belt TOYOTA VERSO 2013 Workshop Manual

556 5-2. Steps to take in an emergency
VERSO_WE_OM64550E_EURO5
NOTICE
To prevent damaging the vehicle (vehicles with a manual transmission)
Do not pull- or push-start the vehicle, because the catalytic converter may
overheat and become a fire hazard.
When handling jumper cables
Be careful that the jumper cables do not become tangled in the cooling fan
or any of the belts when connecting or disconnecting them.

5
559 5-2. Steps to take in an emergency
When trouble arises
VERSO_WE_OM64550E_EURO5If the fan is not operating:
Stop the engine immediately and contact any authorized
Toyota dealer or repairer, or another duly qualified and
equipped professional.
If the fan is operating:
Have the vehicle inspected at the nearest any authorized
Toyota dealer or repairer, or another duly qualified and
equipped professional.
CAUTION
To prevent an accident or injury when inspecting under the hood of
your vehicle
If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot, caus-
ing serious injuries such as burns.
Keep hands and clothing (especially a tie, a scarf or a muffler) away from
the fans and belts. Failure to do so may cause the hands or clothing to be
caught, resulting in serious injury.
Do not loosen the coolant reservoir cap while the engine and radiator are
hot.
Serious injury, such as burns, may result from hot coolant and steam
released under pressure.
NOTICE
When adding engine coolant
Wait until the engine has cooled down before adding engine coolant.
When adding coolant, do so slowly. Adding cool coolant to a hot engine too
quickly can cause damage to the engine.
To prevent damage to the cooling system
Observe the following precautions:
Avoid contaminating the coolant with foreign matter (such as sand or dust
etc.).
Do not use commercially available coolant additives.

570 6-1. Specifications
VERSO_WE_OM64550E_EURO5
Engine
Gasoline engine
Model 1ZR-FAE, 2ZR-FAE
Type 4-cylinder in line, 4-cycle, gasoline
Bore and stroke1ZR-FAE engine
80.5  78.5 mm (3.17  3.09 in.)
2ZR-FAE engine
80.5  88.3 mm (3.17  3.48 in.)
Displacement1ZR-FAE engine
1598 cm3 (97.5 cu. in.)
2ZR-FAE engine
1798 cm
3 (109.7 cu. in.)
Valve clearance
(engine cold)Automatic adjustment
Drive belt tension
Vehicles without air
conditioning system
Vehicles with air
conditioning system7.6  10.0 mm (0.30  0.39 in.)*
*: Drive belt deflection with 98 N (10 kgf, 22 lbf)
thumb force (used belt)
CrankshaftGenerator
Water pump
CrankshaftGenerator
Water pump
Air
conditioning
compressor

571 6-1. Specifications
6
Vehicle specifications
VERSO_WE_OM64550E_EURO5Diesel engine
Fuel
Gasoline engine
Model 1AD-FTV, 2AD-FHV
Ty p e4-cylinder in line, 4-cycle, diesel
(with turbo charger)
Bore and stroke1AD-FTV engine
86.0  86.0 mm (3.39  3.39 in.)
2AD-FHV engine
86.0  96.0 mm (3.39  3.78 in.)
Displacement1AD-FTV engine
1998 cm3 (121.9 cu. in.)
2AD-FHV engine
2231 cm
3 (136.1 cu. in.)
Valve clearance
(engine cold)Automatic adjustment
Drive belt tension Automatic adjustment
Fuel typeEU area:
Unleaded gasoline conforming to European stan-
dard EN228 only
Except EU area:
Unleaded gasoline only
Research octane number 95 or higher
Fuel tank capacity
(Reference)60 L (15.9 gal., 13.2 lmp.gal.)

602 Alphabetical index
VERSO_WE_OM64550E_EURO5
Back-up light
Replacing light bulb............... 459
Wattage................................. 589
Back door
Back door ................................ 79
Battery
Checking ............................... 423
If the vehicle has discharged
battery................................. 553
Preparing and checking
before winter ....................... 289
Bottle holders........................... 368
Brake
Parking brake ........................ 224
Brake assist.............................. 278
Break-in tips ............................. 185
Brightness control
Instrument panel light
control ................................. 231
Care
Exterior.................................. 396
Interior ................................... 400
Seat belts .............................. 401
Cargo capacity ......................... 286
Cargo hooks ............................. 386
CD player .................................. 328
Chains ....................................... 289
Child restraint system
Baby seats, definition ............ 157
Baby seats, installation ......... 165
Child seats, definition ............ 157
Child seats, installation ......... 165
Installing CRS with ISOFIX
rigid anchor ......................... 171
Installing CRS with seat
belts .................................... 166
Installing CRS with top
straps .................................. 172
Junior seats, definition .......... 157
Junior seats, installation........ 165Child safety
Airbag precautions ................ 152
Battery precautions ....... 426, 555
Child-protectors ...................... 75
Child restraint system ........... 157
How your child should wear
the seat belt .......................... 99
Installing child restraints ....... 165
Panoramic roof shade
precautions ......................... 115
Power window lock switch .... 111
Power window precautions ... 113
Removed key battery
precautions ......................... 443
Seat belt precautions ............ 100
Seat heater
precautions ......................... 378
Child-protectors......................... 75
Cleaning
Exterior ................................. 396
Interior................................... 400
Seat belts .............................. 401
Clock ........................................ 243
Condenser ................................ 423
Console box ............................. 365
Cooling system
Engine overheating ............... 557
Cruise control .......................... 263
Cup holders.............................. 367
Curtain shield airbags ............. 146
Customizable features ............ 594B
C

603 Alphabetical index
VERSO_WE_OM64550E_EURO5
Daytime running light
system .................................... 252
Deck board ............................... 386
Defogger
Rear window ......................... 316
Side mirrors........................... 316
Dimension ................................ 566
Display
Multi-information display ....... 236
Trip information ..................... 237
Warning message ................. 492
Do-it-yourself maintenance .... 406
Door courtesy lights
Door courtesy lights .............. 359
Wattage................................. 589
Doors
Back door ................................ 79
Door glasses ......................... 111
Door lock ..................... 42, 64, 73
Double locking system .......... 133
Rear door child protector ........ 75
Side doors ............................... 73
Side mirrors........................... 108
Double locking system............ 133
Driver’s and front passenger’s
seat belt reminder
light ......................................... 490
Driving
Break-in tips .......................... 185
Correct posture ..................... 144
Procedures............................ 182
Winter driving tips ................. 289Electronic power steering....... 278
Electronic key
If your electronic does not
operate properly ................. 550
Emergency flashers
Switch ................................... 476
Emergency tire puncture
repair kit ................................. 520
Emergency, in case of
If the electronic key does not
operate properly ................. 550
If the engine will not start ...... 544
If the shift lever cannot be
shifted from “P” ................... 547
If the vehicle has discharged
battery ................................ 553
If the warning buzzer
sounds ................................ 488
If the warning light
turns on .............................. 488
If the warning message is
displayed ............................ 492
If you cannot operate back
door opener ........................ 549
If you have a flat tire .... 504, 520
If you lose your keys ............. 548
If you think something is
wrong.................................. 486
If you run out of fuel and
the engine stalls ................. 560
If your vehicle becomes
stuck ................................... 561
If your vehicle has to be
stopped in an emergency ... 563
If your vehicle needs to be
towed .................................. 477
If your vehicle overheats ....... 557DE

607 Alphabetical index
VERSO_WE_OM64550E_EURO5
Odometer .................................. 227
Oil
Engine oil .............................. 416
Opener
Fuel filler door ....................... 117
Hood ..................................... 409
Outside rear view mirrors
Adjusting and folding............. 108
Outside temperature
display .................................... 237
Overhead console.................... 366
Overheating, Engine ................ 557
Panoramic roof shade ............. 114
Parking brake ........................... 224
Personal/interior lights
Switch ........................... 360, 361
Wattage................................. 589
Power heater ............................ 314
Power outlets ........................... 375
Power windows ........................ 111
Radiator .................................... 423
Radio ......................................... 324
Rear fog light
Replacing light bulb............... 459
Switch ................................... 256
Wattage................................. 589
Rear seats
Adjustment .............................. 86
Folding the seats..................... 89
Rear side sunshades ............... 382
Rear turn signal lights
Replacing light bulbs ............. 459
Switch ................................... 223
Wattage................................. 589
Rear window defogger ............ 316
Rear window wiper and
washer .................................... 262Replacing
Key battery............................ 440
Fuses .................................... 444
Light bulbs ............................ 459
Tires ...................................... 504
Roof luggage carrier ............... 286
Seatback tables ....................... 380
Seat belts
Adjusting the seat belt ............ 95
Child restraint system
installation .......................... 165
Cleaning and maintaining
the seat belts ...................... 401
Emergency Locking
Retractor............................... 99
How to wear your seat belt ..... 95
How your child should wear
the seat belt .......................... 99
Pregnant women, proper seat
belt use ............................... 100
Rear passenger’s seat belt
reminder display ......... 241, 495
Reminder light....................... 490
Seat belt pretensioners ........... 99
Seat heaters ............................. 377
Seats
Adjustment ........................ 84, 86
Adjustment precautions .... 85, 92
Child seats/child restraint
system installation .............. 165
Cleaning................................ 400
Front seats adjustment ........... 84
Head restraints ....................... 93
Properly sitting in the seat .... 144
Rear seats adjustment ............ 86
Seat heaters ......................... 377
Service reminder
indicators .............................. 232O
P
R
S

609 Alphabetical index
VERSO_WE_OM64550E_EURO5
Size ....................................... 586
Snow tires ............................. 289
Spare tire .............................. 504
Tools................................. 504, 520
Toyota parking
assist-sensor ......................... 270
Towing
Emergency towing ................ 478
Trailer towing ........................ 292
Traction control ....................... 278
Transmission shift
switches ......................... 206, 212
Trailer towing ........................... 292
TRC ........................................... 278
Trip information display .......... 237
Trip meter ................................. 227
Turn signal lights
Replacing light bulbs ............. 459
Switch ................................... 223
Wattage................................. 589
Vanity lights
Vanity lights........................... 373
Wattage................................. 589
Vanity mirrors .......................... 373
Vehicle identification
number ................................... 568
Vehicle stability control + ....... 278
VSC+ ......................................... 278
Warning buzzers
Brake system ........................ 488
Electric power steering
system buzzer .................... 489
Open door ............................. 495
Seat belt reminder................. 490Warning lights
Anti-lock brake system.......... 489
Automatic headlight leveling
system ................................ 489
Brake assist system .............. 489
Brake system ........................ 488
Charging system ................... 488
Cruise control........................ 489
Electric power steering
system warning light ........... 489
Engine coolant
temperature ........................ 488
Low fuel level ........................ 490
Malfunction indicator lamp .... 489
Master warning light.............. 490
Pretensioner ......................... 489
Seat belt reminder light ......... 490
SRS airbags.......................... 489
Warning messages
Back door.............................. 495
Clutch start system............... 493
Engine oil level...................... 495
Engine oil maintenance ........ 495
Engine oil pressure ............... 492
Fuel filter ............................... 493
Light reminder ....................... 495
Open door ............................. 495
Parking brake........................ 495
Rear passenger’s seat belt
reminder ............................. 495
Smart entry & start system ... 498
Speed limiter system ............ 493
Steering lock system............. 493
Traction control ..................... 493
Transmission fluid
temperature ........................ 495
Vehicle stability control ......... 493
V
W

614 What to do if...
VERSO_WE_OM64550E_EURO5
Warning lights
P. 4 8 8P. 489
P. 4 8 8P. 489
(Flashing)
P. 4 8 8P. 489
(Red)
P. 4 8 9P. 490
P. 4 8 9P. 491
P. 4 8 9P. 491
Electric power steering
system warning
light
Brake system warning
light
Charging system warn-
ing lightCruise control warning
light
High engine coolant
temperature warning
lightAutomatic headlight
leveling system warning
light
Malfunction indicator
lampLow fuel level warning
light
SRS warning light
ABS warning lightMaster warning light
Driver’s and front passen-
ger’s seat belt reminder
light
The warning message is
displayedP. 492If a warning message is displayed