wiper fluid TOYOTA T100 1996 Factory Service Manual

Downloaded from www.Manualslib.com manuals search engine MA001−28
− MAINTENANCEOUTSIDE VEHICLE
MA−1
36 Author: Date:
1996 TOYOTA T100 (RM449U)
OUTSIDE VEHICLE
GENERAL MAINTENANCE
The owners are responsible for these maintenance and inspection items.
They can be done by the owner or they can have them done at a service shop.
These items include those which should be checked on a daily basis, those which, in most cases, do not
require (special) tools and those which are considered to be reasonable for the owner to do.
Items and procedures for general maintenance are as follows.
1. GENERAL NOTES
Maintenance items may vary from country to country. Check the owner’s manual supplement in which
the maintenance schedule is shown.
Every service item in the periodic maintenance schedule must be performed.
Periodic maintenance service must be performed according to whichever interval in the periodic main-
tenance schedule occurs first, the odometer reading (miles) or the time interval (months).
Maintenance service after the last period should be performed at the same interval as before unless
otherwise noted.
Failure to do even one item can cause the engine to run poorly and increase exhaust emissions.
2. TIRES
(a) Check the pressure with a gauge.
If necessary, adjust.
(b) Check for cuts, damage or excessive wear.
3. WHEEL NUTS
When checking the tires, check the nuts for looseness or for missing nuts.
If necessary, tighten them.
4. TIRE ROTATION
Check the owner’s manual supplement in which the maintenance schedule is shown.
5. WINDSHIELD WIPER BLADES
Check for wear or cracks whenever they do not wipe clean.
If necessary, replace.
6. FLUID LEAKS
(a) Check underneath for leaking fuel, oil, water or other fluid.
(b) If you smell gasoline fumes or notice any leak, have the cause found and corrected.
7. DOORS AND ENGINE HOOD
(a) Check that all doors and the tailgate operate smoothly, and that all latches lock securely.
(b) Check that the engine hood secondary latch secures the hood from opening when the primary latch
is released.

Downloaded from www.Manualslib.com manuals search engine BO0E3−02
N05675
BB A
C A
C
− BODYFRONT WIPER AND WASHER
BO−13
1996 TOYOTA T100 (RM449U)
INSPECTION
INSPECT WASHER NOZZLE
(a) While operating the washer, check whether the upper
point where the washer fluid hits the windshield and the
surge area are within the range indicated by the hatched
line.
A: Approx. 150 mm (5.91 in.)
B: Approx. 50 mm (1.97 in.)
C: Approx. 0 − 50 mm (0 − 1.97 in.)
(b) Check if the lower point where the washer fluid hits the
windshield is within the range of the wiping pattern the
area of the glass which is wiped by the wiper blades.

Downloaded from www.Manualslib.com manuals search engine BO0E4−02
BE3367
2 − 2.5 mm
(0.079 −0.098 in.)
0.7 − 0.75 mm
(0.028 −0.030 in.) BO−14
− BODYFRONT WIPER AND WASHER
1996 TOYOTA T100 (RM449U)
ADJUSTMENT
ADJUST WASHER NOZZLE
Using a tool like that shown in the figure, change the direction
of the nozzle hole to adjust the point where washer fluid strikes
the windshield.