gas mileage TOYOTA TUNDRA 2019 Warranties & Maintenance Guides (in English)

13Your Warranties in Detail
WARRANTY
NEW VEHICLE LIMITED WARRANTY

WHAT IS COVERED
AND HOW LONG
Basic Warranty
This warranty covers repairs and
adjustments needed to correct defects
in materials or workmanship of any
part supplied by Toyota, subject to the
exceptions indicated under “What
Is Not Covered” on pages 14–15.
Coverage is for 36 months or 36,000 miles,
whichever occurs first, with the exception of
wheel alignment and wheel balancing, which
are covered for 12 months or 12,000 miles,
whichever occurs first.
Powertrain Warranty
This warranty covers repairs needed to
correct defects in materials or workmanship
of any component listed below and in the
next column and supplied by Toyota, subject
to the exceptions indicated under “What Is
Not Covered” on pages 14–15.
Coverage is for 60 months or 60,000 miles,
whichever occurs first.
Engine
Cylinder block and head and all internal
parts, timing gears and gaskets, timing
chain/belt and cover, flywheel, valve
covers, oil pan, oil pump, engine mounts,
turbocharger housing and all internal parts,
supercharger housing and all internal
parts, engine control computer, water
pump, fuel pump, seals and gaskets.
Transmission and Transaxle
Case and all internal parts, torque

converter, clutch cover, transmission
mounts, transfer case and all internal
parts, engine control computer, seals
and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts,
axle shafts, drive shafts, constant velocity
joints, front hub and bearings, seals
and gaskets.
Rear-Wheel-Drive System
A xle housing and all internal parts,
propeller shafts, U-joints, axle shafts,
drive shafts, bearings, supports, seals
and gaskets.
Restraint Systems Warranty
This warranty covers repairs needed to
correct defects in materials or workmanship
of any seatbelt or air bag system supplied by
Toyota, subject to the exceptions indicated
under “What Is Not Covered” on pages 14–15.
Coverage is for 60 months or 60,000 miles,
whichever occurs first.
For vehicles sold and registered in the
state of Kansas, the warranty for seatbelts
and related components is 10 years,
regardless of mileage.
18-TCS-11469_Toyota_WMG_MY19_Tundra_FFV_GUTS_3_0_tw .indd 137/5/18 10:05 PM

41Maintenance Log
Dealer Service verification:
D
ate: Mileage:
MAINTENANCE LOG
MAINTENANCE
27,500 miles or 33 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Replace engine oil and oil filter2
Dealer Service verification:
D
ate: Mileage:
30,000 miles or 36 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Re-torque propeller shaft bolt
Inspect the following:
_ Au

tomatic transmission for signs of leakage
_ Ba

ll joints and dust covers
_ Br

ake lines and hoses
_ Br

ake linings/drums and brake pads/discs
5
_ Dri ve shaft boots
_Eng

ine coolant6
_Ex haust pipes and mountings
_Fr

ont differential oil
Driving on dirt roads or dusty roads:
Replace transfer case oil
Tighten nuts and bolts on chassis and body
Driving while towing, using a car-top carrier, or heavy vehicle loading:
7
Replace front differential oil
Replace rear differential oil
Replace transfer case oil
Tighten nuts and bolts on chassis and body
1 Inspect sealed transmissions, transfer cases and differentials for signs of leaka ge. If any leakage from a sealed component
is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect power steering
fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant level/condition/fre\
ezing
point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on inspection results.
2 Refer to “Engine Oil and Filter” in the “Explanation of Maintenance Items” section in the back of this guide for more information.3 Perform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied. 5 Inspect thickness measurement and disc runout.6 Refer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.7 Not all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual f or details.
_ Fu
el lines and connections, fuel tank band
and fuel tank vapor vent system hoses
_ Fu

el tank cap gasket
_Ra

diator and condenser
_Re

ar differential oil
_St

eering gear
_St

eering linkage and boots
_Tr

ansfer case oil
Replace cabin air filter
Replace engine air filter
Replace engine oil and oil filter2
Rotate tires
Additional Maintenance Items for Special Operating Conditions3
18-TCS-11469_Toyota_WMG_MY19_Tundra_FFV_GUTS_3_0_tw .indd 417/5/18 10:19 PM

45Maintenance Log
MAINTENANCE LOG
MAINTENANCE
Dealer Service verification:
D
ate: Mileage:
57,500 miles or 69 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Replace engine oil and oil filter2
Dealer Service verification:
D
ate: Mileage:
60,000 miles or 72 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Re-torque propeller shaft bolt
Inspect the following:
_ Au

tomatic transmission for signs of leakage
_ Ba

ll joints and dust covers
_ Br

ake lines and hoses
_ Br

ake linings/drums and
brake pads/discs
5
_ Dri ve belts6
_Dri ve shaft boots
_Eng

ine coolant7
_Ex haust pipes and mountings
Additional Maintenance Items for Special Operating Conditions3
Driving on dirt roads or dusty roads:
Replace transfer case oil
Tighten nuts and bolts on chassis and body
Driving while towing, using a car-top carrier, or heavy vehicle loading:8
Replace automatic transmission fluid
Replace front differential oil
Replace rear differential oil
Replace transfer case oil
Tighten nuts and bolts on chassis and body
1 Inspect sealed transmissions, transfer cases and differentials for signs of leaka ge. If any leakage from a sealed component
is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect power steering
fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant level/condition/fre\
ezing
point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on inspection results.
2 Refer to “Engine Oil and Filter” in the “Explanation of Maintenance Items” section in the back of this guide for more information.3 Perform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied. 5 Inspect thickness measurement and disc runout.6 Initial inspection at 60,000 miles/ 72 months. Inspect every 15.000 miles/18 months thereafter.7 Refer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.8 Not all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual f or details.
_ Fr
ont differential oil
_ Fu

el lines and connections, fuel tank band
and fuel tank vapor vent system hoses
_ Fu

el tank cap gasket
_Ra

diator and condenser
_Re

ar differential oil
_St

eering gear
_St

eering linkage and boots
_Tr

ansfer case oil
Replace cabin air filter
Replace engine air filter
Replace engine oil and oil filter2
Rotate tires
18-TCS-11469_Toyota_WMG_MY19_Tundra_FFV_GUTS_3_0_tw .indd 457/5/18 10:21 PM

49Maintenance Log
MAINTENANCE LOG
MAINTENANCE
Dealer Service verification:
D
ate: Mileage:
87,500 miles or 105 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Replace engine oil and oil filter2
Dealer Service verification:
D
ate: Mileage:
90,000 miles or 108 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Re-torque propeller shaft bolt
Inspect the following:
_ Au

tomatic transmission for signs of leakage
_ Ba

ll joints and dust covers
_ Br

ake lines and hoses
_ Br

ake linings/drums and
brake pads/discs
5
_ Dri ve belts
_Dri

ve shaft boots
_Eng

ine coolant
6
_Ex haust pipes and mountings
Additional Maintenance Items for Special Operating Conditions3
Driving on dirt roads or dusty roads:
Replace transfer case oil
Tighten nuts and bolts on chassis and body
Driving while towing, using a car-top carrier, or heavy vehicle loading:
7
Replace front differential oil
Replace rear differential oil
Replace transfer case oil
Tighten nuts and bolts on chassis and body
1 Inspect sealed transmissions, transfer cases and differentials for signs of leaka ge. If any leakage from a sealed component
is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect power steering
fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant level/condition/fre\
ezing
point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on inspection results.
2 Refer to “Engine Oil and Filter” in the “Explanation of Maintenance Items” section in the back of this guide for more information.3 Perform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied. 5 Inspect thickness measurement and disc runout.6 Refer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.7 Not all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual f or details.
_ Fr
ont differential oil
_ Fu

el lines and connections, fuel tank band
and fuel tank vapor vent system hoses
_ Fu

el tank cap gasket
_Ra

diator and condenser
_Re

ar differential oil
_St

eering gear
_St

eering linkage and boots
_Tr

ansfer case oil
Replace cabin air filter
Replace engine air filter
Replace engine oil and oil filter2
Rotate tires
18-TCS-11469_Toyota_WMG_MY19_Tundra_FFV_GUTS_3_0_tw .indd 497/5/18 10:26 PM

53Maintenance Log
MAINTENANCE LOG
MAINTENANCE
Dealer Service verification:
D
ate: Mileage:
117,500 miles or 141 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Replace engine oil and oil filter2
Dealer Service verification:
D
ate: Mileage:
120,000 miles or 144 months
Check installation of driver’s floor mat
Inspect and adjust all fluid levels1
Inspect wiper blades
Re-torque propeller shaft bolt
Replace cabin air filter
Inspect the following:
_ Au

tomatic transmission for signs of leakage
_ Ba

ll joints and dust covers
_ Br

ake lines and hoses
_ Br

ake linings/drums and
brake pads/discs
6
_ Dri ve belts
_Dri

ve shaft boots
_Eng

ine coolant
7
_Ex haust pipes and mountings
Additional Maintenance Items for Special Operating Conditions3
Driving on dirt roads or dusty roads:
Replace transfer case oil
Tighten nuts and bolts on chassis and body
Driving while towing, using a car-top carrier, or heavy vehicle loading:8
Replace automatic transmission fluid
Replace front differential oil
Replace rear differential oil
Replace transfer case oil
Tighten nuts and bolts on chassis and body
1 Inspect sealed transmissions, transfer cases and differentials for signs of leaka ge. If any leakage from a sealed component
is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect power steering
fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant level/condition/fre\
ezing
point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on inspection results.
2 Refer to “Engine Oil and Filter” in the “Explanation of Maintenance Items” section in the back of this guide for more information.3 Perform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied. 5 Maintenance services of spark plugs are required under the terms of the Emissions Control Warranty.6 Inspect thickness measurement and disc runout.7 Refer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.8 Not all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual f or details.
_ Fr
ont differential oil
_ Fu

el lines and connections, fuel tank band
and fuel tank vapor vent system hoses
_ Fu

el tank cap gasket
_Ra

diator and condenser
_Re

ar differential oil
_St

eering gear
_St

eering linkage and boots
_Tr

ansfer case oil
Replace engine air filter
Replace engine oil and oil filter2
Replace spark plugs5
Rotate tires
18-TCS-11469_Toyota_WMG_MY19_Tundra_FFV_GUTS_3_0_tw .indd 537/5/18 10:26 PM