heating VAUXHALL INSIGNIA 2020 Owner's Guide

Driving and operating157Indication
An Autostop is indicated by the
needle at the AUTOSTOP position in
the tachometer.
After restarting, the idle speed is
indicated.
During an Autostop, the heating and
brake performance will be
maintained.
Conditions for an Autostop
The stop-start system checks if each
of the following conditions is fulfilled:
● The stop-start system is not manually deactivated.
● The bonnet is fully closed.
● The driver's door is closed or the driver's seat belt is fastened.
● The vehicle battery is sufficiently charged and in good condition.
● The engine is warmed up.
● The engine coolant temperature is not too high.
● The engine exhaust temperature is not too high, e.g. after driving
with high engine load.
● The ambient temperature is above -5 °C.
● The climate control system allows an Autostop.
● The brake vacuum is sufficient.
● Between the last restart and a new Autostop must be about10 seconds.
● The self-cleaning function of the exhaust filter is not active.
● The vehicle was driven at least at
walking speed since the last
Autostop.
Otherwise an Autostop will be
inhibited.The stop-start system will be
deactivated on inclines of 12% or
more.
Certain settings of the climate control
system may inhibit an Autostop. See
Climate control chapter for more
details 3 139.
Immediately after motorway driving,
an Autostop may be inhibited.
New vehicle running-in 3 151.
Vehicle battery discharge protection
To ensure reliable engine restarts,
several battery discharge protection
features are implemented as part of
the stop-start system.
Power saving measures
During an Autostop, several electrical
features e.g. auxiliary electric heater
or heated rear window are disabled or switched to a power saving mode.
The fan speed of the climate control
system is reduced to save power.

Driving and operating167● Special programmesautomatically adapt the shifting
points when driving up inclines or down hills.
● In snowy or icy conditions or on other slippery surfaces, the
electronic transmission control
enables the driver to manually
select first, second or third gear
for starting off.
Kickdown Pressing down the accelerator pedal
beyond the kickdown detent will lead to maximum acceleration
independent of the selected driving
mode. The transmission shifts to a
lower gear depending on engine
speed and shifts to a higher gear at
high engine revolutions.
Overheat protection
In the event of transmission-
overheating due to high outside
temperatures or sporty driving style,
the torque and the maximum speed of
the engine can be temporarily
reduced.Fault
In the event of a fault a vehicle
message is displayed in the Driver
Information Centre.
Vehicle messages 3 121.
6-gear automatic transmission:
electronic transmission control
enables only fourth gear; 8-gear
automatic transmission: electronic
transmission control enables only
third gear. The transmission no
longer shifts automatically.
Have the cause of the fault remedied
by a workshop.
Interruption of power supply In the event of an interruption of
power supply, the selector lever
cannot be moved out of the P
position.
The ignition key cannot be removed
from the ignition switch.
If the vehicle battery is discharged,
start the vehicle using jump leads
3 268.
If the vehicle battery is not the cause
of the fault, release the selector lever.1. Apply parking brake.
2. Release the selector lever trim from the centre console. Poke
with a finger into the leather
socket beside the selector lever
and pull the trim up carefully, there
is a cable attached to it. Slide trim slightly forward as it is hinged on
its rear side. Tilt loose trim to the
left side to aviod tensioning the
cable.

Driving and operating221(85% ethanol) and other fuels
containing more than 15% ethanol
must be used only in FlexFuel
vehicles.Caution
Do not use fuel containing
methanol. It can corrode metal
parts in the fuel system and also
damage plastic and rubber parts.
This damage would not be
covered by the vehicle warranty.
Some fuels, mainly high octane
racing fuels, can contain an octane
enhancing additive called
methylcyclopentadienyl manganese
tricarbonyl (MMT). Do not use fuels or fuel additives with MMT as they can
reduce spark plug life and affect
emission control system
performance. The malfunction
indicator light Z may illuminate
3 105. If this occurs, seek the
assistance of a workshop.
Fuel for diesel engines
Only use diesel fuel that complies
with EN 590 and which has a sulphur
concentration of max. 10 ppm.
Fuels with a biodiesel (compliant with
EN 14214) content of max. 7% by
volume may be used (e.g. named
B7).
If travelling in countries outside the
European Union occasional use of Euro-Diesel fuel with a sulphur
concentration below 50 ppm is
possible.
Caution
Frequent usage of diesel fuel
containing more than 15 ppm
sulphur will cause severe engine
damage.
Caution
Use of fuel that does not comply to EN 590 or similar can lead to
engine powerloss, increased wear
or engine damage and may affect
your warranty.
Do not use marine diesel oils, heating
oils, Aquazole and similar diesel-
water emulsions. Diesel fuels must
not be diluted with fuels for petrol
engines.
Low temperature operation At temperatures below 0 °C, some
diesel products with biodiesel blends may clog, freeze or gel, which mayaffect the fuel supply system. Starting
and engine operation may not work
properly. Make sure to fill winter
grade diesel fuel at ambient
temperatures below 0 °C.
Arctic grade diesel fuel can be used
in extreme cold temperatures below
-20 °C. Using this fuel grade in warm
or hot climates is not recommended

Vehicle care235Replacing the vehicle batteryNotice
Any deviation from the instructions
given in this section may lead to
temporary deactivation or
disturbance of the stop-start system.
When the vehicle battery is being
replaced, please ensure that there
are no open ventilation holes in the
vicinity of the positive terminal. If a
ventilation hole is open in this area, it
must be closed off with a dummy cap, and the ventilation in the vicinity of the
negative terminal must be opened.
Ensure that the battery is always replaced by the same type of battery.
We recommend that you have the
vehicle battery replaced by a
workshop.
Stop-start system 3 156.Charging the vehicle battery9 Warning
On vehicles with stop-start
system, ensure that the charging potential does not exceed 14.6 V
when using a battery charger.
Otherwise the vehicle battery may be damaged.
Jump starting 3 268.
Discharge protection Battery voltage
When the vehicle battery voltage is
running low, a warning message will
appear in the Driver Information
Centre.
1. Switch off any electrical consumers which are not requiredfor a safe ride, e.g. seat heating,
heated rear window or other main consumers.
2. Charge the vehicle battery by driving continuously for a while or
by using a charging device.
The warning message will disappear
after the engine has been started
twice without a voltage drop.
If the vehicle battery cannot be
recharged, have the cause of the fault
remedied by a workshop.
Vehicle battery state of charge
function
The function guarantees longest vehicle battery life via a generator
with controllable power output and
optimised power distribution.
To prevent discharge of the vehicle
battery when driving, the following
systems are reduced automatically in two stages and finally switched off:
● auxiliary heater
● heated rear and front window
● heated steering wheel
● heated mirrors
● heated seats
● fan
In the second stage, a message
which confirms the activation of the
vehicle battery discharge protection
will be displayed in the Driver
Information Centre.

250Vehicle careNo.Circuit52–53–54–55–56Starter57–58–59Left headlight (LED)60Cooling fan61–62–63–64–65Climate control66–67–68–No.Circuit69Right high beam (Halogen) /
Right headlight (LED)70Left high beam (Halogen)71–72Starter73–74Transmission control module75Engine control module76Exhaust reduction system77–78Horn79Washer system80–81Engine control module82–83Ignition coil84Ignition coil85PowertrainNo.Circuit86–87Diesel fuel heating88Air shutter89–90–91–92After boil pump93Electronic key system94–95Coolant pump96Diesel fuel heating97–98–99Coolant pump
After having changed defective fuses,
close the fuse box cover and press
until it engages.
If the fuse box cover is not closed
correctly, malfunction may occur.

Vehicle care273Thoroughly rinse and leather-off the
vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on the windows will impair vision.
Have the door hinges of all doors
greased by a workshop.
Exterior lights
Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use an ice scraper, and do not clean them
dry.
Polishing and waxing
Wax the vehicle regularly (at the
latest when water no longer beads).
Otherwise, the paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.
Plastic body parts must not be treated with wax or polishing agents.Windows and windscreen wiper
blades
Switch off wipers before handling in
their areas.
Use a soft lint-free cloth or chamois leather together with window cleaner and insect remover.
When cleaning the rear window from
inside, always wipe in parallel to the
heating element to prevent damage.
For mechanical removal of ice, use a
sharp-edged ice scraper. Press the
scraper firmly against the glass so
that no dirt can get under it and
scratch the glass.
Clean smearing wiper blades with a
soft cloth and window cleaner.
Remove dirt residues from smearing
wiper blades by using a soft cloth and window cleaner. Also make sure to
remove any residues such as wax,
insect residues and similar from the
window.
Ice residues, pollution and continuous
wiping on dry windows will damage or
even destroy the wiper blades.Sunroof
Never clean with solvents or abrasive
agents, fuels, aggressive media
(e.g. paint cleaner, acetone-
containing solutions etc.), acidic or
highly alkaline media or abrasive
pads. Do not apply wax or polishing
agents to the sunroof.
Wheels and tyres
Do not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damageRectify minor paintwork damage witha touch-up pen before rust forms.
Have more extensive damage or rust
areas repaired by a workshop.
Underbody Some areas of the vehicle underbody
have a PVC undercoating while other
critical areas have a durable
protective wax coating.

308HHalogen headlights ....................237
Hand brake ................................. 169
Hazard warning flashers ............133
Headlight flash ........................... 131
Headlight range adjustment ......131
Headlights................................... 128
Headlights when driving abroad 131
Head restraint adjustment .............8
Head restraints ............................ 45
Head-up display.......................... 117 Heated mirrors ............................. 39
Heated rear window ..................... 42
Heated steering wheel .................88
Heated windscreen .......................43
Heating .................................. 54, 55
High beam ......................... 109, 129
High beam assist ................109, 129
Hill start assist ........................... 172
Horn ....................................... 13, 89
I
Identification plate .....................279
Ignition switch positions .............151
Immobiliser .......................... 37, 109
Indicators .................................... 100
Inductive charging ........................94
Info Display ................................. 116
Instrument cluster ........................96
Instrument panel fuse box .........251Instrument panel illumination
control .................................... 135
Instrument panel overview ........... 10
Interactive driving system ...........175
Interior care ............................... 274
Interior lighting ............................ 135
Interior lights ...................... 136, 247
Interior mirrors .............................. 39
Interruption of power supply ......167
Introduction .................................... 3
J
Jump starting ............................. 268
K
Key, memorised settings ..............25
Keys ............................................. 20
Keys, locks ................................... 20
L
Lane change alert .......................206
Lane keep assist ................107, 217
Lashing eyes ............................... 80
LED headlights ...........109, 132, 239
Lighting features .........................137
Light switch ................................ 128
Load compartment ................29, 75
Load compartment cover .............78
Loading information .....................85
Low fuel ..................................... 108M
Malfunction indicator light ..........105
Manual anti-dazzle ......................39
Manual mode ............................. 165
Manual seat adjustment ...............48
Manual transmission .................. 168
Massage ....................................... 55
Memorised settings ......................25
Mirror adjustment ........................... 8
Misted light covers .....................135
N New vehicle running-in ..............151
Number plate light .....................247
O
Object detection systems ...........198
Odometer ................................... 101 Oil, engine .......................... 277, 281
Outside temperature ....................92
Overrun cut-off ........................... 156
P Panoramic view system ..............208
Parking ................................ 18, 158
Parking assist ...................... 39, 198
Parking brake ............................ 170
Parking lights ............................. 135
Particulate filter ........................... 159
Pedestrian detection ...................110
Performance .............................. 286

309Performing work ........................230
Power button .............................. 152
Power outlets ............................... 93
Power seat adjustment ................50
Power windows ............................ 40
Preheating ................................. 108
Puncture ..................................... 264
Q Quickheat ................................... 148
R Radio Frequency Identification (RFID) ..................................... 305
Radio remote control ...................21
REACH ....................................... 299
Reading lights ............................ 136
Rear cross traffic alert ................212
Rear floor storage cover ..............80
Rear fog light .............109, 134, 241
Rear seats .................................... 55
Rear storage ................................. 78
Rear view camera ...................... 210
Rear window wiper and washer ..91
Recommended fluids and lubricants ........................ 277, 281
Refuelling ................................... 222 Registered trademarks ...............301
Retained power off .....................154
Reversing lights .........................135
Ride control systems ..................173Roof.............................................. 43
Roof load ...................................... 85
Roof rack ..................................... 85
S
Safety belts ................................... 56
Safety net .................................... 81
Seat adjustment ............................. 6 Seat belt ........................................ 8
Seat belt reminder .....................104
Seat belts ..................................... 56
Seat heating Seat heating, front .....................54
Seat heating, rear .....................55
Seat position ................................ 47
Selective catalytic reduction .......161
Selector lever.............................. 164
Service ............................... 149, 276
Service display .......................... 103
Service information ....................276
Side airbag system ......................62
Side blind spot alert ....................205
Sidelights .................................... 128
Side turn lights ........................... 246
Software acknowledgement .......299
Software update ......................... 301
Spare wheel ............................... 264
Speed limiter....................... 110, 179 Speedometer ............................. 100
Starting and operating ................151Starting off ................................... 17
Starting the engine ....................154
Steering ...................................... 151
Steering wheel adjustment ......9, 88
Steering wheel controls ...............88
Stop-start system........................ 156
Storage ......................................... 73
Storage compartments .................73
Sunglasses storage .....................74
Sunroof ........................................ 43
Sunvisor lights ........................... 137
Sun visors .................................... 43
Symbols ......................................... 4
T
Tachometer ............................... 102
Tail lights ................................... 241
Three-point seat belt .................... 57
Tools .......................................... 252
Tow bar....................................... 224 Towing ................................ 224, 270
Towing another vehicle .............271
Towing equipment .....................225
Towing hitch installation dimensions ............................. 293
Towing the vehicle .....................270
Traction Control system ............. 173
Traction Control system off......... 107
Traffic sign assistant ...........110, 213
Trailer coupling ........................... 224