service VAUXHALL COMBO 2016 User Guide

Vehicle care133Vehicle storageStorage for a long period of time
If the vehicle is to be stored for several months:
● Wash and wax the vehicle.
● Have the wax in the engine compartment and underbody
checked.
● Clean and preserve the rubber seals.
● Fill up fuel tank completely.
● Change the engine oil.
● Drain the washer fluid reservoir.
● Check the coolant antifreeze and
corrosion protection.
● Adjust tyre pressure to the value specified for full load.
● Park the vehicle in a dry, well ventilated place. Engage first or
reverse gear to prevent the
vehicle from rolling.
● Do not apply the parking brake.● Open the bonnet, close all doors and lock the vehicle.
● Disconnect the clamp from the negative terminal of the vehicle
battery. Beware that all systems
are not functional, e.g. anti-theft
locking system.
Putting back into operation
When the vehicle is to be put back into
operation:
● Connect the clamp to the negative terminal of the vehicle
battery. Activate the electronics
of the power windows.
● Check tyre pressure.
● Fill up the washer fluid reservoir.
● Check the engine oil level.
● Check the coolant level.
● Fit the number plates if necessary.End-of-life vehicle recovery
Information on end-of-life vehicle
recovery centres and the recycling of
end-of-life vehicles is available on our website. Only entrust this work to an
authorised recycling centre.
Natural gas vehicles must be recycled by a service centre authorised for
natural gas vehicles.

Vehicle care153Relearn function
After changing wheels, TPMS needs
to recalculate. The relearn process
takes up to 20 minutes of driving with
a minimum speed of 15 mph.
If problems occur during the relearn
process, control indicator w flashes
for several seconds then illuminates
continuously and (depending on
version) a warning message is
displayed in the DIC.
Driver Information Centre (DIC) 3 85.
General information The use of tyre chains or
commercially available liquid tyre
repair kits can impair the function of
the system. Factory-approved tyre
repair kits can be used.
Tyre repair kit 3 154, Tyre chains
3 154.
External high-power radio equipment
could disrupt the TPMS.
Each time the tyres are replaced,
TPMS sensors must be dismounted
and serviced by a workshop.Tread depth
Check tread depth at regular
intervals.
Tyres should be replaced for safety
reasons at a tread depth of 2-3 mm
(4 mm for winter tyres).
For safety reasons, it is
recommended that the tread depth of the tyres on one axle should not vary
by more than 2 mm.
The legally permissible minimum
tread depth (1.6 mm) has been
reached when the tread has worn
down as far as one of the tread wear
indicators (TWI). Their position is
indicated by markings on the
sidewall.
If there is more wear at the front than
the rear, swap round front wheels and rear wheels periodically. Ensure that
the direction of rotation of the wheels
is the same as before.
Tyres age, even if they are not used.
We recommend tyre replacement
every 6 years.
Changing tyre and wheel
size
If tyres of a different size than those
fitted at the factory are used, it may be necessary to reprogramme the
speedometer as well as the nominal
tyre pressure and make other vehicle modifications.
After converting to a different tyre
size, have the label with tyre
pressures replaced.

Service and maintenance167Service and
maintenanceGeneral information ...................167
Service information ..................167
Recommended fluids, lubricants and parts .................................... 168
Recommended fluids and lubricants ................................ 168General information
Service information In order to ensure economical and
safe vehicle operation and to
maintain the value of your vehicle, it
is of vital importance that all
maintenance work is carried out at the proper intervals as specified.
The detailed, up-to-date service
schedule for your vehicle is available
at the workshop.
Service display 3 73.
Service intervals - petrol and CNG
engines
Maintenance of your vehicle is
required every 18,000 miles or
2 years, whichever occurs first.
Service intervals - diesel enginesMaintenance of your vehicle is
required every 21,000 miles or
2 years, whichever occurs first,
unless otherwise indicated in the
Driver Information Centre (DIC) 3 85.A shorter service interval can be valid
for severe driving behaviour, e.g. for
taxis and police vehicles.
Service display 3 73.
Confirmations Confirmation of service is recorded inthe Service and Warranty Booklet.
The date and mileage is completed
with the stamp and signature of the
servicing workshop.
Make sure that the Service and
Warranty Booklet is completed
correctly as continuous proof of
service is essential if any warranty or
goodwill claims are to be met, and is
also a benefit when selling the
vehicle.
Service interval with remaining
engine oil life duration
The service interval is based on
several parameters depending on
usage.

168Service and maintenanceWhen the engine oil requires
changing, control indicator I will
flash in the instrument cluster 3 82.
Depending on version, a message
may also appear in the DIC 3 82.
Service display 3 73.Recommended fluids,
lubricants and parts
Recommended fluids andlubricants
Only use products that meet the
recommended specifications.
Damage resulting from the use of
products not in line with these
specifications will not be covered by
the warranty.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
ageing control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for
petrol and diesel engines. If it is
unavailable, engine oils of other listed qualities must be used.
Recommendations for petrol engines
are also valid for Compressed Natural
Gas (CNG) fuelled engines.
Select the appropriate engine oil
based on its quality and viscosity
3 171.
Topping up engine oil
Engine oils of different manufacturers
and brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oil with only
ACEA A1/B1 or only A5/B5 quality is prohibited, since it can cause long-
term engine damage under certain
operating conditions.
Select the appropriate engine oil
based on its quality and viscosity
3 171.

Service and maintenance169Additional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.
Engine oil viscosity
The SAE viscosity grade gives
information on the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade 3 171.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only antifreeze approved for the
vehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C. In
northern countries with very low
temperatures the factory filled coolantprovides frost protection down to
approx. -37 °C. This concentration
should be maintained all year round.
The use of additional coolant
additives that intend to give additional
corrosion protection or seal against
minor leaks can cause function
problems. Liability for consequences resulting from the use of additional
coolant additives will be rejected.
Brake and clutch fluidOver time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should therefore be replaced at the specified interval.

Technical data171
Information on identification label:
1:type approval number2:vehicle Identification Number3:vehicle type identification
code4:permissible gross vehicle
weight rating in kg5:permissible gross train weight
in kg6:maximum permissible front
axle load in kg7:maximum permissible rear
axle load in kg8:engine type9-11:vehicle-specific or country-
specific dataThe combined total of front and rear
axle loads must not exceed the
permissible gross vehicle weight. For
example, if the front axle is bearing its
maximum permissible load, the rear
axle can only bear a load that is equal
to the gross vehicle weight minus the front axle load.
The technical data is determined in
accordance with European
Community standards. We reserve
the right to make modifications.
Specifications in the vehicle
documents always have priority over
those given in this manual.
Engine identification
The technical data tables show the
engine identifier code. Engine data
3 173.
To identify the respective engine,
refer to the engine power in the EEC
Certificate of Conformity provided
with your vehicle or other national
registration documents.Vehicle data
Recommended fluids and lubricants
Required engine oil qualityEngine oil quality: Europedexos 2✔
For countries with International
service interval 3 167, you may use
the oil qualities listed below:
Engine oil quality: Internationaldexos 2✔ACEA C3✔ACEA A3/B4✔

Customer information181● vehicle reactions in particulardriving situations (e.g. inflation ofan airbag, activation of the
stability regulation system)
● environmental conditions (e.g. temperature)
This data is exclusively technical and
helps identifying and correcting errors
as well as optimizing vehicle
functions.
Motion profiles indicating travelled
routes cannot be created with this
data.
If services are used (e.g. repair
works, service processes, warranty cases, quality assurance),
employees of the service network
(manufacturer included) are able to
read out this technical information
from the event and error data storage
modules applying special diagnostic
devices. If required, you will receive
further information at these
workshops. After an error has been
corrected, the data is deleted from the error storage module or it is
constantly overwritten.When using the vehicle, situations
may occur in which technical data
related to other information (accident
report, damages on the vehicle,
witness statements etc.) may be
associated with a specific person -
possibly, with the assistance of an
expert.
Additional functions contractually
agreed upon with the client (e.g.
vehicle location in emergency cases)
allow the transmission of particular vehicle data from the vehicle.
Radio Frequency
Identification (RFID)
RFID technology is used in some
vehicles for functions such as tyre
pressure monitoring and ignition
system security. It is also used in
connection with conveniences such
as radio remote controls for door
locking/unlocking and starting, and in-
vehicle transmitters for garage door
openers. RFID technology in
Vauxhall vehicles does not use or
record personal information or link
with any other Vauxhall system
containing personal information.

183Cigarette lighter ........................... 69
Climate control ............................. 14
Climate control systems .............101
Clock....................................... 67, 85
CNG............................................ 178
Control indicators.......................... 73
Control of the vehicle .................107
Controls ........................................ 65
Convex shape .............................. 27
Coolant and antifreeze ...............168
Cruise control ...................... 84, 122
Cupholders .................................. 57
D Danger, Warnings and Cautions ...4
Date .............................................. 85
Daytime running lights ............85, 95
Declaration of conformity ............180
DIC ............................................... 85
Diesel particle filter ...............81, 113
Distance to next service ...............85
Door locks..................................... 21
Door open .................................... 84
Doors ................................ 23, 24, 25
Drain fuel filter ............................. 83
Driver assistance systems ..........122
Driver Information Centre .............85
Driving characteristics and towing tips .............................. 130
Driving hints ................................ 107E
Eco mode (E).............................. 118
Electric adjustment ......................28
Electrical system......................... 146
Electronic climate control system 103
Electronic driving programmes ..118
Electronic Stability Control ..80, 121
Electronic Stability Control (ESC). 80
End-of-life vehicle recovery .......133
Engine compartment fuse box ...147
Engine coolant ........................... 136
Engine coolant temperature ........81
Engine coolant temperature gauge ....................................... 72
Engine data ............................... 173
Engine exhaust .......................... 113
Engine identification ...................171
Engine oil ...........135, 168, 171, 178
Engine oil pressure ......................82
ESC (Electronic Stability Control) 121
Event data recorders ..................180
Exit lighting .................................. 99
Extendable load compartment cover ................................... 58, 62
Exterior care .............................. 164
Exterior light ................................. 84
Exterior lighting ......................11, 94
Exterior mirrors ............................. 27F
Fault ........................................... 118
Fixed air vents ........................... 105
Fog light ....................................... 84
Fog lights ................................... 142
Folding front passenger seat ........35
Folding mirrors ............................. 28
Folding seats .......................... 37, 39
Front airbag system .....................48
Front fog lights ............................. 96
Front passenger seat Folding ...................................... 35
Table position ............................ 35
Front seats.................................... 33
Front turn signal light ..................140
Fuel............................................. 125
Fuel consumption .........................85
Fuel consumption - CO 2-
Emissions ............................... 129
Fuel cut-off system .........76, 91, 109
Fuel for diesel engines ..............126
Fuel for natural gas operation ...126
Fuel for petrol engines ...............125
Fuel gauge ................................... 71
Fuel selector ................................ 72
Fuel system messages .........91, 109
Fuel tank ..................................... 178
Fuses ......................................... 146

185Operating windows from outside..29
Outside temperature ....................67
Overhead console .......................57
Overrun cut-off ........................... 110
P Parking ................................ 17, 112
Parking assist ............................ 124
Parking brake ............................ 119
Particulate filter ........................... 113
Payload......................................... 62
Pedals......................................... 107
Performance .............................. 175
Performing work ........................134
Pollen filter ................................. 106
Power outlets ............................... 68
Power steering fluid ....................136
Power windows ............................ 29
Preheating ................................... 81
Puncture ..................................... 157
R Radio Frequency Identification (RFID) ..................................... 181
Radio info ..................................... 85
Radio remote control ...................20
Rear doors ................................... 24
Rear fog light ............................... 84
Rear fog lights ............................. 96
Rear parcel shelf .......................... 58
Rear seats .................................... 37Rear storage................................. 58
Rear windows .............................. 31
Rear window wiper/washer .......... 66
Recommended fluids and lubricants ........................ 168, 171
Refuelling ................................... 127 Removing seats ............................ 39
Reversing lights ........................... 96
Ride control systems ..................121
Roof bars ...................................... 58
Roof load ...................................... 62
Roof rack ..................................... 62
Roof racks .................................... 62
S Safety belts ................................... 41
Seat adjustment ....................... 7, 34
Seat belt ........................................ 8
Seat belt reminder .......................77
Seat belt reminder warning chime 85
Seat belts ..................................... 41
Seat folding .................................. 35
Seat heating ................................. 37
Seat position ................................ 33
Second row seats ........................37
Selector lever ............................. 116
Service ............................... 106, 167
Service display ......................73, 85
Service information ....................167
Settings menu............................... 85Side airbag system ......................49
Sidelights ...................................... 94
Side turn signal lights ................143
Sliding door .................................. 23
Sliding side door ........................... 23
Spare wheel ............................... 158
Speed limit warning chime............ 85
Speedometer ............................... 70
Standard display ........................... 85
Starting and operating ................108
Starting off ................................... 16
Starting the engine ............109, 115
Steering ...................................... 107
Steering wheel adjustment ......9, 65
Steering wheel controls ...............65
Stop engine .................................. 76
Stop-start system.................. 84, 110
Storage ......................................... 56
Storage compartments .................56
Sun visors .................................... 31
Symbols ......................................... 4
T
Tachometer ................................. 71
Tailgate ......................................... 25
Tail lights ................................... 142
Temperature ................................. 85
Third row seats ............................ 39
Three-point seat belt .................... 42
Tools .......................................... 149