check engine TOYOTA VENZA 2016 Service Manual

5
When trouble arises
5755-2. Steps to take in an emergency
VENZA_OM_OM73030U_(U) ■
If the tire pressure warning light frequently comes on after blinking
for 1 minute
Vehicles with smart key system
If the tire pressure warning light frequently comes on after blinking for
1 minute when the “ENGINE START ST OP” switch is turned to IGNI-
TION ON mode, have it checked by your Toyota dealer.
Vehicles without smart key system
If the tire pressure warning light comes on after blinking 1 minute fre-
quently when the engine switch is tu rned to the “ON” position, have it
checked by your Toyota dealer.
CAUTION■
When the electric power steering system warning light comes on
The steering wheel may become extrem ely heavy. If the steering wheel
becomes heavier than usual when operating, hold firmly and operate
using more force than usual.■
If the tire pressure warning light comes on
Be sure to observe the following precautions. Failure to do so could
cause loss of vehicle control and result in death or serious injury. ●
Stop your vehicle in a safe place as soon as possible. Adjust the tire
inflation pressure immediately. ●
If the tire pressure warning light comes on even after tire inflation pres-
sure adjustment, it is pr obable that you have a flat tire. Check the tires.
If the tire is flat, change to the spare tire and have the flat tire repaired
by the nearest Toyota dealer.
●
Avoid abrupt maneuvering and braking. If the vehicle tires deteriorate,
you could lose control of the steering wheel or the brakes.

5865-2. Steps to take in an emergency
VENZA_OM_OM73030U_(U) CAUTION■
Using the tire jack
Improper use of the tire jack may lead to death or serious injuries due to
the vehicle suddenly falling off the jack. ●
Do not use the tire jack for any pu rpose other than replacing tires or
installing and removing tire chains.●
Only use the tire jack that comes with this vehicle for replacing a flat
tire.
Do not use it on other vehicles, and do not use other tire jacks for
replacing tires on this vehicle.●
Always check that the tire jack is securely set to the jack point.●
Do not raise the vehicle while someone is in it.●
When raising the vehicle, do not put an object on or under the jack.●
Do not raise the vehicle to a hei ght greater than that required to
replace the tire.●
Use a jack stand if it is necessary to get under the vehicle.●
Do not put any part of your body under the vehicle supported by a jack.●
Do not start or run the engine while your vehicle is supported by the
jack.
Take particular care when lowering the vehicle to ensure that no one
working on or near the vehicle may be injured.

5925-2. Steps to take in an emergency
VENZA_OM_OM73030U_(U) Emergency start function (vehicles with smart key system)
When the engine does not start, the following steps can be used as
an interim measure to start the engine if the “ENGINE START STOP”
switch is functioning normally.
Set the parking brake.
Shift the shift lever to “P”.
Set the “ENGINE START ST OP” switch to ACCESSORY
mode.
Press and hold the “ENGINE START STOP” switch for about
15 seconds while depressing the brake pedal firmly.
Even if the engine can be start ed using the above st eps, the system
may be malfunctioning. Have the vehicle checked by your Toyota
dealer. STEP 1
STEP 2
STEP 3
STEP 4

6005-2. Steps to take in an emergency
VENZA_OM_OM73030U_(U) ■ Starting the engine when the battery is discharged
The engine cannot be started by push-starting.
■ Avoiding a discharged battery
● Turn off the headlights and the audio system while the engine is turned
off.
● Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic, etc.
■ When the battery is removed or discharged
● The power back door must be initialized. (  P. 60)
● Make sure that the key is not inside the vehicle when recharging or
replacing the battery. The key may be locked in the vehicle if the alarm is
activated. (  P. 114)Start the engine of the second vehicle. Increase the engine
speed slightly and maintain at that level for approximately 5
minutes to recharge the battery of your vehicle.
Vehicles with smart key system: Open and close any of the
doors with the “ENGINE START STOP” switch off.
Maintain the engine speed of the second vehicle and turn
the “ENGINE START STOP” switch to IGNITION ON mode
(vehicles with smart key system) or turn the engine switch
to the “ON” position (vehicles without smart key system),
then start your vehicle’s engine.
Once the vehicle’s engine has started, remove the jumper
cables in the exact reverse order in which they were con-
nected.
Once the engine starts, have the vehicle checked at your Toyota
dealer as soon as possible. STEP 2
STEP 3
STEP 4
STEP 5

6045-2. Steps to take in an emergency
VENZA_OM_OM73030U_(U) Add coolant if necessary. Water can be used in an emer-
gency if coolant is unavailable.
Start the engine and turn the air conditioning system on to
check that the radiator cooling fans operate and to check for
coolant leaks from t he radiator or hoses.
The fans operate when the air conditioning system is turned
on immediately after a cold star t. Confirm that the fans are
operating by checking the fan sound and air flow. If it is diffi-
cult to check these, turn the air conditioning system on and off
repeatedly.
(The fans may not operate in freezing temperatures.)
If the fans are not operating:
Stop the engine immediately and contact your Toyota
dealer.
If the fans are operating:
Have the vehicle inspected at the nearest Toyota dealer. STEP 5
STEP 6
STEP 7

6166-1. Specifications
VENZA_OM_OM73030U_(U) Lubrication system
* : The engine oil capacity is a reference quantity to be used when changing the
engine oil. Warm up and turn off the engine, wait more than 5 minutes, and
check the oil level on the dipstick.
■ Engine oil selection
“Toyota Genuine Motor Oil” is used in your Toyota vehicle. Use
Toyota approved “Toyota Genuine Motor Oil” or equivalent to satisfy
the following grade and viscosity.
Oil grade: ILSAC GF-5 multigrade engine oil Oil capacity
(Drain and refill 
reference
* )
1AR-FE engine
2GR-FE engine Without filter: 4.2 qt. (4.0 L, 3.5 Imp.qt.)
With filter: 4.6 qt. (4.4 L, 3.9 Imp.qt.)
Without filter: 6.0 qt. (5.7 L, 5.0 Imp.qt.)
With filter: 6.4 qt. (6.1 L, 5.4 Imp.qt.)

6196-1. Specifications
6
Vehicle specifications
VENZA_OM_OM73030U_(U) Ignition system
Electrical system
Rear differential (AWD models) Spark plug
Make DENSO
2GR-FE engine
1AR-FE engine
Gap FK20HR11
SK16HR11
0.043 in. (1.1 mm)
NOTICE■ Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust gap when tuning engine.
Battery
Open voltage at
68  F (20  C): 12.6  12.8 V Fully charged
12.2  12.4 V Half charged
11 . 8  12.0 V Discharged
(Voltage is checked 20 minutes after the
engine and all the lights are turned off.)
Charging rates 5 A max.
Oil capacity 0.5 qt. (0.5 L, 0.4 Imp.qt.)
Oil type and viscosity Toyota Genuine Differential gear oil LT
75W-85 GL-5 or equivalent

678Alphabetical index
VENZA_OM_OM73030U_(U) Daytime running light
system .................................... 214
Defogger
Rear window ......................... 316
Dimension................................. 612
Dinghy towing .......................... 302
Display
Fuel consumption
information .......................... 210
Shift position and shift
range................................... 182
Trip information ............. 194, 206
Warning messages ............... 578
Do-it-yourself main tenance..... 483
Door courtesy lights
Door courtesy lights .............. 430
Wattage ................................. 624
Door lock
Back door ................................56
Side door .................................50
Wireless remote control key ....45
Doors
Back door ................................56
Side door .................................50
Side mirrors .............................92
Driver’s seat belt reminder
light ......................................... 567
Driving
Break-in tips .......................... 164
Correct posture ..................... 117
Procedures ............................ 162
Utility vehicle precautions...... 264
Winter driving tips.................. 276
Driving position memory...........73
Electric power steering ........... 256
Electronic key
If your electronic key
battery is discharged... 523, 595 Emergency, in case of
If a warning message is
displayed ............................ 578
If the electronic key does
not operate properly ........... 595
If the engine will not start ...... 590
If the shift lever cannot be
shifted from “P” ................... 593
If the vehicle has discharged
battery ................................ 598
If the warning buzzer
sounds ................................ 564
If the warning light turns on ... 564
If you have a flat tire ............. 579
If you lose your keys ............. 594
If you think something is
wrong .................................. 561
If your vehicle becomes
stuck ................................... 606
If your vehicle has to be
stopped in an emergency ... 608
If your vehicle needs to be
towed .................................. 555
If your vehicle overheats ....... 603
Emergency flashers................. 554
Engine
Compartment ........................ 491
Engine switch ................ 173, 177
Hood ..................................... 487
How to start the
engine ......................... 173, 177
Identification number............. 613
If the engine will not start ...... 590
Ignition switch ............... 173, 177
Overheating .......................... 603
Engine coolant
Capacity ................................ 618
Checking ............................... 497
Preparing and checking
before winter ....................... 276D
E

679Alphabetical index
VENZA_OM_OM73030U_(U) Engine coolan t temperature
gauge ..................................... 188
Engine immobilizer system .... 109
Engine oil
Capacity ............................... 616
Checking .............................. 493
Preparing and checking
before winter ...................... 276
Engine switch .................. 173, 177
Entune Audio Plus
* EPS ........................................... 256
Event data recorder .................. 23
Floor mat .................................. 453
Fluid
Brake .................................... 500
Washer ................................. 505
Fog lights
Replacing light bulbs ............ 543
Switch ................................... 223
Wattage ................................ 624
Four-wheel drive system ........ 257
Front fog lights
Replacing light bulbs ............ 543
Switch ................................... 223
Wattage ................................ 624
Front passenger occupant
classification system............ 134
Front passenger’s seat belt
reminder light ........................ 567
Front seats
Adjustment ............................. 67
Driving position memory ......... 73
Front side marker light
Replacing light bulbs ............ 546
Wattage ................................ 624
Front turn signal lights
Replacing light bulbs ............ 544
Wattage ................................ 624 Fuel
Capacity ................................615
Fuel gauge ............................188
Fuel pump shut off system ....563
Information ............................626
Refueling ...............................105
Type ......................................626
Fuel door...................................105
Fuel filler door ..........................105
Fuel pump shut off
system ....................................563
Fuses.........................................527
Garage door opener.................457
Gauges ......................................188
Glove box..................................435
Glove box light .........................435
Hands-free system
(for cellular phone) ................379
HD Radio ®
system
* Head restraints
Adjusting .................................78
Headlights
Replacing light bulbs .............537
Switch....................................212
Wattage .................................624
Heaters
Seat heaters ..........................449
Side mirror.............................316
Hill-start assist control ............262
Hood ..........................................487
Hooks
Cargo hook............................455
Shopping bag hooks .............455
Horn...........................................187F G
H
* : Refer to “NAVIGATION AND MULTIMEDIA SYSTEM OWNER’S MANUAL”.

683Alphabetical index
VENZA_OM_OM73030U_(U) Switch
Driving position memory
switches ............................... 73
Emergency flasher switch .... 554
Engine switch ............... 173, 177
Fog light switch..................... 223
Ignition switch ............... 173, 177
Intuitive parking assist
switch ................................. 235
Light switches ....................... 212
Power back door .................... 56
Power door lock switch........... 51
Power window switch ............. 96
Rear window wiper and
washer switch .................... 229
Steering wheel
switches ..................... 323, 396
Talk switch
* ......................... 426
Telephone switches.............. 396
Window lock switch ................ 96
Wipers and washer switch.... 225
Tachometer .............................. 188
Tail lights
Replacing light bulbs ............ 547
Switch ................................... 212
Wattage ................................ 624
Talk switch
* ............................. 426
Telephone switches ................ 396
Theft deterrent system
Alarm .................................... 112
Engine immobilizer system... 109
Theft prevention labels ........... 116
Tire inflation pressure ............ 513
Tire pressure warning
system ................................... 507 Tire information
Glossary ................................637
Size .......................................633
Tire identification number ......632
Uniform tire quality grading ...635
Tires
Chains ...................................278
Checking ...............................506
If you have a flat tire ..............579
Inflation pressure...................513
Information ............................630
Pressure warning system ......507
Replacing ..............................579
Rotating tires .........................506
Size .......................................622
Snow tires .............................276
Spare tire...............................579
Tonneau cover .........................456
Tools .........................................579
Total load capacity...................274
Towing
Dinghy towing........................302
Emergency towing.................555
Trailer towing.........................281
TRAC .........................................256
Traction control........................256
Trailer towing ...........................281
Trip information
display ............................194, 206
Trip meter .................................188
Turn signal lights
Replacing light bulbs .....544, 547
Switch....................................185
Wattage .................................624
USB port ...................................325
Utility vehicle precautions ......264T
U
* : Refer to “NAVIGATION AND MULTIMEDIA SYSTEM OWNER’S MANUAL”.