lights VAUXHALL INSIGNIA 2017.5 Service Manual

242Vehicle care
Reverse light
6. Insert the bulb carrier into the tail lamp assembly. Attach plug to thelamp assembly. Fit lamp
assembly on the tailgate and
tighten the screw from the inside.
Attach cover.
Side turn signal lights
To replace bulb, remove lamp
housing:
1. Slide lamp to its left side and remove with its right end.
2. Turn bulb holder anticlockwiseand remove from housing.
3. Pull bulb from bulb holder and replace it.

Vehicle care2434. Insert bulb holder and turnclockwise.
5. Insert left end of the lamp, slide to
the left and insert right end.
Number plate light
The number plate light is designed as LEDs and can not be changed. Incase of defective LEDs, have them
replaced by a workshop.
Interior lights
Courtesy light, reading lights Have bulbs replaced by a workshop.
Load compartment light
Have bulbs replaced by a workshop.
Instrument panelillumination
Have bulbs replaced by a workshop.Electrical system
Fuses Data on the replacement fuse mustmatch the data on the defective fuse.
There are three fuse boxes in the
vehicle:
● engine compartment
● instrument panel
● load compartment
Before replacing a fuse, turn off the
respective switch and the ignition.
A blown fuse can be recognized by its melted wire.Caution
Do not replace the fuse until the
cause of the fault has been
remedied.
Some functions are protected by
several fuses.
Fuses may also be inserted without
existence of a function.
Fuse extractor
A fuse extractor may be located in the
fuse box in the engine compartment.

264Vehicle care● A discharged vehicle battery canalready freeze at a temperature
of 0 °C. Defrost the frozen battery before connecting jump leads.
● Wear eye protection and protective clothing when
handling a battery.
● Use a booster battery with the same voltage (12 Volts). Its
capacity (Ah) must not be much less than that of the discharged
vehicle battery.
● Use jump leads with insulated terminals and a cross section of
at least 16 mm 2
(25 mm 2
for
diesel engines).
● Do not disconnect the discharged
vehicle battery from the vehicle.
● Switch off all unnecessary electrical consumers.
● Do not lean over the vehicle battery during jump starting.
● Do not allow the terminals of one
lead to touch those of the other
lead.● The vehicles must not come into contact with each other during
the jump starting process.
● Apply the parking brake, transmission in neutral,
automatic transmission in P.
Open the positive terminal protection
caps of both vehicle batteries.
Lead connection order: 1. Connect the red lead to the positive terminal of the booster
battery.
2. Connect the other end of the red lead to the positive terminal of the
discharged battery.
3. Connect the black lead to the negative terminal of the boosterbattery.
4. Connect the other end of the black
lead to a vehicle grounding point
of your vehicle in the engine
compartment.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump.
2. After five minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of one
minute.
3. Allow both engines to idle for approx. three minutes with the
leads connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.

Vehicle care265Towing
Towing the vehicle
Disengage cap at slot and remove
downwards.
The towing eye is stowed with the
vehicle tools 3 248.
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach a tow rope – or better still a tow
rod – to the towing eye.
The towing eye must only be used for towing and not for recovering the
vehicle.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.
Transmission in neutral.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation and close the
windows.
Vehicles with manual transmission
and All-wheel drive: If the vehicle is
towed with all four wheels on the
ground then there are no technical
limitations for speed and distance. If
only one axle has been raised, the
maximum speed is 30 mph. There is
no distance limitation.
Vehicles with automatic transmission
and All-wheel drive: The vehicle must
be towed facing forwards. If the
vehicle is towed with all four wheels
on the ground, the maximum speed is 30 mph and for a maximum of
30 miles. If the front axle has been

Vehicle care267Appearance care
Exterior care LocksThe locks are lubricated at the factoryusing a high quality lock cylinder
grease. Use a de-icing agent only
when absolutely necessary, as this
has a degreasing effect and impairs
lock function. After using a de-icing
agent, have the locks regreased by a
workshop.
Washing
The paintwork of your vehicle is
exposed to environmental influences. Wash and wax your vehicle regularly.
When using automatic vehicle
washes, select a programme that
includes waxing.
Bird droppings, dead insects, resin,
pollen and the like should be cleaned
off immediately, as they contain
aggressive constituents which can
cause paint damage.If using a vehicle wash, comply with
the vehicle wash manufacturer's instructions. The windscreen wiperand rear window wiper must be
switched off. Remove antenna and
external accessories such as roof
racks etc.
If you wash your vehicle by hand,
make sure that the insides of the
wheel housings are also thoroughly
rinsed out.
Wax painted parts of the vehicle
regularly.
Clean edges and folds on opened
doors and the bonnet as well as the
areas they cover.
Clean bright metal mouldings with a
cleaning solution approved for
aluminium to avoid damages.Caution
Always use a cleaning agent with
a pH value of four to nine.
Do not use cleaning agents on hot surfaces.
Do not clean the engine compartmentwith a steam-jet or high-pressure jet
cleaner.
Thoroughly rinse and leather-off the vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on
the windows will impair vision.
Have the door hinges of all doors
greased by a workshop.
Exterior lights
Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use an ice scraper, and do not clean them
dry.
Polishing and waxing
Wax the vehicle regularly (at the
latest when water no longer beads).
Otherwise, the paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.

295Child restraint systems ................58
Climate control ............................. 15
Clock............................................. 82
Collision damage repair ..............289
Control indicators.......................... 96
Control of the vehicle .................152
Controls ........................................ 78
Convex shape .............................. 32
Coolant and antifreeze ...............271
Cruise control ....................102, 177
Cupholders .................................. 67
Curtain airbag system .................. 56
Curve lighting.............................. 129
D Danger, Warnings and Cautions ...4
Daytime running lights ...............129
Declaration of conformity ............287
DEF ............................................ 161
Diesel exhaust fluid ....................161
Diesel fuel system bleeding .......235
Diesel particle filter ....................159
Door open .................................. 102
Doors ............................................ 27
Driver assistance systems ..........177
Driver Information Centre ...........103
Driving characteristics and towing tips .............................. 224
Driving hints ................................ 152E
Electric adjustment ......................32
Electrical system......................... 243
Electric parking brake ...........98, 170
Electric parking brake fault ...........98
Electronic climate control system 142
Electronic key system ...................20
Electronic Stability Control.......... 173
Electronic Stability Control and Traction Control system ............99
Electronic Stability Control off....... 99
End-of-life vehicle recovery .......229
Engine compartment fuse box ...244
Engine coolant ........................... 232
Engine coolant temperature ......100
Engine coolant temperature gauge ....................................... 95
Engine data ............................... 279
Engine exhaust .......................... 159
Engine identification ...................275
Engine oil ................... 231, 271, 276
Engine oil pressure ....................100
Entry lighting .............................. 136
Event data recorders ..................292
Exit lighting ................................ 136
Exterior care .............................. 267
Exterior light ............................... 101
Exterior lighting ....................12, 125
Exterior mirrors ............................. 32F
First aid ......................................... 74
First aid kit ................................... 74
Fixed air vents ........................... 149
Fog light ..................................... 101
Fog lights ................................... 238
Folding mirrors ............................. 32
Following distance ........................99
Following distance indication ......191
Forward collision alert................. 188
Front airbag system .....................55
Front fog lights ........................... 133
Front pedestrian protection ........195
Front seats.................................... 41
Front storage ................................ 68
Fuel............................................. 220
Fuel consumption - CO 2-
Emissions ............................... 223
Fuel for diesel engines ..............221
Fuel for petrol engines ...............220
Fuel gauge ................................... 94
Funnel......................................... 221
Fuses ......................................... 243
G
Gauges ......................................... 92
Gear shifting ................................. 99
General information ...................224
Glovebox ..................................... 67

296HHalogen headlights ....................236
Hand brake ................................. 169
Hazard warning flashers ............132
Headlight flash ........................... 128
Headlight range adjustment ......128
Headlights................................... 125
Headlights when driving abroad 128
Head restraint adjustment .............8
Head restraints ............................ 39
Head-up display.......................... 112 Heated mirrors ............................. 33
Heated rear window ..................... 36
Heated steering wheel .................79
Heated windscreen .......................37
Heating .................................. 47, 49
High beam ......................... 101, 126
High beam assist ................101, 126
Hill start assist ........................... 172
Horn ....................................... 13, 79
I
Identification plate .....................274
Immobiliser .......................... 31, 101
Indicators ...................................... 92
Inductive charging ........................85
Info display ................................. 110
Information displays.................... 103
Instrument cluster ........................87
Instrument panel fuse box .........247Instrument panel illumination .....243
Instrument panel illumination control .................................... 134
Instrument panel overview ........... 10
Interactive driving system ...........174
Interior care ............................... 269
Interior lighting ............................ 134
Interior lights ...................... 134, 243
Interior mirrors .............................. 33
Introduction .................................... 3
J
Jump starting ............................. 263
K Key, memorised settings ..............22
L
Lane change alert .......................206
Lane keep assist ..................99, 218
Lashing eyes ............................... 73
LED headlights ...........101, 129, 238
Lighting features .........................136
Light switch ................................ 125
Load compartment ................27, 69
Load compartment cover .............72
Loading information .....................75
Low fuel ..................................... 101M
Malfunction indicator light ............98
Manual anti-dazzle ......................33
Manual seat adjustment ...............42
Manual transmission .................. 168
Massage ....................................... 48
Memorised settings ......................22
Midlevel display .......................... 103
Mirror adjustment ........................... 8
Misted light covers .....................134
N New vehicle running-in ..............152
Number plate light .....................243
O Object detection systems ...........197
Odometer ..................................... 93 Oil, engine .......................... 271, 276
OnStar ........................................ 120
Outside temperature ....................82
Overrun cut-off ........................... 155
P Panoramic view system ..............208
Parking ................................ 18, 158
Parking assist ............................ 197
Parking brake ............................ 170
Parking lights ............................. 133
Particulate filter ........................... 159
Pedestrian detection ...................102

297Performance .............................. 281
Performing work ........................230
Power button .............................. 153
Power outlets ............................... 84
Power seat adjustment ................44
Power windows ............................ 34
Preheating ................................. 100
Puncture ..................................... 259
Q Quickheat ................................... 148
R
Radio Frequency Identification (RFID) ..................................... 293
Reading lights ............................ 135
Rear cross traffic alert ................213
Rear floor storage cover ..............73
Rear fog light .....................102, 133
Rear seats .................................... 49
Rear view camera ...................... 211
Rear window wiper/washer .......... 81
Recommended fluids and lubricants ........................ 271, 276
Refuelling ................................... 221
Registered trademarks ...............291
Retained power off .....................154
Reversing lights .........................134
Ride control systems ..................172
Roof .............................................. 37Roof load...................................... 75
Roof rack ..................................... 74
S Safety belts ................................... 50
Seat adjustment ............................. 6
Seat belt ........................................ 8
Seat belt reminder .......................96
Seat belts ..................................... 50
Seat heating Seat heating, front .....................47
Seat heating, rear .....................49
Seat position ................................ 41
Selective catalytic reduction .......161
Service ............................... 150, 270
Service display ............................ 95
Service information ....................270
Side airbag system ......................56
Side blind zone assistant ............205
Sidelights .................................... 125
Side turn signal lights ................242
Software acknowledgement .......289
Software update ......................... 291
Spare wheel ............................... 261
Speed limiter....................... 102, 179
Speedometer ............................... 92
Starting and operating ................152
Starting off ................................... 17
Starting the engine ....................154
Steering ...................................... 152Steering wheel adjustment ......9, 78
Steering wheel controls ...............78
Stop-start system........................ 156
Storage ......................................... 67
Storage compartments .................67
Sunglasses storage .....................68
Sunroof ........................................ 37
Sunvisor lights ........................... 136
Sun visors .................................... 37
Symbols ......................................... 4
T
Tachometer ................................. 94
Tail lights ................................... 239
Three-point seat belt .................... 51
Tools .......................................... 248
Tow bar....................................... 224
Towing ................................ 224, 265
Towing another vehicle .............266
Towing equipment .....................225
Towing the vehicle .....................265
Traction Control system ............. 172
Traction Control system off......... 100
Traffic sign assistant ...........102, 214
Trailer coupling ........................... 224
Trailer stability assist .................227
Trailer towing ............................. 224
Transmission ............................... 16
Tread depth ............................... 253
Trip odometer .............................. 93

298Turn and lane-change signals ...132
Turn signal ................................... 96
Tyre chains ................................ 254
Tyre designations ......................250
Tyre pressure ............................ 250
Tyre pressure monitoring system ............................. 100, 251
Tyre pressures ........................... 285
Tyre repair kit ............................. 255
U
Ultrasonic parking assist............. 197
Upholstery .................................. 269
Uplevel display ........................... 103
Using this manual ..........................3
V Valet mode ................................. 110
Vehicle battery ........................... 234
Vehicle checks............................ 230
Vehicle data ................................ 276
Vehicle data recording and privacy ..................................... 292
Vehicle detected ahead ..............102
Vehicle dimensions .................... 282
Vehicle Identification Number ....274
Vehicle jack ................................ 248
Vehicle messages .....................114
Vehicle personalisation .............116
Vehicle security ............................ 28
Vehicle specific data ......................3Vehicle storage ........................... 229
Vehicle tools ............................... 248
Vehicle unlocking ........................... 6 Vehicle weight ........................... 282
Ventilating ..................................... 48
W
Warning chimes .........................115
Warning lights ............................... 92
Warning triangle .......................... 73
Washer and wiper systems .........13
Washer fluid ............................... 233
Wheel changing .........................259
Wheel covers ............................. 254
Wheels and tyres .......................249
Windows ....................................... 34
Windscreen................................... 34 Windscreen wiper/washer ...........79
Winter tyres ............................... 249
Wiper blade replacement ..........236