light VAUXHALL VIVA 2019 Workshop Manual

Vehicle care147
Select:● Lo for comfort pressure up to
3 people.
● Eco for Eco pressure up to
3 people.
● Hi for full loading.
Tyre pressure sensor matching
process
Each tyre pressure sensor has a
unique identification code. The
identification code must be matched
to a new tyre / wheel position after
rotating the tyres or exchanging the
complete wheel set and if one or more
tyre pressure sensors were replaced.
The tyre pressure sensor matching
process should also be performed
after replacing a spare tyre with a
road tyre containing the tyre pressure sensor.
The malfunction light w and the
warning message or code should go
off at the next ignition cycle. The
sensors are matched to the wheel
positions, using a relearn tool, in the
following order: left side front wheel,
right side front wheel, right side rear
wheel and left side rear wheel. The
turn light at the current active position
is illuminated until sensor is matched.
Consult a workshop for service. There
are 2 minutes to match the first wheel position, and 5 minutes overall to
match all four wheel positions. If it
takes longer, the matching process
stops and must be restarted.
The tyre pressure sensor matching
process is:
1. Apply the parking brake.
2. Turn the ignition on.
3. Select neutral.4. Use MENU on the stalk to select
the Vehicle Information Menu in
the Driver Information Centre.
5. Turn the adjuster wheel to scroll to
the tyre pressure menu.
6. Press SET/CLR to begin the
sensor matching process. A
message requesting acceptance
of the process should be
displayed.
7. Press SET/CLR again to confirm
the selection. The horn sounds
twice to indicate that the receiver
is in relearn mode.
8. Start with the left side front wheel.
9. Place the relearn tool against the tyre sidewall, near the valve stem.Then press the button to activatethe tyre pressure sensor. A horn
chirp confirms that the sensor
identification code has been
matched to this wheel position.
10. Proceed to the right side front wheel, and repeat the procedure
in Step 9.
11. Proceed to the right side rear wheel, and repeat the procedure
in Step 9.

150Vehicle care1. Open the floor cover.
2. Remove the compressor and thesealant bottle.
3. Remove the electrical connectioncable and air hose from the
storage compartments on the
underside of the compressor.
4. Screw the compressor air hose to
the connection on the sealant
bottle.
5. Fit the sealant bottle into the retainer on the compressor.
Set the compressor near the tyre
in such a way that the sealant
bottle is upright.
6. Unscrew valve cap from defective
tyre.
7. Screw the filler hose to the tyre valve.
8. The switch on the compressor must be set to J.
9. Connect the compressor plug to the power outlet or cigarette
lighter socket.
To avoid discharging the battery, we recommend running the
engine.

158Vehicle care3. Connect the black lead to thenegative terminal of the booster
battery.
4. Connect the other end of the black
lead to a vehicle grounding point,
such as the engine block or an
engine mounting bolt. Connect as far away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of 1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle The towing eye is stowed with the
vehicle tools 3 142.
1. Wrap a cloth around the tip of a flat
screwdriver to prevent paint
damage. Disengage cap by using
the screwdriver and remove the
cap.

Vehicle care159
2. Screw in the towing eye as far asit will go until it stops in a
horizontal position.
3. Attach a tow rope – or better still a
tow rod – to the towing eye.
General
The towing eye must only be used for
towing and not for recovering the
vehicle.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.
Switch the selector lever to neutral.
Release the parking brake.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation and close the
windows.
The vehicle must be towed facing
forward, not faster than 55 mph. In all
other cases and when the
transmission is defective, the front
axle must be raised off the ground.
Seek the assistance of a workshop.
After towing, unscrew the towing eye.
Insert cap and engage in the front
bumper.
Appearance care
Exterior care
Locks The locks are lubricated at the factory
using a high quality lock cylinder
grease. Use a de-icing agent only
when absolutely necessary, as this
has a degreasing effect and impairs
lock function. After using a de-icing
agent, have the locks regreased by a workshop.
Washing
The paintwork of your vehicle is
exposed to environmental influences. Wash and wax your vehicle regularly.
When using automatic vehicle
washes, select a programme that
includes waxing.
Bird droppings, dead insects, resin,
pollen and the like should be cleaned
off immediately, as they contain
aggressive constituents which can
cause paint damage.

160Vehicle careIf using a car wash, comply with the
car wash manufacturer's instructions. The windscreen wiper and rear
window wiper must be switched off.
Remove antenna and external
accessories such as roof racks etc.
If you wash your vehicle by hand,
make sure that the insides of the
wheel housings are also thoroughly
rinsed out.
Clean edges and folds on opened
doors and the bonnet as well as the
areas they cover.
Clean bright metal mouldings with a
cleaning solution approved for
aluminium to avoid damages.Caution
Always use a cleaning agent with
a pH value of four to nine.
Do not use cleaning agents on hot surfaces.
Have the door hinges of all doors
greased by a workshop.
Do not clean the engine compartment with a steam-jet or high-pressure jet
cleaner.
Thoroughly rinse and leather-off the vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on
the windows will impair vision.
Exterior lights
Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use
an ice scraper, and do not clean them
dry.
Polishing and waxing
Wax painted parts of the vehicle
regularly (at the latest when water no longer beads). Otherwise, the
paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.
Unpainted plastic body parts must not be treated with wax or polishing
agents.Windows and windscreen wiper
blades
Switch off wipers before handling in
their areas.
Use a soft lint-free cloth or chamois
leather together with window cleaner
and insect remover.
When cleaning the rear window from
inside, always wipe in parallel to the
heating element to prevent damage.
For mechanical removal of ice, use a
sharp-edged ice scraper. Press the
scraper firmly against the glass so
that no dirt can get under it and
scratch the glass.
Clean smearing wiper blades with a
soft cloth and window cleaner.
SunroofNever clean with solvents or abrasive
agents, fuels, aggressive media (e.g.
paint cleaner, acetone-containing
solutions etc.), acidic or highly
alkaline media or abrasive pads. Do
not apply wax or polishing agents to
the sunroof.

Vehicle care161Wheels and tyresDo not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damage Rectify minor paintwork damage with
a touch-up pen before rust forms.
Have more extensive damage or rust areas repaired by a workshop.
Underbody Some areas of the vehicle underbody
have a PVC undercoating while other
critical areas have a durable
protective wax coating.
After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen / rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.Before and after winter, wash the
underbody and have the protective
wax coating checked.
Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean the leather upholstery with
clear water and a soft cloth. In case of
heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.
Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light-
coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.Clean seat belts with lukewarm water or interior cleaner.Caution
Close Velcro fasteners as open
Velcro fasteners on clothing could damage seat upholstery.
The same applies to clothing with
sharp-edged objects, like zips or
belts or studded jeans.
Plastic and rubber parts
Plastic and rubber parts can be
cleaned with the same cleaner as
used to clean the body. Use interior cleaner if necessary. Do not use any
other agent. Avoid solvents and petrol in particular. Do not use high-
pressure jet cleaners.

Customer information179Depending on technical equipment
level, the data stored is as follows:
● system component operating states (e.g. fill level, tyre
pressure, battery status)
● faults and defects in important system components (e.g. lights,
brakes)
● system reactions in special driving situations (e.g. triggeringof an airbag, actuation of the
stability control systems)
● information on events damaging the vehicle
● for electric vehicles the amount of
charge in the high-voltage
battery, estimated range
In special cases (e.g. if the vehicle
has detected a malfunction), it may be
necessary to save data that would
otherwise just be volatile.
When you use services (e.g. repairs,
maintenance), the operating data
saved can be read together with the
vehicle identification number and
used when necessary. Staff working
for the service network ( e.g. garages,
manufacturers) or third parties (e.g.breakdown services) can read the
data from the vehicle. The same
applies to warranty work and quality
assurance measures.
Data is generally read via the OBD
(On-Board Diagnostics) port
prescribed by law in the vehicle. The operating data which is read out,
documents the technical condition of
the vehicle or individual components
and assists with fault diagnosis,
compliance with warranty obligations
and quality improvement. This data,
in particular information on
component stress, technical events,
operator errors and other faults, is
transmitted to the manufacturer
where appropriate, together with the
vehicle identification number. The
manufacturer is also subject to
product liability. The manufacturer
potentially also uses operating data
from vehicles for product recalls. This
data can also be used to check
customer warranty and guarantee
claims.
Fault memories in the vehicle can be
reset by a service company when
carrying out servicing or repairs or at
your request.Comfort and infotainment
functions
Comfort settings and custom settings can be stored in the vehicle and
changed or reset at any time.
Depending on the equipment level in
question, these include
● seat and steering wheel position settings
● chassis and air conditioning settings
● custom settings such as interior lighting
You can input your own data in the
infotainment functions for your
vehicle as part of the selected
features.
Depending on the equipment level in
question, these include
● multimedia data such as music, videos or photos for playback in
an integrated multimedia system
● address book data for use with an
integrated hands-free system or an integrated navigation system

182IndexAAccessories and vehicle modifications .......................... 124
Adjustable air vents ...................100
Airbag and belt tensioners ...........68
Airbag deactivation ................43, 68
Airbag label................................... 38 Airbag system .............................. 38
Air conditioning regular operation ................................ 101
Air conditioning system ................ 95
Air intake .................................... 101
Air vents...................................... 100
Antilock brake system ................ 110
Antilock brake system (ABS) .......70
Anti-theft alarm system ................25
Appearance care ........................159
Ashtrays ....................................... 62
Autostop ..................................... 105
B Battery discharge protection ........93
Battery voltage ............................. 81
Belts.............................................. 36
Bonnet ....................................... 126
Bonnet open ................................. 72
Brake and clutch fluid .................163
Brake and clutch system .............69
Brake assist ............................... 111
Brake fluid .................................. 129Brakes ............................... 110, 129
Breakdown.................................. 158
Bulb replacement ....................... 132
C Catalytic converter .....................108
Central locking system ................20
Centre console storage ...............51
Centre high-mounted brake light 136
Changing tyre and wheel size ...148
Charging system .......................... 69
Child locks ................................... 22
Child restraint installation locations ................................... 47
Child restraints.............................. 44
Child restraint systems ................44
Cigarette lighter ........................... 62
City mode ................................... 113
Climate control ............................. 15
Climate control systems ...............94
Clock ............................................ 60
Code ............................................. 79
Control indicators.......................... 65
Control of the vehicle .................102
Controls ........................................ 58
Coolant and antifreeze ...............163
Cornering lights ............................ 89
Cruise control ...................... 72, 115
Cupholders .................................. 50
Curtain airbag system .................. 43

183DDanger, Warnings and Cautions ...4
Daytime running lights .................89
Declaration of conformity ............173
Door open .................................... 73
Doors ............................................ 23
Driver assistance systems ..........115
Driver Information Centre .............73
Driving hints ................................ 102
E Electric adjustment ......................26
Electrical system......................... 138
Electronic climate control system 97
Electronic Stability Control.......... 113
Electronic Stability Control and Traction Control system ............70
Electronic Stability Control off....... 70
End-of-life vehicle recovery .......125
Engine compartment fuse box ...139
Engine coolant ........................... 128
Engine coolant temperature ........71
Engine coolant temperature gauge ....................................... 64
Engine data ............................... 169
Engine exhaust .......................... 108
Engine identification ...................166
Engine oil ................... 127, 163, 167
Engine oil pressure ......................71
Event data recorders ..................178Exit lighting .................................. 92
Exterior care .............................. 159
Exterior light ................................. 72
Exterior lighting ......................12, 88
Exterior mirrors ............................. 26
F
First aid ......................................... 55
First aid kit ................................... 55
Fixed air vents ........................... 101
Folding mirrors ............................. 26
Front airbag system .....................41
Front doors ................................... 23
Front fog lights ...............72, 90, 134
Front seats.................................... 33
Front turn lights .......................... 134
Fuel............................................. 120
Fuel for petrol engines ...............120
Fuel gauge ................................... 63
Fuses ......................................... 138
G Gauges ......................................... 62
Gear shifting ................................. 70
Glovebox ..................................... 50
H Halogen headlights ....................132
Hand brake ......................... 110, 111
Hazard warning flashers ..............89
Headlight flash ............................. 88Headlight range adjustment ........89
Headlights..................................... 88
Headlights when driving abroad ..89
Head restraint adjustment .............8
Head restraints ............................ 32
Heated mirrors ............................. 27
Heated rear window ..................... 30
Heated steering wheel .................58
Heating ........................................ 35
Heating and ventilation system ...94
High beam ............................. 72, 88
Hill start assist ........................... 111
Horn ....................................... 13, 59
I
Identification plate .....................166
Ignition switch positions .............103
Immobiliser ............................ 25, 72
Indicators ...................................... 62
Info Display ................................... 78
Information displays...................... 73
Instrument cluster ........................62
Instrument panel fuse box .........141
Instrument panel illumination .....137
Instrument panel illumination control ...................................... 91
Instrument panel overview ........... 10
Interior care ............................... 161
Interior lighting .............................. 91
Interior lights ........................ 92, 137

184Interior mirrors.............................. 27
Introduction .................................... 3
J
Jump starting ............................. 157
K Key, memorised settings ..............20
Keys ............................................. 18
Keys, locks ................................... 18
L
Lane departure warning .......70, 119
Light switch .................................. 88
Load compartment ................23, 51
Load compartment cover .............53
Loading information .....................56
Low fuel ....................................... 72
M Malfunction indicator light ............69
Manual adjustment ......................26
Manual anti-dazzle ......................27
Manual transmission .................. 109
Manual windows ..........................28
Memorised settings ......................20
Mirror adjustment ........................... 8
Mirrors ......................................... 26
Misted light covers .......................91N
New vehicle running-in ..............103
Number plate light .....................137
O Object detection systems ...........117
Odometer ..................................... 63
Oil, engine .......................... 163, 167
OnStar .......................................... 84
Operate pedal ............................... 69
Outside temperature ....................60
Overrun cut-off ........................... 105
P Parking ................................ 17, 107
Parking assist ...................... 70, 117
Parking brake ............................ 111
Parking lights ............................... 91
Performing work ........................126
Power outlets ............................... 62
Power steering.............................. 70
Power windows ............................ 28
Puncture ..................................... 153
R Radio Frequency Identification (RFID) ..................................... 181
Radio remote control ...................19
REACH ....................................... 176
Reading lights .............................. 92
Rear doors ................................... 23Rear floor storage cover ..............54
Rear fog light .................72, 90, 135
Rear window wiper and washer ..60
Recommended fluids and lubricants ........................ 163, 167
Reduced engine power ................72
Refuelling ................................... 121 Registered trademarks ...............177
Retained power off .....................104
Reversing lights ........................... 91
Ride control systems ..................112
Roof .............................................. 30
Roof load ...................................... 56
Roof rack ..................................... 55
S Safety belts ................................... 36
Seat adjustment ....................... 7, 34
Seat belt ........................................ 8
Seat belt reminder .......................68
Seat belts ..................................... 36
Seat heating ................................. 35
Seat position ................................ 33
Service ....................................... 101 Service display ............................ 64
Service information ....................162
Service vehicle soon .................... 69
Side airbag system ......................42
Sidelights ...................................... 88
Side turn lights ........................... 136