warning VAUXHALL MOVANO_B 2015.5 Manual PDF

168Vehicle care
■ If the ground on which the vehicleis standing is soft, a solid board
(max. 1 cm thick) should be placed
under the jack.
■ No people or animals may be in the
vehicle when it is jacked-up.
■ Never crawl under a jacked-up vehicle.
■ Do not start the engine when the vehicle is raised on the jack.
■ Clean wheel bolts/nuts and their threads before mounting the wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Remove the wheel cover using the hook supplied. Vehicle tools
3 158.
2. Install the wheel wrench ensuring that it locates securely and loosen
each wheel bolt/nut by half a turn.
3. Vehicles with Front-wheel drive:
Raise vehicle by placing lifting
pad spigot of the jack under the
jacking hole located nearest the
wheel concerned.
Ensure the jack is positioned correctly. The jack base must be
on the ground directly below the
jacking hole in a manner that
prevents it from slipping.
Attach wheel wrench onto the jack
and raise the vehicle by turning
the wrench until the wheel is clear of the ground.
Vehicles with Rear-wheel drive:
Pay attention to the operating
instructions supplied with the
hydraulic jack and assemble the
parts required as specified.

Vehicle care171
Place wheel below the vehicle frame,
then tighten cable using the wheel
wrench and adapters until the wheel is secured in the fully raised position.9 Warning
Ensure the front of the wheel (side
with tyre valve) is facing
downwards when the spare wheel is reinstalled below the vehicle
frame.
Temporary spare wheel
Caution
The use of a spare wheel that is smaller than the other wheels or in
combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
Only mount one temporary spare
wheel. Do not drive faster than
50 mph. Take curves slowly. Do not
use for a long period of time.
If your vehicle gets a flat tyre on the
rear while towing another vehicle,
mount the temporary spare wheel in
the front and the full tyre in the rear.
Tyre chains 3 163.
Summer and winter tyres If you use winter tyres, the spare
wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's
driveability may be affected,
especially on slippery road surfaces.
Directional tyres
Fit directional tyres such that they roll in the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
■ Driveability may be affected. Have the defective tyre renewed or
repaired as soon as possible.
■ Do not drive faster than 50 mph.
■ Drive particularly carefully on wet and snow-covered road surfaces.Jump starting
Do not start with a quick charger.
A vehicle with a discharged battery can be started using jump leads and
the battery of another vehicle.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact with eyes, skin,
fabrics, and painted surfaces. The fluid contains sulphuric acid which can cause injuries and damage in
the event of direct contact.

172Vehicle careCaution
The air suspension system must
be switched off prior to jump
starting.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
■ Never expose the vehicle battery to
naked flames or sparks.
■ A discharged vehicle battery can already freeze at a temperature of
0 °C. Defrost the frozen vehicle
battery before connecting jump
leads.
■ Wear eye protection and protective
clothing when handling a vehicle
battery.
■ Use a booster battery with the same voltage (12 volts). Its capacity(Ah) must not be much less than
that of the discharged vehicle
battery.
■ Use jump leads with insulated terminals and a cross section of at
least 25 mm 2
.
■ Do not disconnect the discharged battery from the vehicle.
■ Switch off all unnecessary electrical
consumers.
■ Switch off the air suspension system 3 114.
■ Do not lean over the vehicle battery
during jump starting.
■ Do not allow the terminals of one lead to touch those of the other
lead.
■ The vehicles must not come into contact with each other during the
jump starting process.
■ Apply the parking brake and engage neutral (manual
transmission) or N (manual
transmission automated).Jump start terminal
In the event of a discharged vehicle
battery, the jump start terminal
enables the vehicle to be started
without the need to access the battery inside the vehicle.
The jump start terminal is located in
the engine compartment and
identified by a " <" sign on the red
insulating cover. Lift the red insulating
cover to access the terminal
connector.
Ensure the red insulating cover is
latched back into position when not in
use.

Service and maintenance179
The service display, located in the
Driver Information Centre, indicates
when the next service is due. Seek
the assistance of a workshop.
Service display 3 76.
Engine oil lever monitor 3 76.Recommended fluids,
lubricants and parts
Recommended fluids andlubricants Only use products that meet the
recommended specifications.
Damage resulting from the use of
products not in line with these
specifications will not be covered by
the warranty.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
aging control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for diesel engines. If it is unavailable,
engine oils of other listed qualities
must be used.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 184.
Topping up engine oil
Engine oils of different manufacturers and brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oil with only
ACEA A1/B1 or only A5/B5 quality is
prohibited, since it can cause long-
term engine damage under certain
operating conditions.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 184.

207
Cleaning the vehicle...................175
Climate control ............................. 14
Climate control systems ...............96
Clock ............................................ 72
Control indicators.......................... 77
Control of the vehicle .................108
Controls ........................................ 69
Convex shape .............................. 30
Coolant ....................................... 142
Coolant and antifreeze ...............179
Coolant heater ............................ 102
Cornering light ......................91, 150
Coupling ball bar ........................135
Cruise control ...................... 84, 126
Cupholders .................................. 62
D Danger, Warnings and Cautions ...3
Dashboard .................................... 10
Daytime running lights .................90
Declaration of conformity ............203
Demisting and defrosting ..............14
Diesel fuel ................................... 132
Diesel fuel filter .......................... 146
Diesel fuel system bleeding .......146
Diesel particle filter ....................116
Door locks..................................... 19
Door open .................................... 84
Doors ............................................ 24
DPF (diesel particle filter) ...........116Driver assistance systems ..........126
Driver Information Centre .............84
Driving characteristics and towing tips .............................. 134
Driving economically................... 108
Driving hints ................................ 108
E ECO mode .................................. 108
Electric adjustment ......................31
Electrical system......................... 155
Electronic climate control system 98
Electronic driving programmes ..120
Electronic Stability Program .....
.................................. 81, 125, 136
Electronic Stability Program off ...82
Emergency exit ............................. 35
End-of-life vehicle recovery .......139
Engine compartment fuse box ...156
Engine coolant ........................... 142
Engine coolant temperature ........82
Engine coolant temperature gauge ....................................... 75
Engine data ............................... 185
Engine exhaust .......................... 116
Engine identification ...........182, 183
Engine oil ................... 140, 179, 184
Engine oil additives ....................179
Engine oil level monitor ................76
Engine oil pressure ......................82Engine oil viscosity grades .........179
Enhanced Traction function 124, 125
Event data recorders ..................203
Exhaust gases ............................ 116
Exit lighting .................................. 95
Exterior care .............................. 175
Exterior light ................................. 83
Exterior lighting ......................12, 89
Exterior mirrors ............................. 30
F
Fault ........................................... 121
Fire extinguisher ..........................66
First aid ......................................... 66
First aid kit ................................... 66
Fixed air vents ........................... 107
Fog light ....................................... 84
Fog lights .............................. 92, 150
Folding mirrors ............................. 31
Front airbag system .....................50
Front fog lights ........................ 89, 92
Front seats.................................... 37
Front storage ............................... 62
Front turn signal lights ...............150
Fuel consumption - CO 2-
Emissions ............................... 134
Fuel for diesel engines ..............132
Fuel gauge ................................... 75 Fuse box ............................. 156, 157
Fuses ......................................... 155

208
GGauges ......................................... 74
General information ...................134
Glass panel .................................. 35
Glovebox ..................................... 62
Glovebox cooler ......................... 107
Ground clearance .......................114
H Hand brake - see Parking brake. 122
Hazard warning flashers ..............91
Headlight flash ............................. 90
Headlight range adjustment ........90
Headlights ...................... 89, 90, 147
Headlights when driving abroad ..90
Head restraint adjustment .............8
Head restraints ............................ 36
Heated exterior mirrors .................14
Heated mirrors ............................. 31
Heated rear window ...............14, 34
Heating ........................................ 41
Heating and ventilation system ...96
High beam ............................. 84, 90
Hill start assist ........................... 123
Horn ....................................... 13, 70
Hub cap hook ............................. 158
I
Identification plate .....................182
Idle speed control .......................111Ignition switch positions .............110
Immobiliser .................................. 30
Indicators ...................................... 74
Information displays...................... 84
Initial drive information.................... 6
Instrument cluster ........................74
Instrument panel fuse box .........157
Instrument panel illumination .....155
Instrument panel overview ........... 10
Instrument panel storage .............61
Interior care ............................... 177
Interior lighting .............................. 93
Interior lights ........................ 93, 154
Interior mirrors .............................. 32
Interruption of power supply ......121
Introduction .................................... 3
ISOFIX child restraint systems ....60
J Jack ............................................ 158
Jump starting ............................. 171
K Keys ............................................. 18
Keys, locks ................................... 18
L
Lashing eyes ............................... 64
Light covers, misted...................... 92
Lighting ......................................... 89Lighting features........................... 95
Light switch .................................. 89
Load compartment........................ 20
Load compartment lighting ...........93
Loading information .....................68
Low fuel ....................................... 83
M Malfunction indicator light ............80
Manual adjustment ......................30
Manual anti-dazzle ......................32
Manual door locks ........................20
Manual mode ............................. 120
Manual transmission............. 15, 117 Manual transmission automated ......................... 15, 118
Manual windows ..........................33
Messages ..................................... 85
Mirror adjustment ........................... 8 Mirrors .................................... 30, 32
Misted light covers .......................92
N New vehicle running-in ..............109
Number plate light .....................153
O
Object detection systems ...........130
Octane rating .............................. 185
Odometer ..................................... 74

210
Stop-start system............ 16, 83, 111
Storage ......................................... 61
Storage compartments .................61
Sunglasses storage .....................62
Sun visors .................................... 35
Suspension height ......................114
Suspension seat ........................... 38
Symbols ......................................... 4
T
Tachograph ............................ 84, 88
Tachometer ................................. 75
Tail lights ................................... 151
Technical data ............................ 185
Three-point seat belt .................... 45
Tools .......................................... 158
Top-tether fastening eyes ............60
Tow bar....................................... 134
Towing ........................................ 134
Towing another vehicle .............175
Towing a trailer ........................... 135
Towing equipment .....................135
Towing eye ................................. 174
Towing the vehicle .....................174
Traction Control system ............. 124
Trailer coupling ........................... 134
Trailer stability assist .................136
Trailer towing ............................. 135
Transmission ............................... 15
Transmission display ...........77, 118Tread depth ............................... 162
Trip computer .............................. 86
Triple-Info-Display .......................85
Trip odometer .............................. 74
Turbo engine warm-up ...............110
Turn and lane-change signals .....91
Turn signal ................................... 79
Tyre chains ................................ 163
Tyre changing ............................. 167
Tyre designations ......................159
Tyre pressure ............................ 159
Tyre pressure monitoring system ............................... 82, 160
Tyre pressures ........................... 201
Tyre repair kit ............................. 164
Tyres .......................................... 159
Tyres and wheel size, changing. 163
U
Ultrasonic parking assist............. 130
Underseat storage .......................63
Upholstery .................................. 177
Upshift .......................................... 81
Using this manual ..........................3
V Vehicle battery ........................... 144
Vehicle checks............................ 139
Vehicle data ................................ 184Vehicle data recording and
privacy ..................................... 203
Vehicle dimensions .................... 192
Vehicle Identification Number ....181
Vehicle jack ................................ 158
Vehicle messages .......................85
Vehicle security ............................ 28
Vehicle specific data ......................3
Vehicle storage ........................... 138
Vehicle tools ............................... 158
Vehicle unlocking ........................... 6
Vehicle weight ........................... 187
Ventilation ..................................... 96
W
Warning chimes ........................... 86
Warning lights ............................... 74
Warning triangle .......................... 66
Washer and wiper systems .........14
Washer fluid ............................... 143
Washing the vehicle ...................175
Wheel changing .........................167
Wheel covers ............................. 163
Wheels and tyres .......................159
Wheel wrench ............................. 158
Wide view mirror .....................32, 35
Windows ....................................... 33
Windscreen................................... 33
Windscreen wiper/washer ...........70