light VAUXHALL MERIVA 2014.5 Repair Manual

Vehicle care195
Notice
The driving characteristics of the
repaired tyre is severely affected,
therefore have this tyre replaced.
If unusual noise is heard or the
compressor becomes hot, turn
compressor off for at least
30 minutes.
The built-in safety valve opens at a
pressure of 7 bar.
Note the expiry date of the kit. After
this date its sealing capability is no
longer guaranteed. Pay attention to
storage information on sealant
bottle.
Replace the used sealant bottle.
Dispose of the bottle as prescribed
by applicable laws.
The compressor and sealant can be used from approx. -30 °C.
The adapters supplied can be used
to pump up other items e.g.
footballs, air mattresses, inflatable
dinghies etc. They are located on the
underside of the compressor. To
remove, screw on compressor air
hose and withdraw adapter.Wheel changing
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel 3 192.
Make the following preparations and
observe the following information:
■ Park the vehicle on a level, firm and
non-skid surface. The front wheels
must be in the straight-ahead
position.
■ Apply the parking brake and engage first gear, reverse gear or
P .
■ Remove the spare wheel 3 198.
■ Never change more than one wheel
at once.
■ Use the jack only to change wheels
in case of puncture, not for
seasonal winter or summer tyre
change.
■ If the ground on which the vehicle is standing is soft, a solid board
(max. 1 cm thick) should be placed
under the jack.
■ No people or animals may be in the
vehicle when it is jacked-up.■ Never crawl under a jacked-up vehicle.
■ Do not start the vehicle when it is raised on the jack.
■ Before screwing in the wheel bolts,
clean them and lightly coat the
taper of each wheel bolt with
commercially available grease.
1. Pull off the wheel cover with the hook. Vehicle tools 3 188.
For wheel covers with visible
wheel bolts: The cover can remain
on the wheel. Do not remove the
retaining rings on the wheel bolts.

202Vehicle care
4. Switch on electrical consumers(e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle
Disengage cap at bottom and removedownwards.
The towing eye is stowed with the
vehicle tools 3 188.
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach a tow rope – or better still a tow
rod – to the towing eye.
The towing eye must only be used for towing and not for recovering the
vehicle.
Caution
Activate the child lock in both rear
doors if the rear seats are
occupied. Child locks 3 24.

Vehicle care203
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.
Transmission in neutral.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation and close the
windows.
Vehicles with automatic transmission: The vehicle must be towed facing
forwards, not faster than 50 mph nor further than 60 miles. In all other
cases and when the transmission is
defective, the front axle must be
raised off the ground.
Seek the assistance of a workshop. After towing, unscrew the towing eye.
Insert cap at the bottom and close
cap.
Towing another vehicle
Disengage the cap at the bottom and
remove downwards.
The towing eye is stowed with the
vehicle tools 3 188.
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
The lashing eye at the rear
underneath the vehicle must never be used as a towing eye.
Attach a tow rope – or even better a
tow bar – to the towing eye.
The towing eye must only be used for
towing and not for recovering a
vehicle.

Vehicle care205
Thoroughly rinse and leather-off the
vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on
the windows will impair vision.
Exterior lights Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use
an ice scraper, and do not clean them dry.
Polishing and waxing
Wax the vehicle regularly (at the
latest when water no longer beads).
Otherwise, the paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.
Plastic body parts must not be treated with wax or polishing agents.Windows and windscreen wiper
blades
Use a soft lint-free cloth or chamois
leather together with window cleaner and insect remover.
When cleaning the rear window from
inside, always wipe in parallel to the
heating element to prevent damage.
For mechanical removal of ice, use a
sharp-edged ice scraper. Press the
scraper firmly against the glass so
that no dirt can get under it and
scratch the glass.
Clean smearing wiper blades with a
soft cloth and window cleaner.
Moonroof
Never clean with solvents or abrasive
agents, fuels, aggressive media (e.g.
paint cleaner, acetone-containing
solutions etc.), acidic or highly
alkaline media or abrasive pads. Do
not apply wax or polishing agents to
the middle part of the moonroof.
Wheels and tyres
Do not use high-pressure jet
cleaners.Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damage Rectify minor paintwork damage witha touch-up pen before rust forms.
Have more extensive damage or rust
areas repaired by a workshop.
UnderbodySome areas of the vehicle underbody
have a PVC undercoating while other
critical areas have a durable
protective wax coating.
After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.

206Vehicle care
Liquid gas system9Danger
Liquid gas is heavier than air and
can collect in sink points.
Take care when performing work
at the underbody in a pit.
For painting work and when using a
drying booth at a temperature above
60 °C, the liquid gas tank must be
removed.
Do not make any modifications to the
liquid gas system.
Towing equipment Do not clean the coupling ball bar with
a steam-jet or high-pressure jet
cleaner.
Rear carrier system Clean the rear carrier system with a
steam-jet or high-pressure jet cleaner
at least once a year.
Operate the rear carrier system
periodically if not in regular use, in
particular during winter.
Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean the leather upholstery with
clear water and a soft cloth. In case of heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.
Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light- coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.
Clean seat belts with lukewarm water or interior cleaner.Caution
Close Velcro fasteners as open
Velcro fasteners on clothing could damage seat upholstery.
The same applies to clothing with
sharp-edged objects, like zips or
belts or studded jeans.
Plastic and rubber parts
Plastic and rubber parts can be
cleaned with the same cleaner as
used to clean the body. Use interior cleaner if necessary. Do not use any
other agent. Avoid solvents and petrol in particular. Do not use high-
pressure jet cleaners.

230IndexAAccessories and vehicle modifications .......................... 164
Active head restraints ..................35
Adaptive brake light ....................143
Adaptive forward lighting ..........
.................................. 98, 116, 174
Adjustable air vents ...................129
Airbag and belt tensioners ...........93
Airbag deactivation ................53, 94
Airbag label................................... 48 Airbag system .............................. 48
Air conditioning regular operation ................................ 130
Air conditioning system .............. 123
Air intake .................................... 130
Air vents...................................... 129
Alert ............................................ 106
Antifreeze ................................... 167
Antilock brake system ................ 143
Antilock brake system (ABS) .......95
Anti-theft alarm system ................27
Anti-theft locking system .............. 26 Appearance care ........................204
Armrest ................................... 39, 42
Armrest storage ........................... 63
Ashtrays ....................................... 88
Automatic anti-dazzle ..................30
Automatic light control ...............114Automatic locking ..................24, 98
Automatic transmission .............139
Auxiliary heater .......................... 129
B Battery discharge protection ......121
Battery voltage ........................... 106
Belts.............................................. 44 Bicycle rack .................................. 64
Bonnet ....................................... 166
Brake and clutch fluid .................208
Brake and clutch system .............95
Brake assist ............................... 145
Brake fluid .................................. 168
Brakes ............................... 143, 168
Breakdown.................................. 202
Bulb replacement ....................... 172
C Capacities .................................. 223
Car Pass ...................................... 19
Catalytic converter .....................138
Central locking system ................21
Centre console lighting ..............120
Changing tyre and wheel size ...191
Charging system .......................... 94
Child locks ................................... 24
Child restraint installation locations ................................... 57
Child restraints.............................. 54

231
Child restraint systems ................54
Cigarette lighter ........................... 88
Climate control ............................. 15
Climate control, service ..............130
Climate control systems .............122
Clock............................................. 85
Code ........................................... 103
Control indicators.......................... 91
Control of the vehicle .................132
Controls ........................................ 81
Controls in steering wheel ............81
Convex shape .............................. 28
Coolant ....................................... 167
Coolant and antifreeze ...............208
Coolant temperature gauge ..........90
Coupling ball bar ........................160
Cruise control ...................... 98, 147
Cupholders .................................. 61
Curtain airbag system .................. 52
Curve lighting.............................. 116
D Danger, Warnings and Cautions ...4
Dashboard .................................... 10
Daytime running light ..................114
Daytime running lights ...............116
Declaration of conformity ............227
Deflation detection system ..........97
Diesel fuel system bleeding .......171
Diesel particle filter ...............96, 137Door open .................................... 98
Doors ............................................ 25
Driver assistance systems ..........147
Driver Information Centre .............99
Driving characteristics and towing tips .............................. 159
Driving hints ................................ 132
E Electric adjustment ......................28
Electrical system......................... 182
Electric parking brake ...........95, 144
Electric parking brake fault ...........95
Electronic climate control system 124
Electronic driving programmes ..141
Electronic Stability Control.......... 146
Electronic Stability Control and Traction Control system ...........96
Electronic Stability Control off ...... 96
End-of-life vehicle recovery .......165
Engine compartment fuse box ...183
Engine coolant ........................... 167
Engine coolant temperature gauge ....................................... 90
Engine data ............................... 215
Engine exhaust .......................... 137
Engine identification ...................211
Engine oil ................... 166, 208, 212
Engine oil pressure ......................97
Entry lighting .............................. 120Event data recorders ..................227
Exhaust gases ............................ 137
Exit lighting ................................ 120
Exterior care .............................. 204
Exterior light ................................. 98
Exterior lighting ....................12, 113
Exterior mirrors ............................. 28
F
Fault ........................................... 141
First aid ......................................... 78
First aid kit ................................... 78
Fixed air vents ........................... 130
Flex-Fix system ............................ 64
Fog light ....................................... 98
Fog lights .................... 117, 118, 176
Folding mirrors ............................. 29
Folding tray .................................. 78
Front airbag system .....................51
Front fog lights ........................... 117
Front seats.................................... 36
Front storage ............................... 63
Front turn signal light ..................172
Front turn signal lights ...............176
Fuel............................................. 152
Fuel consumption - CO 2-
Emissions ............................... 158
Fuel for diesel engines ..............153
Fuel for liquid gas operation .......153
Fuel for petrol engines ...............152

232
Fuel gauge ................................... 89Fuel selector ................................ 90
Fuse box ..................................... 183
Fuses ......................................... 182
G Gauges ......................................... 88
General information ...................159
Glovebox ..................................... 61
Graphic-Info-Display, Colour- Info-Display ............................ 101
H Halogen headlights ....................172
Hand brake ......................... 143, 144
Hazard warning flashers ............117
Headlight flash ........................... 114
Headlight range adjustment ......115
Headlights .......................... 113, 114
Headlights when driving abroad 115
Head restraint adjustment .............8
Head restraints ............................ 34
Heated mirrors ............................. 29
Heated rear window ..................... 32
Heated steering wheel .................82
Heating ........................................ 40
Heating and ventilation system . 122
High beam ........................... 98, 114
Hill start assist ........................... 145
Horn ....................................... 13, 82I
Identification plate .....................211
Ignition switch positions .............133
Immobiliser ............................ 28, 98
Indicators ...................................... 88
Information displays...................... 99
Instrument cluster ........................88
Instrument panel fuse box .........185
Instrument panel illumination .....182
Instrument panel illumination control .................................... 119
Instrument panel overview ........... 10
Interior care ............................... 206
Interior lighting ............................ 119
Interior lights ...................... 119, 181
Interior mirrors .............................. 29
Interruption of power supply ......141
Introduction .................................... 3
ISOFIX child restraint systems ....60
J
Jump starting ............................. 200
K Keys ............................................. 19
Keys, locks ................................... 19
Keys, memorised settings ............21L
Lashing eyes ............................... 76
Light covers, misted.................... 118
Lighting features .........................120
Light switch ................................ 113
Load compartment ................25, 73
Load compartment cover .............74
Load compartment fuse box ......186
Loading information .....................79
Low fuel ....................................... 97
M Malfunction indicator light ............94
Manual anti-dazzle ......................29
Manual mode ............................. 140
Manual transmission .................. 142
Manual windows ..........................30
Memorised settings ......................21
Mirror adjustment ........................... 8
Misted light covers .....................118
Moonroof ..................................... 33
N New vehicle running-in ..............133
Number plate light .....................180
O
Object detection systems ...........148
Octane rating .............................. 215
Odometer ..................................... 89

233
Oil............................................... 166
Oil, engine .......................... 208, 212
Oil pressure .................................. 97
Outside temperature ....................85
Overrun cut-off ........................... 134
P Parking ................................ 17, 137
Parking assist ............................ 148
Parking brake ............................ 144
Parking lights ............................. 118
Particulate filter ........................... 137
Performance .............................. 218
Performing work ........................165
Personalisation ........................... 109
Pollen filter ................................. 130
Power outlets ............................... 87
Power windows ............................ 30
Preheating ................................... 96
Puncture ..................................... 195
Q
Quickheat ................................... 129
R Radio Frequency Identification (RFID) ..................................... 228
Radio remote control ...................20
Reading lights ............................ 120
Rear carrier system ......................64Rear doors ................................... 25
Rear floor storage cover ..............75
Rear fog light ............................... 98
Rear fog lights ........................... 118
Rear seats .................................... 41
Rear storage ................................ 74
Rear view camera ...................... 150
Rear window wiper/washer .......... 84
Recommended fluids and lubricants ........................ 208, 212
Reduced engine power ...............98
Refuelling ................................... 155 Remote control ............................. 20
Retained power off ....................133
Reversing lights .........................118
Ride control systems ..................145
Roof .............................................. 33
Roof load ...................................... 79
Roof rack ..................................... 79
S
Safety belts ................................... 44
Safety net .................................... 76
Seat adjustment ....................... 6, 36
Seat belt ........................................ 8
Seat belt reminder .......................93
Seat belts ..................................... 44
Seat heating ................................. 40
Seat position ................................ 36
Selector lever ............................. 139Service ............................... 130, 207
Service display ............................ 90
Service information ....................207
Service vehicle soon .................... 94
Side airbag system ......................52
Sidelights .................................... 113
Side turn signal lights ................180
Spare wheel ............................... 198
Speedometer ............................... 88
Starting and operating ................133
Starting off ................................... 16
Starting the engine ....................133
Steering ...................................... 132
Steering wheel adjustment ......9, 81
Steering wheel controls ...............81
Steering wheel, heated .................82
Stop-start system........................ 135
Storage ......................................... 61
Storage compartments .................61
Sunvisor lights ........................... 120
Sun visors .................................... 32
Symbols ......................................... 4
T
Tachometer ................................. 89
Tailgate ......................................... 25
Tail lights ................................... 177
Technical data ............................ 215
Three-point seat belt .................... 45
Tools .......................................... 188

234
Top-tether fastening eyes ............60
Tow bar....................................... 159
Towing ................................ 159, 202
Towing another vehicle .............203
Towing a trailer ........................... 159
Towing equipment .....................160
Towing the vehicle .....................202
Traction Control system ............. 145
Traction Control system off .......... 96
Trailer coupling ........................... 159
Trailer towing ............................. 159
Transmission ............................... 16
Transmission display .................139
Tread depth ............................... 191
Trip computer ............................ 107
Trip odometer .............................. 89
Tunnel detection .........................114
Turn and lane-change signals ...117
Turn signal ................................... 93
Tyre chains ................................ 192
Tyre deflation detection system . 190
Tyre designations ......................189
Tyre pressure ............................ 189
Tyre pressures ........................... 224
Tyre repair kit ............................. 192
Tyres and wheel size, changing. 191
U Ultrasonic parking assist ...... 96, 148
Underseat storage .......................63Upholstery.................................. 206
Upshift .......................................... 96
Using this manual ..........................3
V Variable effort steering .................96
Vehicle battery ........................... 169
Vehicle battery, jump starting .....200
Vehicle checks............................ 165
Vehicle data ................................ 212
Vehicle data recording and privacy ..................................... 227
Vehicle dimensions .................... 221
Vehicle Identification Number ....210
Vehicle jack ................................ 188
Vehicle messages .....................103
Vehicle personalisation .............109
Vehicle security ............................ 26
Vehicle specific data ......................3
Vehicle storage ........................... 164
Vehicle tools ............................... 188
Vehicle unlocking ........................... 6
Vehicle weight ........................... 220
Ventilation ................................... 122
W
Warning chimes .........................106
Warning lights ............................... 88
Warning triangle .......................... 78
Washer and wiper systems .........14Washer fluid ............................... 168
Welcome lighting ........................120
Wheel changing .........................195
Wheel covers ............................. 191
Wheels and tyres .......................189
Windows ....................................... 30
Windscreen................................... 30
Windscreen wiper/washer ...........83
Winter tyres ............................... 189
Wiper blade replacement ..........171