TOYOTA SOLARA 2006 Warranties & Maintenance Guides (in English)

Basic Warranty
This warranty covers repairs and adjustments needed to correct defects in
materials or workmanship of any part supplied by Toyota, subject to theexceptions indicated under “What Is Not Covered” on pages 11–12.
Coverage is for 36 months or 36,000 miles, whichever occurs first, with
the exception of wheel alignment and wheel balancing, which are cov
ered for 12 months or 20,000 miles, whichever occurs first.
Powertrain Warranty
This warranty covers repairs needed to correct defects in materials or
workmanship of any component listed in the next column and supplied
by Toyota, subject to the exceptions indicated under “What Is Not
Covered” on pages 11–12.
Coverage is for 60 months or 60,000 miles, whichever occurs first.
Engine
Cylinder block and head and all internal parts, timing gears and gaskets,
timing chain/belt and cover, flywheel, valve covers, oil pan, oil pump,
engine mounts, turbocharger housing and all internal parts, super
charger housing and all internal parts, engine control computer, water
pump, fuel pump, seals and gaskets.
Transmission and Transaxle
Case and all internal parts, torque converter, clutch cover, transmission
mounts, transfer case and all internal parts, engine control computer,
seals and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts, axle shafts, drive shafts,
constant velocity joints, front hub and bearings, seals and gaskets.
Rear-Wheel-Drive System
Axle housing and all internal parts, propeller shafts, Ujoints, axle
shafts, drive shafts, bearings, supports, seals and gaskets.
WHAT IS COVERED AND HOW LONG
Your Warranties in Detail9
New Vehicle Limited Warranty

Restraint Systems Warranty
This warranty covers repairs needed to correct defects in materials or
workmanship of any seatbelt or air bag system supplied by Toyota,
subject to the exceptions indicated under “What Is Not Covered” on
pages 11–12.
Coverage is for 60 months or 60,000 miles, whichever occurs first.For vehicles sold and registered in the state of Kansas, the warranty for
seatbelts and related components is 10 years, regardless of mileage.
Corrosion Perforation Warranty
This warranty covers repair or replacement of any original body panel
that develops perforation from corrosion (rustthrough), subject to the
exceptions indicated under “What Is Not Covered” on pages 11–12.
Coverage is for 60 months, regardless of mileage.
For information on how to protect your vehicle from corrosion, see the
section entitled “Corrosion Prevention and Appearance Care” in the
Owner’s Manual.
Towing
When your vehicle is inoperable due to failure of a warranted part,
towing service to the nearest authorized Toyota dealership is covered.
Your Warranties in Detail10
New Vehicle Limited Warranty

This warranty does not cover damage or failures resulting directly or
indirectly from any of the following:
¥Fire, accidents or theft
¥Abuse or negligence
¥Misuse — for example, racing or overloading
¥Improper repairs
¥Alteration or tampering, including installation of nonGenuine
Toyota Accessories
¥Lackof or improper maintenance, including use of fluids other
than those specified in the
Owner’s Manual
¥Installation of nonGenuine Toyota Parts
¥Airborne chemicals, tree sap, road debris (including stone chips),
rail dust, salt, hail, floods, wind storms, lightning and other
environmental conditions
¥Water contaminationThis warranty also does not cover the following:
Tires
Tires are covered by a separate warranty provided by the tire manufac
turer. See page 26.
Normal Wear and Tear
Noise, vibration, cosmetic conditions and other deterioration caused by
normal wear and tear.
Maintenance Expense
Normal maintenance services such as:
¥Engine tuneups
¥Replacement of fluids and filters
¥Lubrication
¥Cleaning and polishing
¥Replacement of spark plugs and fuses
¥Replacement of worn wiper blades, brake pads/linings and clutch linings
WHAT IS NOT COVERED
Your Warranties in Detail11
New Vehicle Limited Warranty
Maintenance Expense
Normal maintenance services such as:
¥Engine tuneups
¥Replacementof fluids and filters
¥Lubrication
¥Cleaning and polishing
¥Replacement of spark plugs and fuses
¥Replacement of worn wiper blades, brake pads/linings and clutch linings Noise, vibration, cosmetic conditions and other deterioration caused by
normal wear and tear.
Normal Wear and Tear
Tires are covered by a separate warranty provided by the tire manufac
turer. See page 26.

Vehicles With Altered Odometer
Failure of a vehicle on which the odometer has been altered so that
actual vehicle mileage cannot be readily determined.
Salvage or TotalLoss Vehicles
Any vehicle that has ever been issued a “salvage” title or similar title
under any state’s law; or has ever been declared a “total loss” or equiva
lent by a financial institution or insurer, such as by payment for a claim in
lieu of repairs because the cost of repairs exceeded the cash value of thevehicle. This exclusion does notapply to the emission control warranties.
Incidental Damages
Incidental or consequential damages associated with a vehicle failure.
Such damages include but are not limited to inconvenience; the cost of
transportation, telephone calls and lodging; the loss of personal or com
mercial property; and the loss of pay or revenue.
Disclaimer of Extra Expenses and Damages
The performance of necessary repairs and adjustments is the exclu
sive remedy under this warranty or any implied warranty. Toyota
does not authorize any person to create for it any other obligation
or liability in connection with this vehicle. Toyota shall not be liable
for incidental or consequential damages resulting from breach of
this written warranty or any implied warranty. Any implied war
ranty of merchantability or fitness for a particular purpose is limited
to the duration of this written warranty, except in states where this
limitation is not allowed.
Your Warranties in Detail12
New Vehicle Limited Warranty

If a dispute arises regarding your warranty coverage, please follow the
steps described under “If You Need Assistance” on pages 4–5. Please
note that you must use the Dispute Settlement Program (or, in California,
the CDSP) before seeking remedies through a court action pursuant to the
MagnusonMoss Warranty Act. You may also be required to use the
Dispute Settlement Program or CDSP before seeking remedies under the
“Lemon Laws” of your state. Please check the appropriate page of the
Owner’s Warranty Rights Notificationbooklet (located in your glove box)
for the requirements applicable to your state.
Your Warranties in Detail13
New Vehicle Limited Warranty
DISPUTE RESOLUTION

Emission Defect Warranty
Toyota warrants that your vehicle:
¥Was designed, built and equipped to conform at the time of sale with
applicable federal emissions standards.
¥Is free from defects in materials and workmanship that may cause the
vehicle to fail to meet these standards.
Federal regulations require that this warranty be in effect for two years
or24,000 miles from the vehicle’s inservice date, whichever occurs
first. However, under the terms of the Basic Warranty, Toyota provides
coverage of three years or 36,000 miles, whichever occurs first. Speci
fic components may have longer coverage under the terms of the
Powertrain Warranty. Additionally, components marked “8/80” in the
parts list on pages 15–16 have coverage of eight years or 80,000 miles,
whichever occurs first.
Emission Performance Warranty
Some states and localities have established vehicle inspection and main
tenance (I/M) programs to encourage proper vehicle maintenance. If an
EPAapproved I/M program is in force in your area, you are eligible for
Emission Performance Warranty coverage.
Under the terms of the Emission Performance Warranty and federal
regulations, Toyota will make all necessary repairs if both of the
following occur:
¥Your vehicle fails to meet applicable emissions standards as
determined by an EPAapproved emissions test.
¥This failure results or will result in some penalty to you— such
as a fine or denial of the right to use your vehicle
— under local,
state or federal law.
This warranty is in effect for two years or 24,000 miles from the vehicle’s
inservice date, whichever occurs first. Additionally, components marked
“8/80” in the parts list on pages 15–16 have coverage of eight years or
80,000 miles, whichever occurs first.
WHAT IS COVERED AND HOW LONG
YourWarranties in Detail14
Federal Emission Control Warranty

These warranty obligations do not apply to failures or noncompliance
caused by:
¥The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
¥The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty.
Air/Fuel Metering System
¥Air/fuel ratio feedback control system
¥Coldstart enrichment system
¥Deceleration control system
¥Electronic fuel injection system components
— Airflow sensor
— Engine control module (8/80)
Air Induction System
¥Intake manifold and intake air surge tank
Catalyst System
¥Catalytic converter and protector (8/80)
¥Constricted fuel filler neck
¥Exhaust manifold
¥Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)
WHAT IS NOT COVERED WARRANTY PARTS LIST
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
Your Warranties in Detail15
Federal Emission Control Warranty

*
Evaporative Control System
¥Charcoal canister
¥Diaphragm valve
¥Fuel filler cap
¥Fuel tank
¥Vapor liquid separator
Exhaust Gas Recirculation (EGR) System
¥EGR gas temperature sensor
¥EGR valve
¥Associated parts
Ignition System
¥Distributor and internal parts
¥Ignition coil and ignitor
¥Ignition wires
¥Spark plugs*
Positive Crankcase Ventilation (PCV) System
¥Oil filler cap
¥PCV valve or orifice
Other Parts Used in Above Systems
¥Data linkconnector (8/80)
¥Hoses, clamps, fittings, tubing and mounting hardware
¥Malfunction indicator light and bulb (8/80)
¥Pulleys, belts and idlers
¥Sealing gaskets and devices
¥Sensors, solenoids, switches and valves
Warranted until first required maintenance under terms of the
California Emission Control Warranty.
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
Your Warranties in Detail16
Federal Emission Control Warranty

You are responsible for performance of the required maintenance indi
cated in the
Owner’s Manualand the Scheduled Maintenance Guide.
Toyota will not deny a warranty claim solely because you do not have
records to show that you maintained your vehicle. However, any failure
or noncompliance caused by lack of maintenance is not covered by this
warranty.
When maintenance and repairs are paid for by you, these services
may be performed by you or by any automotive service provider youchoose. Toyota will not deny a warranty claim solely because you
used a service provider other than a Toyota dealership for mainte-nance and repairs.
However, any failure ornoncompliance caused by
improper maintenance or repairs is not covered by this warranty.To ensure optimum performance and maintain the quality built into
your vehicle’s emission control systems, Toyota recommends the use of
Genuine Toyota Parts when servicing or repairing the systems.
Warranty coverage is not dependent upon the use of any particular
brand of replacement parts and you may elect to use nonÐGenuine
Toyota Parts for maintenance and repairs. However, use of replace-
ment parts that are not equivalent in quality to Genuine Toyota
Parts may impair the effectiveness of the emission control systems.
If you use replacement parts that have maintenance or replacement
schedules different from those of Genuine Toyota Parts, you must follow
the maintenance and replacement schedules for the parts you are using.
In addition, you should ensure that such parts are warranted by their
manufacturers to be equivalent to Genuine Toyota Parts.
MAINTENANCE REPLACEMENT PARTS
Your Warranties in Detail17
Federal Emission Control Warranty

If your vehicle fails an EPAapproved emissions test, you may make a
claim under the Emission Performance Warranty. To do so, take your
vehicle to an authorized Toyota dealership and present a copy of the
emissions test report. Also, take your maintenance records in case they
are needed.
If your claim qualifies for coverage, the dealership will repair your vehi
cle within 30 days (unless a shorter period is required by law). If your
claim is denied, Toyota will notify you in writing of the reason within the same period. If we fail to do so, we will repair your vehicle free of
charge. The only exceptions allowed are when you request or agree to adelay, orwhen a delay is caused by factors beyond the control of Toyota
orthe dealership.
For information on how to obtain service under the Emission Defect
Warranty, see page 29, “Obtaining Warranty Service.”If you have questions or concerns about your vehicle’s federal emission
warranty coverage, please follow the steps described under “If You Need
Assistance” on pages 4–5. In the case of the Emission Performance
Warranty, you may also request information from or report complaints to:
U.S. Environmental Protection Agency
Vehicle Programs & Compliance Division (6405J)
Attn: Warranty Complaints
401 M Street SWWashington, D.C. 20460
Excluding Camry PZEV, vehicles equipped with a California Certified
Emission Control System that are sold, registered and operated in
California or any state that adopts California emission warranty pro
visions are also covered by the California Emission Control Warranty
(see page 20). Currently, Maine, Massachusetts and Vermont are the
only other states to which the California Emission Control Warranty
applies.
IF YOUR VEHICLE FAILS AN EMISSIONS TEST IF YOU HAVE QUESTIONS
Your Warranties in Detail18
Federal Emission Control Warranty