weight VAUXHALL VIVARO 2014.5 User Guide

128Driving and operating
Notice
To ensure the fuel level is displayed
correctly, the ignition must be
switched off before refuelling. Avoid
minor fuel top-ups (e.g. less than
5 litres) to ensure accurate readings.
The fuel filler flap is located on the left-
hand side of the vehicle.
The fuel filler flap can only be opened
if the vehicle is unlocked and the left-
hand door is opened.
Pull flap to open.
To open the fuel filler cap, turn
anticlockwise.
The fuel filler cap can be retained in
the bracket on the fuel filler flap.
For refuelling, fully insert the pump
nozzle and switch it on.
After automatic cut-off, it can be
topped up with max. two doses of fuel.Caution
Wipe off any overflowing fuel
immediately.
When refuelling is complete, replace
the fuel filler cap and turn clockwise
as far as it will go.
Close the fuel filler flap.
Fuel filler cap
Only use genuine fuel filler caps. Diesel-engined vehicles have special
fuel filler caps.
Fuel consumption - CO 2-
Emissions The values for fuel consumption
(combined) of the model Vauxhall
Vivaro is within a range of 31 to
37 mpg.
The CO 2 emission (combined) is
within a range of 179 to 155 g/km.
For the values specific to your
vehicle, refer to the EEC Certificate of
Conformity provided with your vehicle
or other national registration
documents.
General information The official fuel consumption and
specific CO 2 emission figures quoted
relate to the EU base model with
standard equipment.
Fuel consumption data and CO 2
emission data are determined
according to regulation
R (EC) No. 715/2007 (in the latest
applicable version), taking into
consideration the vehicle weight in
running order, as specified by the
regulation.

Driving and operating129
The figures are provided only for the
purpose of comparison between different vehicle variants and mustnot be taken as a guarantee for the
actual fuel consumption of a
particular vehicle.
Additional equipment may result in
slightly higher results than the stated
fuel consumption and CO 2 figures.
Furthermore, fuel consumption is dependent on personal driving style
as well as road and traffic conditions.Trailer hitch
General information
Entrust retrofitting of towing
equipment to a workshop. It may be
necessary to make changes that
affect the cooling system, heat
shields or other equipment. Only use
towing equipment that has been
approved for your vehicle.
Driving characteristics and
towing tips In the case of trailers with brakes,
attach the breakaway stopping cable.
Before attaching a trailer, lubricatethe coupling ball. However, do not do
so if a stabiliser, which acts on the coupling ball, is being used to reduce snaking movements. For trailers with
low driving stability the use of a
stabiliser is recommended.
A maximum speed of 50 mph must
not be exceeded, even in countries
where higher speeds are permitted.If the trailer starts snaking, drive more
slowly, do not attempt to correct the
steering and brake sharply if
necessary.
When driving downhill, drive in the
same gear as if driving uphill and
drive at a similar speed.
Adjust tyre pressure to the value
specified for full load 3 178.
Trailer towing Trailer loads
The permissible trailer loads are
vehicle and engine-dependent
maximum values which must not be
exceeded. The actual trailer load is
the difference between the actual
gross weight of the trailer and the
actual coupling socket load with the
trailer coupled.
The permissible trailer loads are
specified in the vehicle documents. In general, they are valid for gradients
up to max. 12 %.
The permitted trailer load applies up to the specified incline and up to an
altitude of 1000 metres above sea

130Driving and operating
level. Since engine power decreases
as altitude increases due to the air becoming thinner, therefore reducing
climbing ability, the permissible gross
train weight also decreases by 10 %
for every 1000 metres of additional
altitude. The gross train weight does
not have to be reduced when driving
on roads with slight inclines (less than 8 %, e.g. motorways).
The permissible gross train weight
must not be exceeded. This weight is
specified on the identification plate
3 169.
Vertical coupling load
The vertical coupling load is the load
exerted by the trailer on the coupling
ball. It can be varied by changing the
weight distribution when loading the
trailer.
The maximum permissible vertical
coupling load is specified on the
towing equipment identification plate
and in the vehicle documents. Always aim for the maximum load, especially
in the case of heavy trailers. The
vertical coupling load should never
fall below 25 kg.In the case of trailer loads of
1200 kg or more, the vertical coupling load should not be less than 50 kg.
Rear axle load
When the trailer is coupled and the
towing vehicle fully loaded (including all occupants), the permissible rear
axle load (see identification plate or
vehicle documents) must not be
exceeded.
Trailer stability assist
If the system detects snaking
movements, engine power is reduced and the vehicle/trailer combination isselectively braked until the snaking
ceases. While the system is working,
keep steering wheel as still as
possible.
Trailer stability assist (TSA) is a
function of the Electronic Stability
Program 3 119.

Vehicle care159
The spare wheel is mounted under
the rear underbody and may be
secured using a security bolt that can
only be removed using the wheel bolt sleeve supplied. Vehicle tools 3 148.9 Warning
Due to the weight of the tyre
assembly, exercise caution when
releasing the spare wheel carrier.
Do not fully remove bolt 1.
Support the spare wheel with a
suitable object to prevent the
wheel falling suddenly when
loosening the carrier bolts - risk of injury!
To release the spare wheel carrier,loosen bolt 1, ensuring it is not fully
removed. Fully remove bolt 2, then
pull the carrier to the left, until it clears bolt 1, and lower the carrier assembly.
When installing the wheel ensure that
the spare wheel carrier is correctly
positioned before tightening the bolts.
Summer and winter tyres
If you use winter tyres, the spare
wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's driveability may be affected,
especially on slippery road surfaces.
Directional tyres
Fit directional tyres such that they roll in the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
■ Driveability may be affected. Have the defective tyre renewed or
repaired as soon as possible.
■ Do not drive faster than 50 mph.
■ Drive particularly carefully on wet and snow-covered road surfaces.Jump starting
Do not start with a quick charger.
A vehicle with a discharged battery
can be started using jump leads and
the vehicle battery of another vehicle.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
■ Never expose the battery to naked flames or sparks.

Technical data169Identification plate
The identification plate is located on
the right-hand door pillar.
Information on identification plate 1)
:
1=Manufacturer, type approval
number2=Vehicle Identification Number3=Permissible gross vehicle
weight rating4=Permissible gross combination
weight5=Maximum permissible front axle
load6=Maximum permissible rear axle
load7=Vehicle-specific or country
specific dataThe combined total of front and rear
axle loads must not exceed the
permissible gross vehicle weight. For
example, if the front axle is bearing its
maximum permissible load, the rear
axle can only bear a load that is equal
to the gross vehicle weight minus the front axle load.
The technical data is determined in
accordance with European
Community standards. We reserve
the right to make modifications.
Specifications in the vehicle
documents always have priority over
those given in this manual.
Engine identification The technical data tables show the
engine identifier code. Engine data
3 172.
To identify the respective engine,
refer to the engine power in the EEC
Certificate of Conformity provided
with your vehicle or other national
registration documents.1) The VIN plate on your vehicle may differ from the illustration shown.

Technical data173Vehicle weight
Kerb weight, basic model
Optional equipment and accessories increase the kerb weight.
Loading information 3 69.ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight 1
,2VanR9MShortStandard100027001661120029001661High120029001771LongStandard120029001695High120029001775ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight 1
,2Combi, BusR9MShortStandard100027001900120029001900LongStandard120029001900ModelEngineWheelbaseRoofPayload ClassGross Vehicle Weight ratingKerb weight 1
,2Platform cabR9MLongStandard120029001520

174Technical dataModelEngineWheelbaseTrim level
Additional weightsFront axleRear axleTotalCrew vanR9MShortBase246185Mid276996Upper3278110LongBase315485Mid356196Upper41691101=Kerb weight and gross vehicle weight increase on models fitted with bad road equipment package - refer to VIN plate.2=Minimum vehicle weight according to Type Approval, including all fluids, vehicle tools and a 90% fuel load. Excludesthe weight of the driver and deletable options, e.g. spare wheel, bulkhead and sliding side load door. Final weight may
vary according to the specification of the vehicle, e.g. options, deleted options and accessories.Vehicle dimensionsTypeVanCombiPlatform cabWheelbaseShortLongShortLongLongLength [mm]49985398499853985398Width without exterior mirrors [mm]19551955195519551955Width with two exterior mirrors [mm]23782378237823782378

186
Trailer stability assist .................130
Trailer towing ............................. 129
Transmission ............................... 16
Tread depth ............................... 152
Trip computer .............................. 88
Trip odometer .............................. 77
Turn and lane-change signals .....93
Turn signal ................................... 81
Tyre chains ................................ 153
Tyre changing ............................. 157
Tyre designations ......................149
Tyre pressure ............................ 149
Tyre pressure monitoring system ............................... 84, 150
Tyre pressures ........................... 178
Tyre repair kit ............................. 154
Tyres .......................................... 149
Tyres and wheel size, changing. 153
U Ultrasonic parking assist............. 124
Underseat storage .......................65
Upholstery .................................. 164
Upshift .......................................... 83
Using this manual ..........................3
V Vehicle battery ........................... 137
Vehicle checks............................ 132
Vehicle data ................................ 171Vehicle data recording and
privacy ..................................... 179
Vehicle dimensions .................... 174
Vehicle Identification Number ....168
Vehicle jack ................................ 148
Vehicle messages .......................87
Vehicle security ............................ 31
Vehicle shutdown ......................112
Vehicle specific data ......................3
Vehicle storage ........................... 131
Vehicle tools ............................... 148
Vehicle unlocking ........................... 6
Vehicle weight ........................... 173
Ventilation ..................................... 97
W
Warning chimes ........................... 87
Warning lights ............................... 76
Warning messages .......................87
Warning triangle .......................... 68
Washer and wiper systems .........14
Washer fluid ............................... 136
Washing the vehicle ...................162
Welcome lighting .......................... 95
Wheel changing .........................157
Wheel cover hook .......................148
Wheel covers ............................. 153
Wheels and tyres .......................149
Wheel wrench ............................. 148
Windows ....................................... 37Windscreen................................... 37
Windscreen wiper/washer ...........72
Winter tyres ............................... 149
Wiper blade replacement ..........139