parking brake TOYOTA TUNDRA HYBRID 2022 Repair Manual

5257-2. Steps to take in an emergency
Owners Manual_USA_M0C031_en
7
When trouble arises
approximately -31°F [-35°C]).
( P.195)
One of the following may be the
cause of the problem:
 The 12-volt battery may be
discharged. ( P.529)
 The 12-volt battery terminal
connections may be loose or
corroded. ( P.463)
One of the following may be the
cause of the problem:
 The 12-volt battery may be
discharged. ( P.529)
 One or both of the 12-volt bat-
tery terminals may be discon-
nected. ( P.463)
Contact your Toyot a dealer if the
problem cannot be repaired, or if
repair procedures are unknown.
When the hybrid system does
not start, the following steps can
be used as an interim measure
to start the hybrid system if the
power switch is functioning nor- mally.
Do not use this starting proce-
dure except in case of emer-
gency.
1
Pull the parking brake switch
to check that the parking
brake is set. ( P.205)
Parking brake indicator will come
on.
2 Shift the shift lever to P.
3 Turn the power switch to
ACC.
4 Press and hold the power
switch for about 15 seconds
while depressing the brake
pedal firmly.
Even if the hybrid system can be
started using the above steps, the
system may be malfunctioning.
Have the vehicle inspected by your
Toyota dealer.
The interior lights and
headlights are dim, or the
horn does not sound or
sounds at a low volume.
The interior lights and
headlights do not turn on,
or the horn does not
sound.
Emergency start function

5387-2. Steps to take in an emergency
Owners Manual_USA_M0C031_en
1Stop the hybrid system. Set
the parking brake and shift
the shift lever to P.
2 Remove the mud, snow or
sand from around the rear
wheels.
3 Place wood, stones or some
other material under the rear
wheels to help provide trac-
tion.
4 Restart the hybrid system.
5 Shift the shift lever to D or R
and release the parking
brake. Then, while exercising
caution, depress the acceler-
ator pedal.
■When it is difficult to free the
vehicle
Try the followings.
●Turn off the TRAC
(  P.375)
●Using the rear d ifferential lock*
( P.364)
●Switching the front-wheel drive
control switch* ( P.361)
●Using Crawl Control* ( P.365)
●Using Multi-te rrain Select*
( P.369)
*: If equippedIf the vehicle becomes
stuck
Carry out the following pro-
cedures if the tires spin or
the vehicle becomes stuck
in mud, dirt or snow:
Recovering procedure
WARNING
■When attempting to free a
stuck vehicle
If you choose to push the vehicle
back and forth to free it, make
sure the surrounding area is clear
to avoid striking other vehicles,
objects or people. The vehicle
may also lunge forward or lunge
back suddenly as it becomes free.
Use extreme caution.
■When shifting the shift lever
Be careful not to shift the shift
lever with the accelerator pedal
depressed.
This may lead to unexpected
rapid acceleration of the vehicle
that may cause an accident
resulting in death o r serious injury.
NOTICE
■To avoid damaging the trans-
mission and other compo-
nents
●Avoid spinning the rear wheels
and depressing the accelerator
pedal more than necessary.
●If the vehicle remains stuck
even after these procedures are
performed, the vehicle may
require towing to be freed.

5468-1. Specifications
Owners Manual_USA_M0C031_en
Your Toyota vehicle is filled with “Toyota Genuine Differential Gear
Oil” at the factory.
Use Toyota approved “Toyota Genuine Differential Gear Oil” or an
equivalent oil of matching quality to satisfy the above specifi cation.
Please contact your Toyota dealer for further details.
*1: Minimum pedal clearance when depressed with a force of 110 lbf (490 N,
50 kgf) while the hybrid system is running.
*2: Make sure to confirm that the brake warning light (yellow) doe s not illumi-
nate. (If the brake warning light illuminates, refer to P.501.)
Differential
Oil capacity
Front (4WD
models)1.4 qt. (1.29 L, 1.1 Imp.qt.)
Rear
Without rear differential lock system
6.0 qt. (5.73 L , 5.0 Imp.qt.)
With rear differential lock system
5.8 qt. (5.51 L, 4.8 Imp.qt.)
Oil type and viscosityToyota Genuine Differential Ge ar Oil LT
75W-85 GL-5 or equivalent
Brakes
Pedal clearance*13.6 in. (90.8 mm) Min.
Pedal free play0.04  0.24 in. (1  6 mm)
Brake pad wear limit0.04 in. (1 mm)
Parking brake indicator*2
When pulling the parking brake switch for
1 to 2 seconds: comes on
When pushing the parking brake switch for
1 to 2 seconds: turns off
Fluid typeFMVSS No.116 DOT 3 or SAE J1703
Steering
Free playLess than 1.2 in. (30 mm)

5718-3. Initialization
Owners Manual_USA_M0C031_en
8
Vehicle specifications
8-3.Initialization
*: If equipped
Items to initialize
The following items must be initialized for normal system
operation after such cases as the 12-volt battery being recon-
nected, or maintenance being performed on the vehicle:
List of items to initialize
ItemWhen to initializeReference
PKSB (Parking
Support Brake)• After reconnecting or changing the 12-volt batteryP.292
Maintenance
required reminder
message• After the maintenance is per-formedP.449, 459
Tire pressure warn-
ing system
• When the tire inflation pressure is changed, such as when
changing traveling speed or load
weight.
• When the tire inflation pressure is changed, such as when the
tire size is changed.
• When rotating the tires.
• After performing the transmitter
ID code registration procedure.
P.470
Toyota parking
assist monitor
*• 12-volt battery has been rein-
stalled.
• The steering wheel has been moved while the 12-volt battery
was being reinstalled.
• 12-volt battery power is low.
P.307, 341, 354Panoramic view
monitor
*
Multi-terrain Moni-
tor
*

Owners Manual_USA_M0C031_en
593What to do if... (Troubleshooting)
Is the power switch in ON?
If you cannot release the shift lever
by depressing the brake pedal with
the power switch in ON. ( P.201)
 Is the window lock switch
pressed?
The power window except for the
one at the driver’s seat cannot be
operated if the win dow lock switch
is pressed. ( P.162)
 The auto power off function
will be operated if the vehicle
is left in ACC or ON (the
hybrid system is not operat-
ing) for a period of time.
( P.198)
 The seat belt reminder light is
flashing
Are the driver and the front passen-
ger wearing the seat belts?
( P.507)
 The parking brake indicator is
on
Is the parking br ake released?
(  P.205)
Depending on the situation,
other types of warning buzzer
may also sound. ( P.501, 511)
 Did anyone inside the vehicle
open a door during setting the
alarm?
The sensor detects it and the alarm
sounds. ( P. 8 2 )
Do one of the following to deac-
tivate or stop the alarms:
 Unlock the doors using the
entry function or wireless
remote control.
 Turn the power switch to ACC
or ON, or start the hybrid sys-
tem. (The alarm will be deacti-
vated or stopped after a few
seconds.)
 Is the message displayed on
the multi-information display?
Check the message on the multi-
information display. ( P.501)
 When a warning light turns on
or a warning message is dis-
The shift lever cannot be
shifted from P even if you
depress the brake pedal
The windows do not open
or close by operating the
power window switches
The power switch is
turned off automatically
A warning buzzer sounds
during driving
An alarm is a ctivated and
the horn sounds
A warning buzzer sounds
when leaving the vehicle
A warning light turns on
or a warning message is
displayed

596Alphabetical Index
Owners Manual_USA_M0C031_en
B
Back window Power back window ............. 163
Back-up lights Replacing light bulbs ............ 490
Battery (12-volt battery) ......... 463 Battery checking................... 463
If the 12-volt battery is dis-charged .............................. 529
Preparing and c hecking before
winter.................................. 395
Warning light ........................ 502
Battery (traction battery) ......... 76
Bed hooks ............ ................... 417
Bed lamp ................................. 410 Replacing light bulbs ............ 490
Blind Spot Monitor (BSM) ...... 267 Enabling/disabling the system........................................... 269
Trailer settings ...................... 100
Boost Meter .............................. 94
Bottle holders ......................... 415
Brake Brake hold ............................ 208
Fluid ............................. 461, 546
Parking brake ....................... 205
Regenerative braking ............. 74
Warning light ........................ 501
Brake assist ............................ 374
Brake hold ............................... 208
Brake Override System .......... 172
Break-in tips ........ ................... 172
Brightness control Instrument panel light control . 94
BSM (Blind Spot Monitor) ...... 267 Enabling/disabling the system........................................... 269
Trailer settings ...................... 100
C
Camper information ...............585
Care..................................442, 445 Aluminum wheel ornaments .442
Aluminum wheels .................442
Exterior .................................442
Hybrid battery (tr action battery)
air intake vents ...................481
Interior ..................................445
Seat belts .............................445
Cargo and luggage .................178
Cargo capacity ........................180
Cargo lamp ..............................410 Replacing light bulbs ............490
Chains......................................397
Child restraint system ..............53 Fixed with a LATCH system ...60
Fixed with a seat belt..............62
Front passenger occupant clas-sification system ...................46
Points to remember ................53
Riding with children ................52
Types of child restraint system installation method ...............55
Using an anchor bracket ........58
Child safety ...............................52 12-volt battery precautions ...464
Airbag precautions .................41
Battery precautions ..............533
Child restraint system .............55
Heated steering wheel and seat heater precautio ns..............407
How your child should wear the seat belt ................................30
Panoramic moon r oof ...........166
Power back window..............163
Power window lock switch ....162
Power window precautions...161
Rear door child-protectors .... 116
Removed electronic key battery precautions .........................486

Owners Manual_USA_M0C031_en
Alphabetical Index599
Engine coolant temperature gauge....................................... 91
Engine oil Capacity ............................... 543
Checking .............................. 458
Warning light ........................ 502
Engine oil pressure gauge ...... 91
Engine switch (power switch)195 Auto power off function ........ 198
Changing the power switch modes ................................ 198
If your vehicle has to be stopped in an emergency................. 494
Starting the hybrid system.... 195
Enhanced Vehicle Stability Con- trol (Enhanced VSC) ............ 375
Enhanced VSC (Enhanced Vehi- cle Stability Control) ............ 375
EPS (Electric Power Steering) ............................................... 375Warning light ........................ 503
Event data recorder (EDR)......... 8
F
Flat tire .................................... 515 Tire pressure warning system........................................... 468
Floor mats ................................. 26
Fluid Automatic transmission ........ 545
Brake .................................... 546
Washer ................................. 462
Fog light Replacing light bulbs ............ 490
Switch................................... 214
Footwell lights ..... ................... 410
Four-wheel drive system ....... 361
Front fog light Replacing light bulbs ............ 490
Front passenger occupant clas- sification system .................... 46 Front seats ..............................133
Adjustment ...........................133
Cleaning ...............................445
Correct driving posture ...........27
Driving position memory .......137
Head restraints .....................140
Memory recall function .........139
Power easy access system ..137
Seat heaters ....... ..................407
Seat position memory...........137
Seat ventilators.....................407
Front tray light ........................410
Front turn signal lights ..........204 Turn signal lever ...................204
Front turn signal/parking lights Replacing light bulbs ....490, 491
Wattage ................................548
Fuel Capacity ...............................542
Fuel gauge .............................91
Information ......... ..................549
Opening the fuel tank cap ....222
Type......................................542
Warning light.........................507
Fuel consumption Average fuel economy ............97
Current fuel consumption .......97
Fuel door When the fuel door cannot be opened ...............................526
Fuel economy ...........................97
Fuel gauge.................................91
Fuses .......................................487
G
Garage door opene r ...............433
Gauges ......................................91
Glove box ................................413
Glove box light........................410

600Alphabetical Index
Owners Manual_USA_M0C031_en
H
Head restraints ....................... 140
Head-up display ..................... 102 Driving support system display area .................................... 104
HUD (Head-up display) switch ........................................... 103
Hybrid System Indicator ....... 105
Navigation system-linked dis- play area ............................ 104
Outside temperature ............ 102
Pop-up display ..................... 104
Settings ................................ 103
Headlights Automatic High Beam system........................................... 214
Light switch .......................... 211
Replacing light bulbs ............ 490
Heated steering wheel ........... 407
Heaters Automatic air conditioning sys-tem ..................................... 400
Heated steering wheel ......... 407
Outside rear view mirrors ..... 401
Seat heaters ......................... 407
High mounted stoplight Replacing light bulbs ............ 490
High-voltage components ....... 76
Hill-start assist control .......... 375
Hood ........................................ 456 Open .................................... 456
Hooks Coat hooks ........................... 426
Retaining hooks (floor mat) .... 26
Horn ......................................... 144
HUD (Head-up display) switch ............................................... 103
Hybrid battery (tr action battery)
Location.................................. 76
Warning message .................. 79 Hybrid battery (traction battery)
air intake vents .......................79Cleaning ...............................481
Hybrid Electric Vehicle driving tips .........................................390
Hybrid Power Meter ..................94
Hybrid system .... .......................73
Acoustic vehicle alerting system .............................................75
Emergency shut off system ....79
High voltage components .......76
Hybrid system precautions .....76
If the hybrid sys tem will not start
...........................................524
Power (ignition) switch .........195
Regenerative braking .............74
Starting the hybrid system ....195
Warning lights .......................502
Hybrid System Indicator ..97, 105
I
Identification Vehicle ..................................541
Ignition switch (power switch) ...............................................195Auto power off fun ction .........198
Changing the power switch modes.................................198
If your vehicle has to be stopped in an emergency .................494
Starting the hybrid system ....195
Immobilizer system ..................81
Indicators ..................................89
Initialization Items to initialize ...................571
Parking Support Brake .........292
Power windows ....................160
Tire pressure w arning system
...........................................470
Inside rear view m irror ...........145

Owners Manual_USA_M0C031_en
Alphabetical Index603
OpenerHood..................................... 456
Opening the fuel tank cap .... 222
Tailgate ................................. 121
Outside rear view mirrors Adjustment ........................... 156
BSM (Blind Spot Monitor)..... 267
Folding ................................. 157
Mirror position memory ........ 137
Outside rear view mirror defog-gers .................................... 401
RCTA (Rear Cross Traffic Alert) ........................................... 281
Outside temperature ........ 91, 105
Overheating ............................ 535
P
Panic mode ............................. 112
Panoramic moon roof ............ 164
Panoramic view monitor ........ 310 Camera switch ..................... 312
Checking around the vehicle 315
Checking the bed ................. 329
Checking the front and around the vehicle .......................... 316
Checking the rear and around the vehicle .......................... 320
Customizing the panoramic view monitor ............................... 330
Display ................................. 313
Driving precautions .............. 310
Magnifying function .............. 329
Menu button ......................... 312
Panoramic view monitor precau- tions.................................... 330
Things you should know....... 341
Parking assist sensors (intuitive parking assist) ...................... 274
Parking brake ......................... 205 Brake system warning light .. 501 Parking brake engaged warning
buzzer.................................207
Warning light.........................506
Warning message.................207
Parking lights Light switch........................... 211
Parking Support Brake (PKSB) ...............................................287Enabling/disabling the system ...........................................289
Parking Support Brake function (rear-crossing vehicles) ......295
Parking Support Brake function (static objects) ....................292
Warning lights .......................504
Warning message.................291
PCS (Pre-Collision System) ...230 Enabling/disabling the system...........................................234
Function................................230
Warning light.........................503
Personal lights ........................410
Pitch and roll gauges ...............94
PKSB (Parking Support Brake) ...............................................287Enabling/disabling the system ...........................................289
Parking Support Brake function (rear-crossing vehicles) ......295
Parking Support Brake function (static objects) ....................292
Warning lights .......................504
Warning message.................291
Power back window ...............163
Power bed step .......................126
Power control unit ....................76
Power control unit coolant ....460 Capacity ...............................544
Checking ..............................460
Power easy access system ...137
Power outlet ............................426

Owners Manual_USA_M0C031_en
Alphabetical Index605
Cleaning and maintaining the seat belt.............................. 445
Emergency Locking Retractor 31
How to wear your seat belt..... 30
How your child should wear the seat belt................................ 30
Pregnant women, proper seat belt use................................. 29
Reminder light and buzzer ... 507
Seat belt extender .................. 30
Seat belt pretensioners .......... 34
SRS warning light................. 502
Seat heaters ............................ 407
Seat position memory ............ 137
Seat ventilators ...................... 407
Seating capacity ............. 180, 541
Seats ................................ 133, 134 Adjustment ........................... 133
Adjustment precautions133, 134, 136
Child seats/child restraint system installation ............................ 53
Cleaning ............................... 445
Driving position memory....... 137
Folding down and returning the rear seatbacks.................... 134
Head restraints ..................... 140
Power easy access system .. 137
Properly sitting in the seat ...... 27
Seat heaters ......................... 407
Seat position memory .......... 137
Seat ventilators .................... 407
Sensor Automatic headlight system . 211
Automatic High Beam system........................................... 214
BSM (Blind Spot Monitor)..... 268
Dynamic radar cruise control with full-speed range .......... 225 Inside rear view mirror ..........145
Intuitive parking assist ..........274
LTA (Lane Tracing Assist) .....242
Parking Support Brake function
(rear-crossing vehicles) ......268
Parking Support Brake function (static objects) ....................274
PCS (Pre-Collisio n System) .225
Radar sensor ........................225
Rain-sensing windshield wipers ...........................................220
RCTA (Rear Cross Traffic Alert) ...........................................268
Service plug ..............................76
Shift lever ................................201 Automatic transm ission ........200
If th e s hif t le ver ca n no t b e s hif te d from P .................................201
Shift lever light........................410
Shift lock system ....................201
Side airbags ..............................36
Side marker lights Light switch........................... 211
Replacing light bulbs ............490
Side mirrors Adjustment ...........................156
BSM (Blind Spot M onitor) .....267
Folding..................................157
Heaters .................................401
Mirror position me mory.........137
RCTA (Rear Cross Traffic Alert) ...........................................281
Side turn signal lights ............204 Replacing light bulbs ............490
Turn signal lever ...................204
Side windows ..........................160
Smart key system ...................128 Antenna location...................128
Entry functions.............. 113, 120
Starting the hybrid system ....195
Snow tires ...............................395