catalytic converter TOYOTA xB 2005 Warranties & Maintenance Guides (in English)

These warranty obligations do not apply to failures or non-
compliance caused by:
›The use of replacement parts not certified in accordance
with aftermarket parts certification regulations.
›The use of replacement parts not equivalent in quality or
design to original equipment parts.
Provisions under the “What Is Not Covered” section of the New
Vehicle Limited Warranty also apply to this warranty.Air/Fuel Metering System
›Air/fuel ratio feedback control system
›Cold-start enrichment system
›Deceleration control system
›Electronic fuel injection system components
— Airflow sensor
— Engine control module (8/80)
— Throttle body
— Other components
Air Induction System
›Intake manifold and intake air surge tank
Catalyst System
›Catalytic converter and protector (8/80)
›Constricted fuel filler neck
›Exhaust manifold
›Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)
WHAT IS NOT COVERED WARRANTY PARTS LIST
Your Warranties in Detail15
Federal Emission Control Warranty ‹‹
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.

The California Air Resources Board (CARB) and Scion are
pleased to explain the emission control system warranty for
your 2005 vehicle. In California, new motor vehicles must be
designed, built and equipped to meet the state’s stringent anti-
smog standards. CARB regulations require that Scion must
warrant the emission control system on your vehicle for the
time periods indicated on this page, provided there has been
no abuse, neglect or improper maintenance of your vehicle.
Your emission control system may include parts such as the
fuel injection system, ignition system, catalytic converter and
engine computer. Also included may be hoses, belts, connectors
and other emissions-related assemblies.
Where a warrantable condition exists, Scion will repair your
vehicle at no cost to you, including diagnosis, parts and labor.1) For three years or 50,000 miles, whichever occurs first:
›If your vehicle fails a smog-check test, all necessary
repairs and adjustments will be made by Scion to ensure
that your vehicle passes the test. This is your Emission
Control System Performance Warranty.
›If any emissions-related part on your vehicle is defective,
the part will be repaired or replaced by Scion. This is your
Short-Term Emission Control System Defect Warranty.
Covered parts are listed on pages 15–16. Specific compo-
nents may have longer coverage under the terms of the
Powertrain Warranty.
2) For seven years or 70,000 miles, whichever occurs first:
›If an emissions-related part listed on pages 22—23 is
defective, the part will be repaired or replaced by Scion.
This is your Long-Term Emission Control System Defect
Warranty.
Your Warranties in Detail 20
›› California Emission Control Warranty
YOUR WARRANTY RIGHTS AND OBLIGATIONS MANUFACTURER’S WARRANTY COVERAGE

The parts listed here are covered for seven years or 70,000
miles from the vehicle’s in-service date, whichever occurs first.
Air/Fuel Metering System
›Engine control computer (engine control module)
›Throttle body
Air Induction System
›Intake manifold
Catalyst System
›Catalytic converter (warm-up three-way catalyst)
›Exhaust center pipe on tC
›Exhaust front pipe on xA and xB
›Exhaust manifold on tC
Evaporative Control System
›Fuel tankYou are responsible for performance of the required mainte-
nance indicated in the
Owner’s Manualand the Scheduled
Maintenance Guide
. Scion will not deny a warranty claim solely
because you do not have records to show that you maintained
your vehicle. However, any failure or noncompliance caused by
lack of maintenance is not covered by this warranty.
When maintenance and repairs are paid for by you, these
services may be performed by you or by any automotive
service provider you choose. Scion will not deny a warranty
claim solely because you used a service provider other
than an Authorized Servicing Dealership for maintenance
and repairs. However, any failure or noncompliance caused
by improper maintenance or repairs is not covered by this
warranty.
Your Warranties in Detail 22
›› California Emission Control Warranty
PARTS LIST: LONG-TERM EMISSION
DEFECT WARRANTYMAINTENANCE