check transmission fluid TOYOTA SEQUOIA 2002 1.G Owners Manual

02_SEQUOIA_U (L/O 0108)
1302002 MY SEQUOIA_U (OM34418U)
(m) Automatic Transmission Fluid Tem-perature Warning Light
This light warns that the automatic trans-
mission fluid temperature is too high.
If this light comes on while you are driv-
ing, slow down and pull off the road. Stop
the vehicle at a safe place and put the
selector lever in “P”. With the engine id-
ling, wait until the light goes off. If the
light goes off, you may start the vehicle
again. If the light does not go off, call a
Toyota dealer or qualified repair shop for
assistance.
NOTICE
Continued driving with the warning
light on may damage the automatic
transmission.
(n) Low windshield Washer Fluid Level Warning Light
This light warns that the windshield wash-
er fluid level is too low. Add washer fluid
at your earliest opportunity. (For instruc-
tions, see “Adding washer fluid” on page
299 in Section 73.) CHECKING SERVICE REMINDER
INDICATORS (except the low fuel level
warning light and low windshield
washer fluid level warning light)
1. Apply the parking brake.
2. Open one of the side doors or back door.
The open door warning light should
come on.
3. Close the door. The open door warning light should go
off.
4. Turn the ignition key to “ON”, but do not start the engine.
All the service reminder indicators ex-
cept the open door warning light should
come on. The “ABS” and “VSC/TRAC”
warning lights, “TRAC OFF” (twowheel
drive models) or “VSC OFF” (four
wheel drive models) indicator light and
slip indicator light go off after a few
seconds. The SRS warning light goes
off after about 6 seconds.
5. Place the fourwheel control lever in “N” position and the selector lever in
“P” position.
The unengaged “Park” warning light
should come on. 6. Shift the fourwheel drive control lever
out of “N”.
The unengaged “Park” warning light
should go off.
If any service reminder indicator or warn-
ing buzzer does not function as described
above, have it checked by your Toyota
dealer as soon as possible.

02_SEQUOIA_U (L/O 0108)
2482002 MY SEQUOIA_U (OM34418U)
If your engine coolant temperature
gauge indicates overheating, if you ex-
perience a loss of power, or if you hear
a loud knocking or pinging noise, the
engine has probably overheated. You
should follow this procedure...1. Pull safely off the road, stop the ve- hicle and turn on your emergency
flashers. Put the transmission in “P”
and apply the parking brake. Turn off
the air conditioning if it is being used.
2. If coolant or steam is boiling out of the radiator or reservoir, stop the engine.
Wait until the steam subsides before
opening the hood. If there is no coolant
boiling over or steam, leave the engine
running.
CAUTION
To help avoid personal injury, keep
the hood closed until there is no
steam. Escaping steam or coolant is
a sign of very high pressure.
3. Visually check to see if the enginedrive belt (fan belt) is broken or loose.
Look for obvious coolant leaks from the
radiator, hoses, and under the vehicle.
However, note that water draining from
the air conditioning is normal if it has
been used.
CAUTION
When the engine is running, keep
hands and clothing away from the
moving fan and engine drive belts.
4. If the engine drive belt is broken or thecoolant is leaking, stop the engine im-
mediately. Call a Toyota dealer for as-
sistance.
5. If the engine drive belt is O.K. and there are no obvious leaks, you may
help the engine cool down more quickly
by running it at about 1500 rpm for a
few minutes with the accelerator pedal
lightly depressed.
6. Check the coolant reservoir. If it is dry, add coolant to the reservoir while the
engine is running. Fill it about half full.
CAUTION
Do not attempt to remove the radiator
cap when the engine and radiator are
hot. Serious injury could result from
scalding hot fluid and steam blown
out under pressure.
7. After the engine coolant temperaturehas cooled to normal, again check the
coolant level in the reservoir. If neces-
sary, bring it up to half full again. Seri-
ous coolant loss indicates a leak in the
system. You s hould have it checked as
soon as possible at your Toyota dealer.
If your vehicle overheats

02_SEQUOIA_U (L/O 0108)
2742002 MY SEQUOIA_U (OM34418U)
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working. Check headlight aim.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Check that it has the specified free play.
Be alert for changes in steering condition,
such as hard steering or strange noise.
Seats
Check that all seat controls such as seat
adjusters, seatback recliner, etc. operate
smoothly and that all latches lock securely
in any position. Check that the head re-
straint move up and down smoothly and
that the locks hold securely in any latched
position. For foldingdown rear seatbacks,
swingup rear seat cushions and detach-
able temporary third seat, check that the
latches lock securely.Seat belts
Check that the seat belt system such as
buckles, retractors and anchors operate
properly and smoothly. Make sure the belt
webbing is not cut, frayed, worn or dam-
aged.
Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the pedal has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.
Automatic transmission “Park” mecha-
nism
Check the lock release button of the se-
lector lever for proper and smooth opera-
tion. On a safe incline, check that your
vehicle is held securely with the selector
lever in “P” position and all brakes re-
leased.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 299 in Section 73 for
additional information.
Engine coolant level
Make sure the coolant level is between
the “F” and “L” lines on the seethrough
reservoir when the engine is cold. See
page 285 in Section 72 for additional
information.
Radiator, condenser and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt, or insects. See page 286 in
Section 72 for additional information.

02_SEQUOIA_U (L/O 0108)
2812002 MY SEQUOIA_U (OM34418U)
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
 Add only demineralized or distilled
water to fill the radiator. And if you
spill some of the coolant, be sure
to wash it off with water to prevent
it from damaging the parts or paint.
 Do not allow dirt or anything else
to fall through the spark plug holes.
 Do not pry the outer electrode of a
spark plug against the center elec-
trode.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not overfill automatic transmis-
sion fluid, or the transmission
could be damaged.
Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.
 When closing the engine hood,
check to see that you have not for-
gotten any tools, rags, etc.Here is a list of parts and tools you will
need on performing doityourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
Engine oil API grade SJ,
“EnergyConserving” or ILSAC
multigrade having viscosity proper for
your climate
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“TOYOTA Long Life Coolant” or equiva-
lent
See page 285 in Section 72 for de-
tails about coolant type selection.
Demineralized or distilled water
Tools:
Funnel (only for adding coolant)
Parts and tools

02_SEQUOIA_U (L/O 0108)
2822002 MY SEQUOIA_U (OM34418U)
CHECKING BRAKE FLUID
Parts (if level is low):
SAE J1703 or FMVSS No.116 DOT 3
brake fluid
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Automatic transmission fluid
DEXRON II or III
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts) CHECKING AND REPLACING FUSES
Parts (if replacement is necessary):
Fuse with same amperage rating as
original
Tools:
Conventional wrench (for instrument
lower panel nut)
ADDING WASHER FLUID
Parts:
Water
Washer fluid containing antifreeze
(for winter use)
Tools:
Funnel
REPLACING LIGHT BULBS
Parts:
Bulb with same number and wattage
rating as original (See charts in “Re-
placing light bulbs” on page 300 in
Section 73.)
Tools:
Screwdriver

02_SEQUOIA_U (L/O 0108)
2882002 MY SEQUOIA_U (OM34418U)
Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the “COLD”
range. Similarly, if it is hot, the fluid level
should be in the “HOT” range. If the level
is at the low side of either range, add
automatic transmission fluid DEXRONII
or III to bring the level within the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the reser-
voir cap, visually check the steering box
case, vane pump and hose connections
for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
Keep your tire pressures at the proper
level.
The recommended cold tire pressures, tire
size and the vehicle capacity weight are
given on page 308 and 312 in Section 8.
The recommended cold tire pressures and
tire size are also on the tire pressure
label as shown.
You should check the tire pressures every
two weeks, or at least once a month. And
do not forget the spare! Incorrect tire pressure can reduce tire
life and make your vehicle less safe to
drive.
Low tire pressure results in excessive
wear, poor handling, reduced fuel econo-
my, and the possibility of blowouts from
overheated tires. Also, low tire pressure
can cause poor sealing of the tire bead.
If the tire pressure is excessively low,
there is the possibility of w
heel deforma-
tion and/or tire separation.
High tire pressure produces a harsh ride,
handling problems, excessive wear at the
center of the tire tread, and a greater
possibility of tire damage from road haz-
ards.
If a tire frequently needs ref illing, have it
checked by your Toyota dealer.
The following instructions for checking
tire pressure should be observed:
The pressure should be checked only
when the tires are cold. If your ve-
hicle has been packed for at least 3
hours and has not been driven for
more than 1.5 km or 1 mile since, you
will get an accurate cold tire pressure
reading.
Checking tire pressure

02_SEQUOIA_U (L/O 0108)
3102002 MY SEQUOIA_U (OM34418U)
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):With rear heater 13.4 (14.1, 11.8)
Without rear heater 11.7 (12.4, 10.2)
Coolant type:
“TOYOTA Long Life Coolant” or equiva-
lent
With ethyleneglycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af- ter the key is removed with all the
lights turned off
Charging rates: 5 A max. AUTOMATIC TRANSMISSION
Fluid capacity (drain and ref
ill),
L (qt., Imp. qt.):
Up to 2.0 (2.1, 1.8)
Fluid type: Automatic transmission fluid DII or
DEXRON III (DEXRON II)
TRANSFER
Oil capacity, L (qt., Imp. qt.): 1.2 (1.3, 1.1)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90
DIFFERENTIAL
Oil capacity, L (qt., Imp. qt.): Front
1.15 (1.2, 1.0)
Rear 3.65 (3.9, 3.3)
Oil type: Hypoid gear oil API GL5 Recommended oil viscosity:
FrontSAE 75W90
Rear Above 18 C (0 F)
SAE 90
Below 18 C (0 F)
SAE 80W or 80W90
CHASSIS LUBRICATION
Propeller shafts: Spiders and slide yokesLithium base chassis grease, NLGI
No.2
BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine stopping and after de-
pressing the brake pedal several times,
mm (in.): 113 (4.5)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)

02_SEQUOIA_U (L/O 0108)
3222002 MY SEQUOIA_U (OM34418U)
A
Active traction control system warning light 125 . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 299 . . . . . . . . . . . . . . . . . .
Adjustment
Front seats 37,38 . . . . . . . . . . . . . . . . . . . . . .
Seat belt 55 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Second seat 40 . . . . . . . . . . . . . . . . . . . . . . . .
Third seats 45 . . . . . . . . . . . . . . . . . . . . . . . . .
Airbags 68,75 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 293 . . . . . . . . . .
Antiglare inside rear view mirror 106 . . . . . .
Antilock brake system
warning light 125 . . . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 132 . . . . . . . .
Appearance care
Cleaning the interior 267 . . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 264 . . . . . . . . . . . . . . . . . . .
Washing and waxing 265 . . . . . . . . . . . . . . . .
Armrests 53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic door locking and unlocking functions 14 . . . . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 133 . . . . . . . .
Shift pattern 133 . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 133 . . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 125 . . . . . . . . . . .
Auxiliary box 200 . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 29 . . . . . . . . . . .
B
Back door 27
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 27
. . . . . . . . . . . . . . . . . . . . . . . .
Back window 25
. . . . . . . . . . . . . . . . . . . . . . . . .
Back window and outside rear view mirror defogger switch 119
. . . . . . . . .
Back window wiper and washer switch 118
. . . . . . . . . . . . . . . . . . . . .
Battery
Checking battery condition 296
. . . . . . . . . .
Gas caution 296
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 296
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 297
. . . . . . . . . . . . .
Winter driving tips 232
. . . . . . . . . . . . . . . . . .
Before starting the engine 228
. . . . . . . . . . . . .
Brake pad wear limit indicators 222 . . . . . . . .
Brake system 218
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 125
. . . . . . . . . . . .
Brakes
Fluid level 287
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 222
. . . . . . . . . . . .
Parking 147
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 213
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 114
. . . . . . . . . . . . . . . . . . . .
C
Car audio system 152
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 217
. . . . . . . . . . . . .
Cargo net hooks 207
. . . . . . . . . . . . . . . . . . . . .
Cassette player 152
. . . . . . . . . . . . . . . . . . . . . .
Center interior and personal lights 115 . . . . . . Checking and replacing fuses
298
. . . . . . . . .
Checking brake fluid 287
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 284
. . . . . . . . . .
Checking the radiator and condenser 286
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 83
. . . . . . . . . . . . . . .
Installation 85
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 99,101
. . . . . . . . . . . . .
Precautions 82
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 84 . . . . . . . .
Using a top strap 95,97
. . . . . . . . . . . . . . . . .
Cigarette lighter and ashtray 195
. . . . . . . . . .
Cleaning the interior 267
. . . . . . . . . . . . . . . . . .
Clock 195
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coin holder 203
. . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 232
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc and cassette tape holder
Cassette tape holder 205
. . . . . . . . . . . . . . .
Compact disc holder 205
. . . . . . . . . . . . . . . .
Compact disc auto changer 152
. . . . . . . . . . .
Compact disc auto changer controller 152
. . . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc player 152
. . . . . . . . . . . . . . . . . .
Compass 191
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 286
. . . . . . . . . . . .
Console box
Rear 202
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,4
. . . . . . . . . . . .

02_SEQUOIA_U (L/O 0108)
3252002 MY SEQUOIA_U (OM34418U)
Light bulbs, Replacing300
. . . . . . . . . . . . . . . .
Lights
Luggage compartment 116
. . . . . . . . . . . . . .
Lock
Back door 27
. . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 12
. . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 132
. . . . . . . . . . . . . . . . . . .
Low fuel level warning light 125
. . . . . . . . . . . .
Low windshield washer fluid level warning light 125
. . . . . . . . . . . . . . . . . . . . . . .
Luggage compartment light 116
. . . . . . . . . . . .
Luggage stowage precautions 222
. . . . . . . . .
M
Maintenance
Doityourself maintenance 280 . . . . . . . . .
Does your vehicle need repairing? 275 . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 273 . . . . . . . . . . . . . . .
Maintenance requirements 272 . . . . . . . . . .
Parts and tools 281 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 272 . . . . . . . . . . . . .
Malfunction indicator lamp 125,276 . . . . . . . .
Maximum allowable speed
Automatic transmission 133 . . . . . . . . . . . . .
Mirror
Antiglare inside rear view 106 . . . . . . . . . .
Mirrors
Folding rear view 105 . . . . . . . . . . . . . . . . . . .
Outside rear view 104 . . . . . . . . . . . . . . . . . .
Power rear view 104 . . . . . . . . . . . . . . . . . . . .
Vanity 107 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Moon roof 32
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Multiinformation display 184 . . . . . . . . . . . . .
N
New vehicle breakin 213
. . . . . . . . . . . . . . . . .
Note pad holder 203
. . . . . . . . . . . . . . . . . . . . . .
O
Odometer 124
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Offroad driving precautions 230
. . . . . . . . . .
Offroad vehicle precautions 212
. . . . . . . . . .
Oil
Consumption 217
. . . . . . . . . . . . . . . . . . . . . .
Power steering 287
. . . . . . . . . . . . . . . . . . . . .
Pressure gauge 123
. . . . . . . . . . . . . . . . . . . .
Viscosity and grade 284
. . . . . . . . . . . . . . . .
Oil consumption 217
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 125
. . . . . . . . . . . . . . .
Operation in foreign countries 215
. . . . . . . . .
Outside temperature and cruise information display 189
. . . . . . . . . . . . . . . . .
Overdrive switch 133
. . . . . . . . . . . . . . . . . . . . .
Overheating, Engine 248
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 122
. . . . . . . . . .
Overview
Engine compartment 278
. . . . . . . . . . . . . . .
P
Parking brake
Operation 147 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 147 . . . . . . . . . . . . . . . . . . . . .
Personal light 115 . . . . . . . . . . . . . . . . . . . . . . . .
Polishing 265 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power back window 25 . . . . . . . . . . . . . . . . . . .
Power outlet 196 . . . . . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 104 . . . . . . . . .
Power steering
Fluid level 287 . . . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 22 . . . . . . . . . . . . . . . .
Preloaders (seat belt pretensioners) 65 . . . . .
Pretensioners (seat belt pretensioners) 65 . . . . . . . . . . . . .
Protecting your Toyota from corrosion 264 . . . . . . . . . . . . . . . . . . . . .
R
Radiator
Checking the radiator 286 . . . . . . . . . . . . . . .
Coolant, Engine 285 . . . . . . . . . . . . . . . . . . . .
Radio 152 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear air conditioning system 180 . . . . . . . . . .
Rear console box 202 . . . . . . . . . . . . . . . . . . . .
Rear seat
Third seat entry 41 . . . . . . . . . . . . . . . . . . . . .
Rear seat precautions 39 . . . . . . . . . . . . . . . . .
Rear seats 39 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear view mirror
Antiglare inside 106 . . . . . . . . . . . . . . . . . . .