fuel TOYOTA YARIS 2007 2.G Service Manual

2712007 YARIS HATCHBACK from Feb. ’07Prod. (OM52754U)
ENGINE OIL SELECTION
“Toyota Genuine Motor Oil” is used in
your Toyota vehicle. Use Toyota approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and viscos-
ity.
Oil grade:ILSAC multigrade engine oil.
Recommended viscosity:
SAE 5W −30
OIL008
Outside temperature
SAE 5W30 is the best choice for good
fuel economy, and good starting in cold
weather. If SAE 5W30 oil is not available, SAE
10W30 oil may be used. However, it
should be replaced with SAE 5W30 at
the next oil change.
API02
Oil identification mark
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is added to some oil con-
tainers to help you select the oil you
should use.

2752007 YARIS HATCHBACK from Feb. ’07Prod. (OM52754U)
Always use a tire pressure
gauge. The appearance of a tire
can be misleading. Besides, tire
inflation pressures that are even
just a few pounds off can degrade
ride and handling.
 Take special care when adding
air to the compact spare tire.
The smaller tire size can gain
pressure very qu ickly. Add com-
pressed air in small quantities and
check the pressure often until it
reaches the specified pressure.
 Do not bleed or reduce tire
inflation pressure after driving.
It is normal for the tire inflation
pressure to be higher after driving.
 Never exceed the vehicle capac-
ity weight. Passenger and lug-
gage weight should be located so
that the vehicle is balanced.
PS72503
Tire pressure gauge
INSPECTION AND ADJUSTMENT
PROCEDURE
1. Remove the tire valve cap.
2. Press the tip of the tire pressure gauge to the tire valve.
3. Read the pressure using the grad- uations of the gauge.
4. In case the tire inflation pressure
is not within the prescribed range,
insert the compressed air from the
valve. In case of applying too
much air, press the center of the
valve and release the air to adjust. 5. After completing the tire inflation
pressure measurement and ad-
justment, apply soapy water to the
valve and check for leakage.
6. Install the tire valve cap.
If a gauge and air pump are not avail-
able, have your vehicle checked by
your Toyota dealer.
CAUTION
Be sure to reinstall the tire valve
caps. Without the valve caps, dirt
or moisture could get into the
valve core and cause air leakage.
If the caps have been lost, have
new ones put on as soon as pos-
sible.
Incorrect tire infl ation pressure may
waste fuel, reduce the comfort of driv-
ing, reduce tire life and make your ve-
hicle less safe to drive.
If a tire frequently needs refilling,
have it checked by your Toyota deal-
er.

2952007 YARIS HATCHBACK from Feb. ’07Prod. (OM52754U)
SPECIFICATIONS
Specifications
Dimensions and weights296
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Engine 296
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . .
Fuel 296
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Service specifications 297
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . .
Tires 299
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . .
Fuses 300
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . .
SECTION 8

2962007 YARIS HATCHBACK from Feb. ’07Prod. (OM52754U)
Dimensions and weights
Overall length mm (in.) 3825 (150.6)
Overall width mm (in.) 1695 (66.7)
Overall height mm (in.) 1530 (60.2)
Wheelbase mm (in.) 2460 (96.9)
Front tread mm (in.) 1480 (58.3)
∗1
1470 (57.9)∗2
Rear tread mm (in.) 1470 (57.9)∗1
1460 (57.5)∗2
Vehicle capacity weight
(occupants + luggage)
kg (lb.) 383 (845)
Towing capacity
∗ 3
(trailer + cargo weight) kg (lb.) 318 (700)
∗1: With P175/65R14 81S tires∗2: With P185/60R15 84T tires∗3: For Canada only
Engine
Model:
1.5 L 4 −cylinder (1NZ− FE)
Type: 4 cylinder in line, 4 cycle, gasoline
Bore and stroke, mm (in.): 75.0  84.7 (2.95  3.33)
Displacement, cm
3 (cu. in.):
1496 (91.3)
Fuel
Fuel type: Unleaded gasoline, Octane Rating 87(Research Octane Number 91) or higher
Fuel tank capacity, L (gal., Imp. gal.): 42 (11.1, 9.2)

3002007 YARIS HATCHBACK from Feb. ’07Prod. (OM52754U)
Fuses
PS81501
Engine compartment
Fuses (type A)1. AM2 15 A: Starting system, multiport
fuel injection system/sequential multi-
port fuel injection system
2. HORN 10 A: Horn
3. EFI 20 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system
4. SPARE 30 A: Spare fuse
5. SPARE 15 A: Spare fuse
6. SPARE 10 A: Spare fuse
7. FR DEF 20 A: No circuit
PS81502
Instrument panel
8. ABS2/VSC2 30 A: Anti−lock brake sys-
tem
9. HLP MAIN 30 A: No circuit
10. ST 30 A: Starting system
11. SLOCK 20 A: No circuit
12. DOME 15 A: Interior light, personal
lights, theft deterrent system, audio
system, wireless remote control system
13. ECUB 7.5 A: Engine immobilizer sys-
tem, daytime running light system, front
passenger occupant classification sys-
tem, power windows, door lock system,
theft deterrent system, meter and
gauge
PS81503
Instrument panel
14. ALTS 7.5 A: Charging system
15. ETCS 10 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system, electronic throttle control
system
16. HAZ 10 A: Turn signal lights, emergen-
cy flashers
17. HLP RH/HLP LO RH 10 A: Right−
hand headlight
18. HLP LH/HLP LO LH 10 A: Left−
hand headlight
19. EFI2 10 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system

3012007 YARIS HATCHBACK from Feb. ’07Prod. (OM52754U)
PS81504
Instrument panel
20. ACC2 7.5 A: Shift lock system
21. TAIL 10 A: Side marker lights, parking
lights, tail lights, license plate lights,
multiport fuel injection system/sequen-
tial multiport fuel injection system
22. PANEL1 7.5 A: Illuminations, instru-
ment panel light control, meter and
gauge
23. A/C 7.5 A: Rear window defogger, air
conditioning system
24. D DOOR 20 A: No circuit
25. RL DOOR 20 A: Rear passenger ’s
power window (left side)
PS81505
Engine compartment
26. RR DOOR 20 A: Rear passenger ’s
power window (right side)
27. CIG 15 A: Power outlet
28. ACC 7.5 A: Door lock system, outside
rear view mirrors, audio system
29. ID/UP/MIR HTR 10 A: Multiport fuel
injection system/sequential multiport
fuel injection system
30. IGN 7.5 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, engine immobilizer system,
SRS airbag system, front passenger
occupant classification system 31. MET 7.5 A:
Meter and gauge
32. WIP 25 A: Windshield wiper
33. RR WIP 15 A: Rear wiper
34. WSH 15 A: Windshield wiper and rear
wiper
35. ECUIG 10 A: Daytime running light
system, anti −lock brake system, elec-
tric power steering system, power win-
dows, door lock system, theft deterrent
system, electric cooling fan
36. GAUGE 10 A: Charging system, turn
signal lights, emergency flashers,
buck −up lights, instrument panel light
control, shift lock system, rear window
defogger, air conditioning system, auto-
matic transmission system
37. OBD2 7.5 A: On−board diagnosis sys-
tem
38. STOP 10 A: Stop lights, high mounted
stop light, multiport fuel injection sys-
tem/sequential multiport fuel injection
system, shift lock system, anti −lock
brake system
39. D/L 25 A: Door lock system
40. FR FOG 15 A: Front fog lights
41. AM1 25 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system

Publication No. OM52754U
Part No. 01999-52754
Printed in Japan 01−0702 −00
(U)
U 4
I
Quick index
 If a service reminder indicator or warning buzzer comes on 114 . . . . . . .
 If your vehicle will not start 222 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
.
 If your engine stalls while driving 226 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 If you cannot increase engine speed 226 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 If your vehicle overheats 227 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . .
 If you have a flat tire 228 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . .
 If your vehicle needs to be towed 240 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 Tips for driving during break-in period 178 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 How to start the engine 208 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . .
 General maintenance 257 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . .
Gas station information
Fuel type:
UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91)
or higher
See page 178 for detailed information.
Fuel tank capacity:
42 L (11.1 gal., 9.2 lmp.gal.)
Engine oil:
ILSAC multigrade engine oil is recommended.
See page 271 for detailed information.
Tire information: See pages 274 through 281.
Tire inflation pressure: See page 299.
2007 YARIS HATCHBACK from Feb. ’07Prod. (OM52754U)