pressure control VAUXHALL VIVARO 2016 User Guide

Vehicle care143General Information
Accessories and vehicle modifications
We recommend the use of genuine
parts and accessories and factory
approved parts specific for your
vehicle type. We cannot assess or guarantee reliability of other products
- even if they have a regulatory or
otherwise granted approval.
Do not make any modifications to the
electrical system, e.g. changes of
electronic control units (chip tuning).Caution
When transporting the vehicle on
a train or on a recovery vehicle, the
mud flaps might be damaged.
Vehicle storage
Storage for a long period of time
If the vehicle is to be stored for several months:
● Wash and wax the vehicle.
● Have the wax in the engine compartment and underbody
checked.
● Clean and preserve rubber seals.
● Fill up fuel tank completely.
● Change the engine oil.
● Drain the washer fluid reservoir. ● Check the coolant antifreeze and
corrosion protection.
● Adjust tyre pressure to the value specified for full load.
● Park vehicle in a dry, well ventilated place. Engage first or
reverse gear. Prevent the vehicle from rolling.
● Do not apply the parking brake.● Open the bonnet, close all doors and lock the vehicle.
● Disconnect the clamp from the negative terminal of the vehicle
battery. Beware that all systems
are not functional, e.g. anti-theft
alarm system.
Putting back into operation When the vehicle is to be put back into
operation:
● Connect the clamp to the negative terminal of the vehicle
battery. Activate the electronics
of the power windows.
● Check tyre pressure.
● Fill up the washer fluid reservoir.
● Check the engine oil level.
● Check the coolant level.
● Fit the number plate, if necessary.

Vehicle care147Engine coolant
The coolant provides freeze
protection down to approx. -28 °C.Caution
Only use approved antifreeze.
Coolant level
Caution
Too low a coolant level can cause engine damage.
If the cooling system is cold, the
coolant level should be just above the
MINI mark. Top-up if the level is low.9Warning
Allow the engine to cool before
opening the cap. Carefully open
the cap, relieving the pressure
slowly.
Top-up with antifreeze. If no
antifreeze is available, use clean tap
water or distilled water. Install the cap
tightly. Have the antifreeze
concentration checked and have the
cause of the coolant loss remedied by a workshop.
If a substantial amount of coolant is
required, it will be necessary to bleed
any trapped air from the cooling
system. Seek the assistance of a
workshop.
If the coolant temperature is too high, control indicator W 3 86 illuminates
red in the instrument cluster, together
with C 3 85. Consult a workshop if
coolant level is sufficient.
Power steering fluidCaution
Extremely small amounts of
contamination can cause steering
system damage and cause it to not work properly. Do not allow
contaminates to contact the fluid
side of the reservoir cap or from
entering the reservoir.
The power steering fluid reservoir is located below the front left wheel
arch, behind a trim panel.
The fluid level normally does not need
to be checked. If an unusual noise is
heard during steering or if the power
steering reacts conspicuously, seek
the assistance of a workshop.

Vehicle care165
With the vehicle stationary, press
button on end of wiper lever
repeatedly until the tyre pressure
menu is displayed.
Low tyre pressure condition
A detected low tyre pressure
condition is indicated by illumination
of control indicator w 3 87 and a
corresponding message appears in
the DIC.
If w illuminates, stop as soon as
possible and inflate the tyres as
recommended 3 196.
After inflating, some driving may be
required to update the tyre pressure
values in the DIC. During this time w
may illuminate.
If w illuminates at lower temperatures
and extinguishes after some driving,
this could be an indicator for
approaching a low tyre pressure
condition. Check tyre pressure.
If the tyre pressure must be reduced
or increased, switch off ignition.
Only mount wheels with pressure
sensors, otherwise the tyre pressure
will not be displayed and w flashes for
several seconds then illuminates continuously together with control
indicator F 3 85 and a corresponding
message appears in the DIC.
A spare wheel or temporary spare
wheel is not equipped with pressure
sensors. TPMS is not operational for
these wheels. For the further three
wheels, TPMS remains operational.
Control indicator w and a
corresponding message appears at
each ignition cycle until the tyres are
inflated to the correct tyre pressure.
Driver Information Centre (DIC) 3 89.
Vehicle messages 3 90.

166Vehicle carePuncture
A puncture or severely under-inflated
tyre is indicated by illumination of
control indicator w together with C
3 85 and a corresponding message
appears in the DIC. Stop vehicle and
switch off engine.
Tyre pressure 3 196, Tyre repair kit
3 168, Spare wheel 3 172, Wheel
changing 3 171.
Temperature dependency Tyre pressure depends on the
temperature of the tyre. During
driving, tyre temperature and
pressure increase.
Tyre pressure values provided on the tyre information label and tyre
pressure chart are valid for cold tyres,
which means at 20 °C. The pressure
increases by nearly 1.5 psi for a
10 °C temperature increase. This
must be considered when warm tyres
are checked.The tyre pressure value displayed in
the DIC shows the actual tyre
pressure. A cooled down tyre will show a decreased value, which does
not indicate an air leak.
Relearn function
After changing the wheels, TPMS
needs to recalculate.
With the vehicle stationary, select the tyre pressure menu in the DIC by
pressing button on end of wiper lever.
Press and hold button for approx.5 seconds to initialise recalculation. A
corresponding message appears in
the DIC.
Several minutes of driving at a speed above 25 mph may be required to
complete the relearn process. The
system can only provide limited
information during this time.
If problems occur during the relearn
process, control indicator w remains
illuminated and a warning message is
displayed in the DIC.
Driver Information Centre (DIC) 3 89.
Vehicle messages 3 90.
General information The use of commercially available
liquid tyre repair kits can impair the
function of the system. Factory-
approved tyre repair kits can be used.
Tyre repair kit 3 168.
External high-power radio equipment
could disrupt the tyre pressure
monitoring system.
Each time the tyres are replaced, TPMS sensors must be dismounted
and serviced by a workshop.

Customer information199Vehicle data recording
and privacy
Event data recorders Data storage modules in the
vehicle
A large number of electronic
components of your vehicle contain
data storage modules temporarily or
permanently storing technical data
about the condition of the vehicle,
events and errors. In general, this
technical information documents the
condition of parts, modules, systems
or the environment:
● operating conditions of system components (e.g. filling levels)
● status messages of the vehicle and its single components (e.g.
number of wheel revolutions / rotational speed, deceleration,
lateral acceleration)
● dysfunctions and defects in important system components● vehicle reactions in particulardriving situations (e.g. inflation of
an airbag, activation of the
stability regulation system)
● environmental conditions (e.g. temperature)
These data are exclusively technical
and help identifying and correcting
errors as well as optimising vehicle
functions.
Motion profiles indicating travelled
routes cannot be created with these
data.
If services are used (e.g. repair
works, service processes, warranty
cases, quality assurance),
employees of the service network
(manufacturer included) are able to
read out this technical information
from the event and error data storage
modules applying special diagnostic
devices. If required, you will receive
further information at these
workshops. After an error has been
corrected, the data are deleted from
the error storage module or they are
constantly overwritten.When using the vehicle, situations
may occur in which these technical
data related to other information
(accident report, damages on the
vehicle, witness statements etc.) may
be associated with a specific person - possibly, with the assistance of an
expert.
Additional functions contractually
agreed upon with the client (e.g.
vehicle location in emergency cases)
allow the transmission of particular vehicle data from the vehicle.
Radio Frequency
Identification (RFID)
RFID technology is used in some
vehicles for functions such as tyre
pressure monitoring and ignition
system security. It is also used in
connection with conveniences such
as radio remote controls for door
locking/unlocking and starting, and in-
vehicle transmitters for garage door
openers. RFID technology in
Vauxhall vehicles does not use or
record personal information or link
with any other Vauxhall system
containing personal information.

201Charging system .......................... 84
Child locks ................................... 28
Child restraint installation locations ................................... 59
Child restraints.............................. 57
Child restraint systems ................57
Cigarette lighter ........................... 78
Cleaning the vehicle ...................177
Climate control ............................. 15
Climate control systems .............101
Clock ............................................ 76
Coat hooks ................................... 66
Coin holder ................................... 65
Control indicators.......................... 81
Control of the vehicle .................113
Controls ........................................ 74
Controls in steering wheel ............74
Convex shape .............................. 36
Coolant ....................................... 147
Coolant and antifreeze ...............181
Coolant heater ............................ 106
Cooling (AC) ............................... 102
Cornering light .............................. 97
Cruise control ...................... 88, 131
Cupholders .................................. 66
Curtain airbag system .................. 56
D Danger, Warnings and Cautions ...4
Dashboard .................................... 10Daytime running lights............95, 97
Declaration of conformity ............197
DEF ............................................ 121
Demisting and defrosting ..............15
Diesel exhaust fluid ....................121
Diesel fuel filter .......................... 150
Diesel fuel system bleeding .......151
Diesel particle filter ....................120
Directional tyres ..................163, 172
Distance to service .......................80
Document tray .............................. 66
Door locks..................................... 23
Door open .................................... 89
Doors ............................................ 29
Double cab ................................... 67
DPF (diesel particle filter) ...........120
Driver assistance systems ..........131
Driver Information Centre .............89
Driving characteristics and towing tips .............................. 140
Driving economically................... 112
Driving hints ................................ 112
E ECO mode .................................. 112
ecoScoring.................................... 91
Electric adjustment ......................36
Electrical accessories ...................77
Electrical system......................... 157
Electronic climate control system 103Electronic data recording..............38
Electronic key system ...................22
Electronic Stability Program 86,
129, 141
Electronic Stability Program off ...86
End-of-life vehicle recovery .......144
Engine air filter............................ 146
Engine air flow indicator .............146
Engine coolant ........................... 147
Engine coolant temperature ........86
Engine data ............................... 186
Engine exhaust .......................... 120
Engine identification ...................184
Engine oil ...........145, 181, 185, 195
Engine oil additives ....................181
Engine oil level ............................ 91
Engine oil pressure ......................87
Engine oil viscosity grades .........181
Enhanced Traction function 128, 129
Entry lighting .............................. 100
Event data recorders ..................199
Exhaust gases ....................120, 175
Exit lighting ................................ 100
Exterior care .............................. 177
Exterior light ................................. 88
Exterior lighting ......................12, 95
Exterior mirrors ............................. 36

203LLashing eyes ............................... 69
LED spotlights .............................. 99
Light covers, misted...................... 98
Lighting ......................................... 95
Lighting features .........................100
Light switch .................................. 95
Load compartment ....................... 31
Load compartment cover .............68
Load compartment lighting ...........99
Loading information .....................71
Load-through feature ....................67
Low fuel ....................................... 88
Luggage floor net .........................69
M Malfunction indicator light ............85
Manual adjustment ......................36
Manual anti-dazzle ......................37
Manual transmission .................. 125
Maximum speed limiter............... 134
Messages ..................................... 90
Mirror adjustment ........................... 8 Mirrors .................................... 36, 37
Misted light covers .......................98
N New vehicle running-in ..............114
Number plate light .....................156O
Object detection systems ...........134
Octane rating .............................. 186
Odometer ..................................... 79 Oil ............................................... 145
Oil, engine .................. 145, 181, 185
Oil pressure .................................. 87
Outside temperature ....................76
Overcab storage ..........................68
Overrun cut-off ........................... 117
P Parking ................................ 18, 120
Parking assist ............................ 134
Parking brake ............................ 127
Particulate filter ........................... 120
Performing work ........................144
Phone controls.............................. 74
Phone holder ................................ 65
Pollen filter ................................. 110
Power button ........................ 17, 114
Power outlets ............................... 77
Power steering fluid ....................147
Power windows ............................ 38
Preheating ........................... 87, 116
Puncture ..................................... 171
R Radio Frequency Identification (RFID) ..................................... 199
Radio remote control ...................20Rear air conditioning system .....105
Rear courtesy lights ......................99
Rear doors ................................... 29
Rear fog light ............................... 88
Rear fog lights ........................ 95, 98
Rear heating system .................. 105
Rear parcel shelf .......................... 68
Rear seats .................................... 45
Rear view camera ...................... 136
Rear windows .............................. 39
Rear window wiper/washer .......... 76
Recommended fluids and lubricants ........................ 181, 185
Refuelling ................................... 138
Remote control ............................. 20
Reversing light ........................... 155
Reversing lights ........................... 98
Ride control systems ..................128
Roof load ...................................... 71
Roof rack ..................................... 71
S Safety belts ................................... 48
Safety net .................................... 69
Seat adjustment ....................... 7, 43
Seat belt ........................................ 8
Seat belt reminder .......................84
Seat belts ..................................... 48
Seat folding .................................. 44
Seat heating ................................. 45

204Seat position ................................ 42
Seats ............................................ 67
Selective catalytic reduction .......121
Service ............................... 111, 180
Service display ............................ 80
Service information ....................180
Service vehicle soon .................... 85
Side airbag system ......................55
Sidelights ...................................... 95
Side turn signal lights ................155
Sliding door .................................. 29
Spare wheel ............................... 172
Spare wheel security tool ...........162
Speed limiter......................... 78, 134
Speedometer ............................... 78
Starting and operating ................114
Starting off ................................... 17
Starting the engine ...............17, 116
Steering ...................................... 113
Steering column controls ..............74
Steering wheel adjustment ......9, 74
Steering wheel controls ...............74
Stop engine .................................. 85
Stop-start system.................. 17, 117
Storage ......................................... 65
Storage box .................................. 67
Storage compartments .................65
Sun visors .................................... 40
Symbols ......................................... 4T
Tablet holder................................. 65 Tachograph ............................ 89, 93
Tachometer ................................. 79
Tailgate ......................................... 31
Tail lights ................................... 154
Technical data ............................ 186
Temporary spare wheel ..............172
Three-point seat belt .................... 49
Toll road stickers .......................... 38
Tools .......................................... 162
Top-tether fastening eyes ............64
Torx key ...................................... 162
Tow bar....................................... 140
Towing ................................ 140, 175
Towing another vehicle .............176
Towing a trailer ........................... 140
Towing eye ......................... 162, 175
Towing the vehicle .....................175
Traction Control system ............. 128
Trailer coupling ........................... 140
Trailer stability assist .................141
Trailer towing ............................. 140
Transmission ............................... 16
Tread depth ............................... 167
Trip computer .............................. 91
Trip odometer .............................. 79
Turbo engine warm-up ...............116
Turn and lane-change signals .....97
Turn signal ................................... 83Tyre chains ................................ 168
Tyre changing ............................. 171
Tyre designations ......................163
Tyre pressure ............................ 163
Tyre pressure monitoring system ............................... 87, 164
Tyre pressures ........................... 196
Tyre repair kit ............................. 168
Tyres .......................................... 163
Tyres and wheel size, changing. 167
U Ultrasonic parking assist............. 134
Underseat storage .......................67
Upholstery .................................. 178
Upshift .......................................... 86
Using this manual ..........................3
V Vehicle battery ...................149, 174
Vehicle checks............................ 144
Vehicle data ................................ 185
Vehicle data recording and privacy ..................................... 199
Vehicle dimensions .................... 190
Vehicle Identification Number ....183
Vehicle jack ................................ 162
Vehicle messages .......................90
Vehicle security ............................ 32
Vehicle shutdown ......................117
Vehicle specific data ......................3