light VAUXHALL VIVARO 2014.5 Service Manual

Vehicle care147
No.Circuit1Vehicle battery (with electronic
key system)2APC battery backup (with elec‐
tronic key system)3Passenger compartment heater4Adaptations5Adaptations6Passenger compartment heater7Additional air conditioning8Additional heating9Electric exterior mirrors, addi‐
tional adaptations10Heated exterior mirrors11Radio, multimedia, electric exte‐
rior mirrors, diagnostic socket12Multimedia, trailer hitch13Fuel injection system, courtesy
lightsNo.Circuit14Fuel injection system, tyre pres‐ sure monitoring system, elec‐
tronic key system15Hazard warning flashers, turn and lane-change signals16Central locking17Left-hand high beam, right-hand
low beam, tail lights, left-hand
daytime running light18Front fog lights, rear fog lights,
number plate lighting19Alarm, horn, automatic light
control, wiper20Instrument cluster21Light switch22Rear window wiper, windscreen
washer pump, horn23APC general battery24Reversing lights25Engine start-stop buttonNo.Circuit26Fuel injection, starter27Airbag, steering column lock28Passenger power window29Power steering30Brake lights31APC battery backup (with elec‐
tronic key system)32Service display33Cigarette lighter, power outlet34Right-hand high beam, left-
hand low beam, headlights,
right-hand daytime running light35Brake lights, ABS, immobiliser36Interior lighting, air conditioning37Starting with electronic key
system38Rear window wiper39Warning chimes

Vehicle care155
6. Screw the filler hose to the tyrevalve.
7. The switch on the compressor must be set to O.
8. Connect the electrical connection cable to the power outlet or
cigarette lighter socket.
To avoid discharging the vehicle
battery, we recommend running
the engine.9. Set the rocker switch on the compressor to I. The tyre is filled
with sealant.
10. The compressor pressure gauge briefly indicates up to 6 bar(600 kPa/87 psi). Then the
pressure starts to drop.
11. All of the sealant is pumped into the tyre. Then the tyre is inflated.12. The prescribed tyre pressureshould be obtained within
15 minutes. Tyre pressure
3 178 . When the correct pressure
is obtained, switch off the
compressor.
If the prescribed tyre pressure is
not obtained within 15 minutes,
remove the tyre repair kit. Move
the vehicle one tyre rotation
(approx. 2 metres). Reattach the
tyre repair kit and continue the
filling procedure for 15 minutes. If
the prescribed tyre pressure is still not obtained, the tyre is too badly

Vehicle care161
far away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump start.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle
Release cap by using a screwdriver.
The towing eye is stowed with the
vehicle tools 3 148.
Screw the towing eye fully into the
front towing point.
Attach a tow rope - or better still a tow
rod - to the towing eye, never to the
bumper or front suspension units.
Caution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Caution
Activate the child locks in the rear
doors if the rear seats are
occupied. Child locks 3 28.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wipers.
Transmission in neutral.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.

Vehicle care163
If using a vehicle wash, comply with
the vehicle wash manufacturer's
instructions. The windscreen wipers and rear window wiper must be
switched off. Remove antenna and
external accessories such as roof
racks etc.
If you wash your vehicle by hand,
make sure that the insides of the
wheel housings are also thoroughly
rinsed out.
Clean edges and folds on opened
doors and the bonnet as well as the
areas they cover.Caution
Always use a cleaning agent with
a pH value of 4 to 9.
Do not use cleaning agents on hot surfaces.
Have the door hinges of all doors
greased by a workshop.
Do not clean the engine compartment with a steam-jet or high-pressure jet
cleaner.
Thoroughly rinse and leather-off the vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on
the windows will impair vision.
Exterior lights
Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use an ice scraper, and do not clean them
dry.
Polishing and waxing Wax the vehicle regularly (at the
latest when water no longer beads).
Otherwise, the paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.
Plastic body parts must not be treated with wax or polishing agents.Windows and windscreen wiper
blades
Use a soft lint-free cloth or chamois leather together with window cleanerand insect remover.
When cleaning the rear window from
inside, always wipe in parallel to the
heating element to prevent damage.
For mechanical removal of ice, use a
sharp-edged ice scraper. Press the
scraper firmly against the glass so
that no dirt can get under it and
scratch the glass.
Clean smearing wiper blades with a
soft cloth and window cleaner.
Wheels and tyres Do not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.

164Vehicle care
Paintwork damageRectify minor paintwork damage with
a touch-up pen before rust forms.
Have more extensive damage or rust
areas repaired by a workshop.
UnderbodySome areas of the vehicle underbody
have a PVC undercoating while other
critical areas have a durable
protective wax coating.
After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Towing equipment
Do not clean the coupling ball bar with a steam-jet or high-pressure jet
cleaner.Interior care
Interior and upholstery
Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean any leather upholstery with
clear water and a soft cloth. In case of heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.
Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light- coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.
Clean seat belts with lukewarm water or interior cleaner.Caution
Close Velcro fasteners as open
Velcro fasteners on clothing could damage seat upholstery.
The same applies to clothing with
sharp-edged objects, like zips or
belts or studded jeans.
Plastic and rubber parts
Plastic and rubber parts can be
cleaned with the same cleaner as
used to clean the body. Use interior cleaner if necessary. Do not use any
other agent. Avoid solvents and petrol in particular. Do not use high-
pressure jet cleaners.

182IndexAAccessories and vehicle modifications .......................... 131
Adjustable air vents ...................106
Airbag and belt tensioners ...........81
Airbag deactivation ................55, 81
Airbag label................................... 50 Airbag system .............................. 50
Air conditioning regular operation ................................ 107
Air conditioning system ................ 98
Air intake .................................... 107
Air vents...................................... 106
Alert .............................................. 87
Antifreeze ................................... 135
Antilock brake system ................ 117
Antilock brake system (ABS) .......83
Anti-theft alarm system ................33
Anti-theft locking system .............. 31
Anti-theft security lock ..................23
Appearance care ........................162
Armrest ........................................ 43
Ashtrays ....................................... 76
Automatic anti-dazzle ..................37
Automatic fuel cut-off ..................112
Automatic light control .................91
Automatic locking ........................28
Autostop ....................................... 85
Auxiliary heater ........................... 102B
Battery, jump starting.................. 159
Belts.............................................. 47
Bonnet ....................................... 132
Brake and clutch fluid .................166
Brake assist ............................... 118
Brake fluid .................................. 136
Brakes ............................... 117, 136
Brake system ............................... 83
Breakdown.................................. 161
Bulb replacement ....................... 139
C Capacities .................................. 177
Car Pass ...................................... 19
Catalytic converter .....................115
Central locking system ................23
Centre high-mounted brake light 141
Changing tyre and wheel size ...153
Charging system .......................... 82
Child locks ................................... 28
Child restraint installation locations ................................... 58
Child restraints.............................. 56
Child restraint systems ................56
Cigarette lighter ........................... 75
Cleaning the vehicle ...................162
Climate control ............................. 15
Climate control systems ...............97

183
Clock ............................................ 74
Control indicators.......................... 79
Control of the vehicle .................108
Controls ........................................ 71
Controls in steering wheel ............71
Convex shape .............................. 35
Coolant ....................................... 135
Coolant and antifreeze ...............166
Coolant heater ............................ 102
Cruise control ...................... 85, 120
Cupholders .................................. 65
Curtain airbag system .................. 54
D
Danger, Warnings and Cautions ...3
Dashboard .................................... 10
Daytime running lights ............91, 92
Declaration of conformity ............179
Diesel fuel filter .......................... 138
Diesel fuel system bleeding .......138
Diesel particle filter ....................115
Door locks..................................... 23
Door open .................................... 85
Doors ............................................ 29
Driver assistance systems ..........120
Driver Information Centre .............86
Driving characteristics and towing tips .............................. 129
Driving economically................... 108
Driving hints ................................ 108E
ECO mode .................................. 108
ecoScoring.................................... 88
Electric adjustment ......................35
Electrical system......................... 144
Electronic climate control system 99
Electronic key system ...................21
Electronic Stability Program 83, 119
End-of-life vehicle recovery .......132
Engine air filter............................ 134
Engine air flow indicator .............134
Engine coolant ........................... 135
Engine coolant temperature ........84
Engine data ............................... 172
Engine exhaust .......................... 115
Engine identification ...................169
Engine oil ................... 133, 166, 171
Engine oil level ............................ 88
Engine oil pressure ......................84
Entry lighting ................................ 95
Event data recorders ..................179
Exhaust gases ............................ 115
Exit lighting .................................. 96
Exterior care .............................. 162
Exterior light ................................. 85
Exterior lighting ......................12, 91
Exterior mirrors ............................. 35F
Fault messages ............................ 87
First aid kit ................................... 68
Fixed air vents ........................... 106
Fog light ....................................... 85
Fog lights .............................. 93, 140
Fog tail light ............................... 143
Folding mirrors ............................. 36
Front airbag system .....................53
Front fog lights ............................. 93
Front seats.................................... 41
Front storage ................................ 65
Front turn signal lights ...............140
Fuel consumption - CO 2-
Emissions ............................... 128
Fuel cut-off system .....................112
Fuel economy gauge ....................78
Fuel economy mode .....................85
Fuel economy rating ...............87, 88
Fuel for diesel engines ..............127
Fuel gauge ................................... 77
Fuse box ..................................... 145
Fuses ......................................... 144
G
Gauges ......................................... 76
General information ...................129
Glovebox ..................................... 64
Glove box lighting .........................95

184
HHand brake - see Parking brake. 118
Hazard warning flashers ..............93
Headlight flash ............................. 92
Headlight range adjustment ........92
Headlights ...................... 91, 92, 139
Headlights when driving abroad ..92
Head restraint adjustment .............8
Head restraints ............................ 40
Heated mirrors ............................. 36
Heated rear window ..................... 38
Heating ........................................ 44
Heating and ventilation system ...97
High beam ............................. 85, 92
Hill start assist ........................... 118
Horn ....................................... 14, 72
I
Identification plate .....................169
Idle speed control .......................112
Ignition switch positions .............109
Immobiliser .................................. 34
Indicators ...................................... 76
Info-display ................................... 86
Information displays...................... 86
Initial drive information.................... 6 Instrument panel fuse box .........145
Instrument panel illumination .....144Instrument panel illumination
control ...................................... 94
Instrument panel overview ........... 10
Instrument panel storage ..............64
Interior care ............................... 164
Interior lighting .............................. 94
Interior lights ........................ 94, 143
Interior mirrors .............................. 36
Introduction .................................... 3
Isofix child restraint systems ........ 63
J
Jack ............................................ 148
Jump starting ............................. 159
K Keys ............................................. 19
Keys, locks ................................... 19
L
Lashing eyes ............................... 67
Light covers, misted...................... 94
Lighting ......................................... 91
Lighting features ........................... 95
Light switch .................................. 91
Load compartment ....................... 30
Load compartment cover .............66
Load compartment lighting ...........95
Loading information .....................69Load rails and hooks ...................67
Low fuel ....................................... 85
M
Malfunction indicator light ............82
Manual adjustment ......................35
Manual anti-dazzle ......................36
Manual transmission .................. 116
Messages ..................................... 87
Mirror adjustment ........................... 8
Mirrors .................................... 35, 36
Misted light covers .......................94
N New vehicle running-in ..............109
Number plate light .....................142
O
Object detection systems ...........124
Octane rating .............................. 172
Odometer ..................................... 77
Oil ............................................... 133
Oil, engine .......................... 166, 171
Oil pressure .................................. 84
Outside temperature ....................74
Overcab storage ..........................66
Overrun cut-off ........................... 113

185
PParking ................................ 18, 115
Parking assist ............................ 124
Parking brake ............................ 118
Particulate filter ........................... 115
Performing work ........................132
Pollen filter ................................. 107
Power button .............................. 110
Power outlets ............................... 75
Power steering fluid ....................135
Power windows ............................ 37
Preheating ................................... 84
Puncture ..................................... 157
R
Radio Frequency Identification (RFID) ..................................... 180
Radio remote control ...................19
Rear air conditioning system .....101
Rear doors ................................... 29
Rear fog light ............................... 85
Rear fog lights ............................. 93
Rear heating system .................. 101
Rear seats .................................... 44
Rear view camera ...................... 125
Rear windows .............................. 38
Rear window wiper/washer .......... 73
Recommended fluids and lubricants ........................ 166, 171Refuelling ................................... 127
Remote control ............................. 19
Reversing light ........................... 142
Reversing lights ........................... 94
Roof load ...................................... 69
Roof rack ..................................... 69
S Safety belts ................................... 47
Safety net .................................... 68
Seat adjustment ....................... 7, 42
Seat belt ........................................ 8
Seat belt reminder .......................81
Seat belts ..................................... 47 Seat heating ................................. 44
Seat position ................................ 41
Service ............................... 107, 165
Service display ............................ 78
Service information ....................165
Service vehicle soon .................... 82
Side airbag system ......................54
Sidelights ...................................... 91
Side turn signal lights ................141
Sliding door .................................. 29
Spare wheel ............................... 158
Spare wheel security tool ...........148
Speed limiter............................... 123
Speedometer ............................... 76
Starting and operating ................109
Starting off ................................... 16Starting the engine ....................111
Steering ...................................... 109
Steering column controls ..............72
Steering wheel adjustment ......9, 71
Steering wheel controls ...............71
Stop engine .................................. 82
Stop-start system........................ 113
Storage ......................................... 64
Storage compartments .................64
Sun visors .................................... 39
Symbols ......................................... 4
T
Tachograph .................................. 90
Tachometer ................................. 77
Tailgate ......................................... 30
Tail lights ................................... 141
Technical data ............................ 172
Three-point seat belt .................... 48
Tools .......................................... 148
Top-tether fastening eyes ............63
Torx key ...................................... 148
Tow bar....................................... 129
Towing ................................ 129, 161
Towing another vehicle .............162
Towing a trailer ........................... 129
Towing eye ......................... 148, 161
Towing the vehicle .....................161
Traction Control system ............. 118
Trailer coupling ........................... 129

186
Trailer stability assist .................130
Trailer towing ............................. 129
Transmission ............................... 16
Tread depth ............................... 152
Trip computer .............................. 88
Trip odometer .............................. 77
Turn and lane-change signals .....93
Turn signal ................................... 81
Tyre chains ................................ 153
Tyre changing ............................. 157
Tyre designations ......................149
Tyre pressure ............................ 149
Tyre pressure monitoring system ............................... 84, 150
Tyre pressures ........................... 178
Tyre repair kit ............................. 154
Tyres .......................................... 149
Tyres and wheel size, changing. 153
U Ultrasonic parking assist............. 124
Underseat storage .......................65
Upholstery .................................. 164
Upshift .......................................... 83
Using this manual ..........................3
V Vehicle battery ........................... 137
Vehicle checks............................ 132
Vehicle data ................................ 171Vehicle data recording and
privacy ..................................... 179
Vehicle dimensions .................... 174
Vehicle Identification Number ....168
Vehicle jack ................................ 148
Vehicle messages .......................87
Vehicle security ............................ 31
Vehicle shutdown ......................112
Vehicle specific data ......................3
Vehicle storage ........................... 131
Vehicle tools ............................... 148
Vehicle unlocking ........................... 6
Vehicle weight ........................... 173
Ventilation ..................................... 97
W
Warning chimes ........................... 87
Warning lights ............................... 76
Warning messages .......................87
Warning triangle .......................... 68
Washer and wiper systems .........14
Washer fluid ............................... 136
Washing the vehicle ...................162
Welcome lighting .......................... 95
Wheel changing .........................157
Wheel cover hook .......................148
Wheel covers ............................. 153
Wheels and tyres .......................149
Wheel wrench ............................. 148
Windows ....................................... 37Windscreen................................... 37
Windscreen wiper/washer ...........72
Winter tyres ............................... 149
Wiper blade replacement ..........139