 240 . . . . . . . . . . . . . . . . . . . . . .
Electric moon roof 32 . . . . . . . . . . . . . . . . . . . . .
Electrical system,
Battery 296,297 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 279 . . . . . . . . . . . . . . . . . . . . .
Fuses 298 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 113 . . . . . . . . . . . . .
Emergency, In case of8
Blown fuse 298 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 113 . . . . . . . . . . .
Flat tire 249 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the engine speed 247 . . . . . . . . . . . . . . . . .
If you lose your keys 261 . . . . . . . . . . . . . . . .
If you lose your wireless remote control transmitter 261 . . . . . . . . . . . . . . . .
If your engine stalls while driving 247 . . . . .
If your vehicle needs to be towed 257 . . . . .
If your vehicle will not start 244 . . . . . . . . . .
Jump starting 245 . . . . . . . . . . . . . . . . . . . . . .
Overheating 248 . . . . . . . . . . . . . . . . . . . . . . .
Towing 257 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and
Maintenance (I/M) programs 276 . . . . . . . . . Engine
Before starting the engine 228 . . . . . . . . . . .
Checking the coolant level 285 . . . . . . . . . .
Emission control device 216 . . . . . . . . . . . . .
Engine compartment 278 . . . . . . . . . . . . . . .
Exhaust gas caution 217 . . . . . . . . . . . . . . . .
Hood release 29 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 217 . . . . . . . . . . . . . . . . . . . .
Oil level 284 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil pressure gauge 123 . . . . . . . . . . . . . . . . .
Overheating 248 . . . . . . . . . . . . . . . . . . . . . . .
Starting procedure 228 . . . . . . . . . . . . . . . . .
Threeway catalytic converter 216 . . . . . . .
Engine coolant
Temperature gauge 122 . . . . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 122 . . . . .
Engine immobiliser system 10 . . . . . . . . . . . . .
Engine oil
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 123 . . . . . . . . . . . . .
Exhaust gas caution 217 . . . . . . . . . . . . . . . . . .
F
Facts about engine oil consumption 217 . . . .
Flasher, Headlight 110,112 . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 256 . . . . . . . . . . . . . .
Changing tire 254 . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 249 . . . . . . . . . . . . . . . .
Jack point 252 . . . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 249 . . . . . . . . . . . . . . . .
Jacking up 253 . . . . . . . . . . . . . . . . . . . . . . . .