battery TOYOTA URBAN CRUISER 2015 Workshop Manual

488
5-2. Steps to take in an emergency
URBAN CRUISER_OM_OM52F47E_(EE)
Connect the jumper cables.
Gasoline engine
Positive (+) battery terminal on your vehicle
Positive (+) battery terminal on the second vehicle
Negative (-) battery terminal on the second vehicle
Connect the jumper cable to ground on your vehicle as shown in
the illustration.
Diesel engineSTEP2

5
489
5-2. Steps to take in an emergency
When trouble arises
URBAN CRUISER_OM_OM52F47E_(EE)
Remove the engine cover
Positive (+) battery terminal on your vehicle
Positive (+) battery terminal on the second vehicle
Negative (-) battery terminal on the second vehicle
Connect the jumper cable to ground on your vehicle as shown in
the illustration.
Start the engine of the second vehicle. Increase the engine
speed slightly and maintain at that level for approximately 5
minutes to recharge the battery of your vehicle.
Vehicles with smart entry & start system: Open and close
any of the doors with the “ENGINE START STOP” switch
OFF.
Vehicles without smart entry & start system: Maintain the
engine speed of the second vehicle and turn the engine
switch to the “ON” position, then start the vehicle’s engine.
Vehicles with smart entry & start system: Maintain the
engine speed of the second vehicle and turn the “ENGINE
START STOP” switch to the IGNITION ON mode, then start
the vehicle’s engine.
Once the vehicle’s engine has started, remove the jumper
cables in the exact reverse order in which they were con-
nected.
STEP3
STEP4
STEP5
STEP6

5
491
5-2. Steps to take in an emergency
When trouble arises
URBAN CRUISER_OM_OM52F47E_(EE)
■
To prevent battery discharge
●Turn off the headlights and the audio system while the engine is turned
off.
● Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic, etc.
■ Charging the battery
The electricity stored in the battery will discharge gradually even when the
vehicle is not in use, due to natural discharge and the draining effects of cer-
tain electrical appliances. If the vehicle is left for a long time, the battery may
discharge, and the engine may be unable to start. (The battery recharges
automatically during driving.)
■ When the battery is removed or discharged
Make sure that the key is not inside the vehicle when recharging or replacing
the battery. The key may be locked in the vehicle if the alarm is activated.
(→ P. 122)
CAUTION
■Avoiding battery fires or explosions
Observe the following precautions to prevent accidentally igniting the flam-
mable gas that may be emitted from the battery.
●Make sure the jumper cable is connected to the correct terminal and that it
is not unintentionally in contact with any other than the intended terminal.
● Do not allow the + and - clamps of the jumper cables to come into contact
with each other.
● Do not smoke, use matches, cigarette lighters or allow open flame near
the battery.

492
5-2. Steps to take in an emergency
URBAN CRUISER_OM_OM52F47E_(EE)
CAUTION
■ Battery precautions
The battery contains poisonous and corrosive acidic electrolyte, while
related parts contain lead and lead compounds. Observe the following pre-
cautions when handling the battery.
●When working with the battery, always wear safety glasses and take care
not to allow any battery fluids (acid) to come into contact with skin, clothing
or the vehicle body.
● Do not lean over the battery.
● In the event that battery fluid comes into contact with the skin or eyes,
immediately wash the affected area with water and seek medical attention.
Place a wet sponge or cloth over the affected area until medical attention
can be received.
● Always wash your hands after handling the battery support, terminals, and
other battery-related parts.
● Do not allow children near the battery.
■ To prevent damaging the vehicle
Do not pull- or push-start the vehicle, because the catalytic converter may
overheat and become a fire hazard.
NOTICE
■When handling jumper cables
When connecting the jumper cables, ensure that they do not become entan-
gled in the cooling fans or belt.
■ To prevent damage to the engine cover (diesel engine only)
●When removing the cover, make sure that you pull the cover towards you
after lifting the front edge to remove the fixed pins.
● When installing the cover, do not force the cover or subject it to strong
shocks.

517
6-1. Specifications
6
Vehicle specifications
URBAN CRUISER_OM_OM52F47E_(EE)
Ignition system (gasoline engine)
Electrical system
Spark plug
Make DENSO SC20HR11
Gap 1.1 mm (0.043 in.)
NOTICE
■
Iridium-tipped spark plugs
Use only iridium-tipped spark plugs . Do not adjust spark plug gap.
Battery
Specific gravity reading at
20°C (68 °F): 1.250
 1.290 Fully charged
1.160  1.200 Half charged
1.060  1.100 Discharged
Charging rates
Quick charge
Slow charge 15 A max.
5 A max.

528
URBAN CRUISER_OM_OM52F47E_(EE)
6-3. Initialization
Items to initialize
*: Diesel engine only
ItemWhen to initializeReference
Engine oil mainte-
nance data
*After changing engine oil P. 375
The following items must be initia lized for normal system operation
in cases such as after the battery is reconnected, or maintenance is
performed on the vehicle.

531
URBAN CRUISER_OM_OM52F47E_(EE)
Alphabetical index
Alphabetical index
A/CAir conditioning filter.............. 395
Automatic air conditioning system ................................ 259
Manual air conditioning
system ................................ 252
ABS ........................................... 223
Active head restraint ................. 76
Active Torque Control 4WD system ........................... 223
Air conditioning filter .............. 395
Air conditioning system
Air conditioning filter.............. 395
Automatic air conditioning system ................................ 259
Manual air conditioning system ................................ 252
Airbags Airbag manual on-off system ................................ 140
Airbag operating conditions ........................... 129
Airbag precautions for your
child .................................... 134
Airbag warning light .............. 440
Curtain shield airbag operating conditions ........... 129
Curtain shield airbag precautions ......................... 134
General airbag precautions... 134
Locations of airbags.............. 126
Modification and disposal of airbags................................ 139
Proper driving posture... 124, 134
Side airbag operating conditions ........................... 129
Side airbag precautions ........ 134
SRS airbags .......................... 126 Alarm ........................................ 120
Antenna .................................... 277
Anti-lock brake system .......... 223
Assist grips .............................. 343
Audio system
Antenna ................................ 277
CD player .............................. 278
MP3/WMA disc ..................... 285
Optimal use........................... 293
Radio .................................... 274
Steering wheel audio switch ................................. 297
Type ...................................... 272
Automatic air conditioning system .................................... 259
AUX port ................................... 296
Auxiliary box .................... 335, 346
Back-up lights Replacing light bulbs............. 418
Wattage ................................ 522
Back door
Back door................................ 70
Back door handle .................... 71
Wireless remote control key ... 57
Battery Checking ............................... 380
If the vehicle has discharged battery ................................ 487
Preparing and checking before winter....................... 235
Bottle holder ............................ 334
Brake Parking brake........................ 194
Brake assist ............................. 223
Break-in tips ............................. 170
Brightness control Instrument light control ......... 197A
B

532
Alphabetical index
URBAN CRUISER_OM_OM52F47E_(EE)
Care
Exterior.................................. 350
Interior ................................... 354
Seat belts .............................. 355
Cargo capacity ......................... 232
Cargo hooks ............................. 346
CD player .................................. 278
Chains ....................................... 235
Child restraint system
Baby seats, definition ............ 143
Baby seats, installation ......... 153
Child seats, definition ............ 143
Child seats, installation ......... 153
Installing CRS with ISOFIX rigid anchor......................... 159
Installing CRS with seat belts .................................... 155
Installing CRS with top straps.................................. 161
Junior seats, definition .......... 143
Junior seats, installation........ 153
Child safety Airbag precautions ................ 134
Battery precautions ....... 384, 492
Child-protectors....................... 68
Child restraint system ........... 143
How your child should wear
the seat belt .......................... 90
Installing child restraints........ 153
Power window lock switch .... 101
Power window precautions ... 104
Removed key battery
precautions ......................... 401
Seat belt precautions .............. 91
Seat heater precautions ......................... 342 Child-protectors......................... 68
Cigarette lighter ....................... 340
Cleaning
Exterior ................................. 350
Interior................................... 354
Seat belts .............................. 355
Clock ......................................... 338
Clutch pedal ..................... 168, 189
Condenser ................................ 379
Cooling system Engine overheating ............... 493
Cup holders.............................. 332
Curtain shield airbags ............. 126
Customizable features ............ 526
Daytime running light system .................................... 210
Defogger Rear window ......................... 270
Side mirror ............................ 270
Dimension ................................ 506
Display Trip information ..................... 202
Do-it-yourself maintenance .... 362
Door lock Back door................................ 70
Side door ................................ 66
Wireless remote control key ... 57
Doors Back door................................ 70
Door glasses ......................... 101
Door lock..................... 36, 57, 66
Double locking system .......... 118
Side doors............................... 66
Side mirrors ............................ 98C
D

533
Alphabetical index
URBAN CRUISER_OM_OM52F47E_(EE)
Double locking system............ 118
Driver’s seat belt reminder
light ......................................... 442
Driving Break-in tips .......................... 170
Correct posture ..................... 124
Procedures............................ 168
Winter driving tips ................. 235
Electronic key If your electronic key battery is discharged ...................... 484
Electric power steering ........... 223
Emergency flasher................... 428
Emergency tire puncture repair kit ................................. 464
Emergency, in case of If the electronic key does not operate properly ................. 484
If the engine will not start ...... 480
If the vehicle has discharged battery................................. 487
If the warning buzzer sounds ................................ 439
If the warning light turns on ... 439
If you cannot operate back door opener ........................ 483
If you have a flat tire ..... 449, 464
If you lose your keys ............. 482
If you think something is
wrong.................................. 437
If you run out of fuel and the engine stalls.................. 497
If your vehicle becomes
stuck ................................... 500
If your vehicle has to be stopped
in an emergency ................. 502
If your vehicle needs to be towed .................................. 429
If your vehicle overheats ....... 493 Engine
Compartment ........................ 370
Engine switch................ 185, 181
Hood ..................................... 366
How to start the engine......................... 168, 185
Identification number ............ 507
If the engine will not start ...... 480
If you run out of fuel and the engine stalls ................. 497
Ignition switch ............... 185, 181
Overheating .......................... 493
Engine coolant Capacity ................................ 516
Checking ............................... 377
Preparing and checking before winter....................... 235
Engine immobilizer system .... 110
Engine oil Capacity ................................ 511
Checking ............................... 372
Preparing and checking before winter....................... 235
Engine switch .................. 185, 181
EPS ........................................... 223
Floor mat .................................. 344
Fluid Washer ................................. 386
Front fog lights Replacing light bulbs............. 418
Switch ................................... 211
Wattage ................................ 522
Front passenger’s seat belt
reminder light ........................ 442
E
F

535
Alphabetical index
URBAN CRUISER_OM_OM52F47E_(EE)
Keyless entry ............................. 36
Keys
Electronic key.......................... 32
If you lose your keys ............. 482
If your key battery is discharged .............. 399, 398
Ignition switch ............... 185, 181
Key number plate .................... 32
Keyless entry .......................... 36
Keys ........................................ 32
Mechanical key ....................... 32
Wireless remote control key.... 57
Knee airbag .............................. 126
License plate lights Replacing light bulbs ............. 418
Wattage................................. 522
Light bulbs Replacing .............................. 418
Wattage................................. 522
Lights Emergency flasher switch ..... 428
Fog light switch ..................... 211
Hazard lights switch .............. 428
Headlight switch .................... 207
Interior lights ......................... 328
Personal light switch ............. 329
Replacing light bulbs ............. 418
Turn signal lever ................... 193
Wattage................................. 522
Luggage compartment Auxiliary box.......................... 346
Cargo hooks.......................... 346
Luggage cover ...................... 347
Luggage cover ......................... 347 Maintenance
Do-it-yourself maintenance ... 362
Maintenance data ................. 506
Maintenance requirements ... 358
Manual air conditioning
system .................................... 252
Manual headlight leveling dial .......................................... 209
Manual transmission ............... 189
Meter Instrument cluster light
control................................. 197
Meters ................................... 196
Mirrors Inside rear view mirror ............ 96
Side mirrors ............................ 98
Vanity mirrors........................ 337
MP3 disc ................................... 285
Multi-information display .................................... 202
Odometer.................................. 202
Oil Engine oil .............................. 372
Opener Back door................................ 70
Fuel filler door ....................... 105
Hood ..................................... 366
Outside rear view mirrors Adjusting ................................. 98
Defogger ............................... 270
Folding .................................... 99
Outside temperature display .................................... 202
Overheating, Engine................ 493K
L
M
O