light VAUXHALL COMBO D 2017.5 Workshop Manual

170Vehicle care● The vehicles must not come intocontact with each other during
the jump starting process.
● Apply the parking brake, transmission in neutral.
Lead connection order:
1. Connect the red lead to the positive terminal of the booster
battery.
2. Connect the other end of the red lead to the positive terminal of the
discharged vehicle battery.
3. Connect the black lead to the negative terminal of the booster
battery.
4. Connect the other end of the black
lead to a vehicle grounding point,
such as the engine block or an
engine mounting bolt. Connect as far away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump.
2. After five minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
one minute.
3. Allow both engines to idle for approx. three minutes with the
leads connected.4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.

Vehicle care171Towing
Towing the vehicle
Release the cap by carefully lifting
with a screwdriver. To prevent
damage, it is recommended to place
a cloth between the screwdriver and
the frame.
The towing eye is stowed with the vehicle tools 3 158.
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach a tow rope – or better still a tow
rod – to the towing eye.
Caution
The towing eye must only be used for towing and not for recovering
the vehicle.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.
Transmission in neutral.
Notice
If neutral cannot be selected on
vehicles with manual transmission
automated (MTA), the vehicle must
only be towed with the drive wheels
raised off the ground.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation 3 106 and close the
windows.
Seek the assistance of a workshop. After towing, unscrew the towing eye
and replace the cap.
Towing another vehicle
Insert a screwdriver in the slot at the
side of the cap. Release the cap by
carefully levering the screwdriver. To
prevent damage it is recommended to place a cloth between the screwdriver
and the frame.

Vehicle care173Do not clean the engine compartment
with a steam-jet or high-pressure jet
cleaner.
Thoroughly rinse and leather-off the
vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on
the windows will impair vision.
Exterior lights
Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use
an ice scraper, and do not clean them
dry.
Polishing and waxing
Wax the vehicle regularly (at the
latest when water no longer beads).
Otherwise, the paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.Unpainted plastic body parts must not be treated with wax or polishing
agents.
Matt filmed body parts or decor tapes must not be polished, to avoid
gleaming. Do not use hot wax
programmes in automatic car washes if the vehicle is equipped with these
parts.
Matt painted decor parts, e.g. mirror
housing cover, must not be polished. Otherwise these parts would become
agleam or the colour would be
dissolved.
Windows and windscreen wiper
blades
Use a soft lint-free cloth or chamois
leather together with window cleaner
and insect remover.
When cleaning the rear window from
inside, always wipe in parallel to the
heating element to prevent damage.
For mechanical removal of ice, use a
sharp-edged ice scraper. Press the
scraper firmly against the glass so
that no dirt can get under it and
scratch the glass.Clean smearing wiper blades with a
soft cloth and window cleaner.
Remove dirt residues from smearing
wiper blades by using a soft cloth and
window cleaner. Also make sure to
remove any residues such as wax,
insect residues and similar from the
window.
Ice residues, pollution and continuous wiping on dry windows will damage or
even destroy the wiper blades.
Glass panel
Never clean with solvents or abrasive agents, fuels, aggressive media (e.g.
paint cleaner, acetone-containing
solutions etc.), acidic or highly
alkaline media or abrasive pads. Do
not apply wax or polishing agents to
the glass panel.
Wheels and tyres Do not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.

174Vehicle carePaintwork damageRectify minor paintwork damage with
a touch-up pen before rust forms.
Have more extensive damage or rust
areas repaired by a workshop.
Underbody Some areas of the vehicle underbody
have a PVC undercoating while other
critical areas have a durable
protective wax coating.
After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Natural gas system Do not direct the steam jet or high-
pressure jet towards natural gas
system components. It is particularly
important to protect the natural gastank and the pressure valves on the vehicle underbody and the bulkheadin the engine compartment.
These components must not be
treated using chemical cleaners or
preservatives.
Have components of the natural gas system cleaned by a workshop
authorised to carry out maintenance
of natural gas vehicles.
Towing equipment Do not clean the coupling ball bar with
a steam-jet or high-pressure jet
cleaner.
Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean the leather upholstery with
clear water and a soft cloth. In case of
heavy soiling, use leather care.The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary, use a weak soap solution.
Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light-
coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.
Clean seat belts with lukewarm water
or interior cleaner.Caution
Close Velcro fasteners as open
Velcro fasteners on clothing could damage seat upholstery.
The same applies to clothing with
sharp-edged objects, like zips or
belts or studded jeans.

194IndexAAccessories and vehicle modifications .......................... 139
Adjustable air vents ...................109
Airbag activation ........................... 89
Airbag and belt tensioners ...........81
Airbag deactivation ..........52, 82, 89
Airbag label............................. 47, 52
Airbag system .............................. 47
Air conditioning regular operation ................................ 110
Air conditioning system .............. 106
Air intake .................................... 110
Air vents...................................... 109
Alert .............................................. 94
Antilock brake system ................ 125
Antilock brake system (ABS) .......83
Anti-Slip Regulator (ASR) ...........127
Anti-theft locking system .............. 28
Appearance care ........................172
Armrest ......................................... 39
Ashtrays ....................................... 74
ASR (Anti-Slip Regulator) ...........127
Audible warning chimes................ 94
Autoclose ...................................... 89
Automatic fuel cut-off ............95, 114
Automatic locking .........................89
Autostop ..................................... 115
AUX socket ................................... 73B
Battery ........................................ 145
Battery discharge protection ......104
Belts.............................................. 44
Bonnet ....................................... 141
Brake and clutch fluid .................177
Brake assist ............................... 126
Brake fluid .................................. 145
Brake pad wear ............................ 83
Brakes ............................... 125, 144
Brake system ............................... 83
Breakdown.................................. 171
Bulb replacement ....................... 148
C Capacities .................................. 189
Car Pass ...................................... 20
Catalytic converter .....................119
Central locking system ................23
Centre high-mounted brake light 151
Change engine oil .......................87
Changing tyre and wheel size ...162
Charging system .......................... 82
Child locks ................................... 24
Child restraint installation locations ................................... 56
Child restraints.............................. 54
Child restraint systems ................54
Child safety system for rear windows .................................... 31

195Chimes......................................... 94
Cigarette lighter ........................... 74
Climate control ............................. 15
Climate control systems .............105
Clock....................................... 71, 89
CNG............................................ 189
Collision damage repair ..............191
Control indicators.......................... 78
Control of the vehicle .................112
Controls ........................................ 69
Convex shape .............................. 29
Coolant and antifreeze ...............177
Cruise control ...................... 89, 129
Cupholders .................................. 60
D
Danger, Warnings and Cautions ...4
Date .............................................. 89
Daytime running lights ............89, 99
Declaration of conformity ............191
Diesel particle filter ...............85, 119
Distance to next service ...............89
Door open .................................... 89
Doors ...................................... 25, 27
Drain fuel filter ............................. 88
Driver assistance systems ..........129
Driver Information Centre .............89
Driving characteristics and towing tips .............................. 137
Driving hints ................................ 112E
Eco mode (E).............................. 123
Electric adjustment ......................29
Electrical system......................... 154
Electronic climate control system 107
Electronic driving programmes ..123
Electronic Stability Control ..84, 128
Electronic Stability Control (ESC). 84
End-of-life vehicle recovery .......140
Engine compartment fuse box ...155
Engine coolant ........................... 143
Engine coolant temperature ........85
Engine coolant temperature gauge ....................................... 77
Engine data ............................... 182
Engine exhaust .......................... 119
Engine identification ...................180
Engine oil ...........142, 177, 181, 189
Engine oil pressure ......................86
ESC (Electronic Stability Control) 128
Event data recorders ..................192
Exit lighting ................................ 104
Extendable load compartment cover ................................... 62, 66
Exterior care .............................. 172
Exterior light ................................. 88
Exterior lighting ......................12, 98
Exterior mirrors ............................. 29F
Fault ........................................... 124
Fixed air vents ........................... 110
Fog light ....................................... 89
Fog lights ................................... 150
Folding front passenger seat ........37
Folding mirrors ............................. 30
Folding seats .......................... 40, 41
Front airbag system .....................51
Front fog lights ........................... 100
Front passenger seat Folding ...................................... 37
Table position ............................ 37
Front seats.................................... 35
Front storage ................................ 60
Front turn signal light ..................148
Fuel............................................. 133
Fuel consumption .........................89
Fuel consumption - CO 2-
Emissions ............................... 136
Fuel cut-off system .........80, 95, 114
Fuel for diesel engines ..............133
Fuel for natural gas operation ...133
Fuel for petrol engines ...............133
Fuel gauge ................................... 76
Fuel selector ................................ 76
Fuel system messages .........95, 114
Fuel tank ..................................... 189
Fuses ......................................... 154

196GGauges ......................................... 75
Gear shifting ................................. 84
General information ...................137
Generic warning .............80, 95, 114
Glovebox ..................................... 60
Gross Vehicle Weight ...................66
H
Halogen headlights ....................148
Hand brake ................................. 126
Hazard warning flashers ..............99
Headlamp washer......................... 71
Headlight flash ............................. 98
Headlight range adjustment ........99
Headlights..................................... 98
Headlights when driving abroad ..99
Head restraint adjustment .............8
Head restraints ............................ 34
Heated mirrors ............................. 30
Heated rear window ..................... 33
Heating ........................................ 39
Heating and ventilation system . 105
High beam ............................. 88, 98
Hill start assist ...................... 84, 126
Horn ....................................... 13, 69
I
Identification plate .....................180
Ignition switch positions .............113
Immobiliser ............................ 28, 88Indicators...................................... 75
Information displays...................... 89
Initial drive information.................... 6
Installing seats .............................. 41
Instrument cluster ........................75
Instrument panel fuse box .........156
Instrument panel illumination .....153
Instrument panel illumination control .................................... 101
Instrument panel overview ........... 10
Instrument panel storage ..............59
Interior care ............................... 174
Interior lighting ......................89, 101
Interior lights ...................... 102, 152
Interior mirrors .............................. 30
Introduction .................................... 3
ISOFIX .......................................... 54
J
Jump starting ............................. 169
K Kerb weight................................... 66
Key number .................................. 19
Keys ............................................. 19
Keys, locks ................................... 19
L
Language ..................................... 89
Lashing eyes ......................... 64, 66
Laying up the vehicle ..................145Light switch .................................. 98
Load compartment ................27, 61
Load compartment cover .............62
Load compartment grille ...............65
Load compartment lighting .........103
Loading ............................. 37, 40, 41
Loading information .............66, 187
Loadspace dimensions ...............187
Lock cylinders ............................... 19
Low engine oil level .....................87
Low fuel ....................................... 87
Luggage floor net .........................64
Lumbar support ............................ 36
M Malfunction indicator light ............82
Manual adjustment ......................29
Manual anti-dazzle ......................30
Manual door locks ........................21
Manual mode ............................. 123
Manual transmission .................. 120
Manual transmission automated 121
Manual windows ..........................31
Mirror adjustment ........................... 8
Misted light covers .....................101
Multifunction display .....................89
N
Natural gas ................................. 189
New vehicle running-in ..............113
Number plate light .....................151

197OObject detection systems ...........130
Odometer ..................................... 75
Oil, engine .......................... 177, 181
Operating windows from outside ..31
Outside temperature ....................71
Overhead console .......................60
Overrun cut-off ........................... 115
P Parking ................................ 18, 118
Parking assist ............................ 130
Parking brake ............................ 126
Particulate filter ........................... 119
Payload......................................... 66
Pedals......................................... 112
Performance .............................. 185
Performing work ........................141
Pollen filter ................................. 110
Power outlets ............................... 73
Power steering fluid ....................144
Power windows ............................ 31
Preheating ................................... 85
Puncture ..................................... 165
R Radio Frequency Identification (RFID) ..................................... 193
Radio info ..................................... 89
Radio remote control ...................20
Rear doors ................................... 25Rear fog light ............................... 89
Rear fog lights ........................... 100
Rear parcel shelf .......................... 62
Rear seats .................................... 40
Rear storage ................................. 61
Rear windows .............................. 33
Rear window wiper/washer .......... 70
Recommended fluids and lubricants ........................ 177, 181
Refuelling ................................... 134 Registered trademarks ...............191
Remote control ............................. 20
Removing seats ............................ 41
Reversing lights .........................100
Ride control systems ..........127, 128
Roof bars ...................................... 61
Roof load ...................................... 66
Roof rack ............................. 66, 187
Roof racks .................................... 66
S Safety belts ................................... 44
Seat adjustment ....................... 7, 36
Seat belt ........................................ 8
Seat belt reminder .......................81
Seat belt reminder warning chime 89
Seat belts ..................................... 44
Seat folding .................................. 37
Seat heating ................................. 39
Seat position ................................ 35Second row seats ........................40
Selector lever ............................. 121
Service ............................... 110, 176
Service display ......................77, 89
Service information ....................176
Settings menu............................... 89
Side airbag system ......................52
Sidelights ...................................... 98
Side turn signal lights ................151
Sliding door .................................. 25
Sliding side door ........................... 25
Spare wheel ............................... 167
Speed limit warning chime............ 89
Speedometer ............................... 75
Standard display ........................... 89
Starting and operating ................113
Starting off ................................... 16
Starting the engine ............114, 121
Steering ...................................... 113
Steering wheel adjustment ......9, 69
Steering wheel controls ...............69
Stop engine .................................. 80
Stop-start system.................. 88, 115
Storage ......................................... 59
Storage compartments .................59
Sun visors .................................... 33
Symbols ......................................... 4

198T
Tachometer ................................. 75
Tailgate ......................................... 27
Tail lights ................................... 150
Technical data ............................ 182
Temperature ................................. 89
Third row seats ............................ 41
Three-point seat belt .................... 45
Toll road stickers .......................... 31
Tools .......................................... 158
Top-Tether .................................... 54
Towing ................................ 137, 171
Towing another vehicle .............171
Towing the vehicle .....................171
Traction Control system ............. 127
Trailer coupling ........................... 137
Trailer towing ............................. 137
Transmission ......................... 16, 83
Transmission display ...........78, 121
Tread depth ............................... 161
Trip computer ......................... 89, 95
Trip odometer .............................. 75
Turn and lane-change signals ...100
Turn signal ................................... 81
Tyre chains ................................ 162
Tyre designations ......................159
Tyre pressure ............................ 159
Tyre pressure monitoring system ............................... 86, 160Tyre pressures ........................... 190
Tyre repair kit ............................. 163
U
Ultrasonic parking assist ...... 84, 130
Underseat storage .......................61
Unit of measurement ....................89
Upholstery .................................. 174
USB port ....................................... 73
Using this manual ..........................3
V Vehicle battery ........................... 145
Vehicle checks............................ 141
Vehicle data ................................ 181
Vehicle data recording and privacy ..................................... 192
Vehicle dimensions .................... 187
Vehicle Identification Number ....179
Vehicle jack ................................ 158
Vehicle security ............................ 28
Vehicle shutdown ...........80, 95, 114
Vehicle specific data ......................3
Vehicle storage ........................... 140
Vehicle tools ............................... 158
Vehicle unlocking ........................... 6
Vehicle weight ........................... 186
Ventilation ................................... 105
Volume ......................................... 89W
Warning chime.............................. 89
Warning chimes ........................... 94
Warning lights ............................... 75
Washer and wiper systems .........14
Washer fluid ............................... 144
Wheel changing .........................165
Wheel covers ............................. 162
Wheels and tyres .......................158
Windows ....................................... 31
Windscreen................................... 31 Windscreen stickers .....................31
Windscreen wiper/washer ...........70
Winter tyres ............................... 158
Wiper blade replacement ..........147