lock VAUXHALL VIVARO 2017.5 Manual PDF

Vehicle care191Notice
The driving characteristics of the
repaired tyre is severely affected, therefore have this tyre replaced.
If unusual noise is heard or the
compressor becomes hot, turn
compressor off for at least
30 minutes.
Pay attention to storage information
and expiry date on sealant bottle. Its
sealing capability is not guaranteed
after this time.
Replace the used sealant bottle. Dispose of the sealant bottle as
prescribed by applicable laws.
Wheel changing
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel 3 188.
Make the following preparations and
observe the following information:
● Park the vehicle on a level, firm and non-slippery surface. The
front wheels must be in the
straight-ahead position.
● Apply the parking brake and engage first gear or reverse gear.● Remove the spare wheel 3 192.
● Never change more than one wheel at a time.
● Use the jack only to change wheels in case of puncture, not
for a seasonal winter or summer
tyre change.
● The jack is maintenance-free. ● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.
● Remove heavy objects out of the
vehicle before jacking up.
● No people or animals may be in the vehicle when it is jacked-up.
● Never crawl under a jacked-up vehicle.
● Do not start the engine when the vehicle is raised on the jack.
● Clean wheel bolts/nuts and thread with a clean cloth before
mounting the wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Remove the wheel cover (using the hook supplied). Vehicle tools
3 182.
2. Loosen each of the wheel bolts by
half a turn using the wheel
wrench. Ensure the wrench
locates securely. The wrench
should turn anticlockwise to
loosen the bolts. Invert the wrench if necessary.

192Vehicle care
3.Place lifting pad spigot of the jack
under the jacking hole located
nearest the wheel concerned.
Ensure the jack is positioned
correctly. The jack base must be
on the ground directly below the
jacking hole in a manner that
prevents it from slipping.
4. Install wrench onto the jack and raise the vehicle by turning the
wrench until the wheel is clear of
the ground.
5. Unscrew wheel bolts completely by turning anticlockwise and wipe
clean with a cloth.
Put wheel bolts somewhere
where the threads will not be
soiled.
6. Change the wheel. Spare wheel 3 192.
7. Screw in the wheel bolts.
8. Lower the vehicle and remove jack.
9. Tighten each of the wheel bolts in
a crosswise sequence using the
wheel wrench. Ensure the wrench locates securely. The wrench
should turn clockwise to tighten
the bolts. Invert the wrench if
necessary.
Tightening torque is 160 Nm.
10. Replace the wheel cover, ensuring that the valve hole in thewheel cover is aligned with the
tyre valve before installing.
Notice
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).11. Stow the replaced wheel 3 192
and the vehicle tools 3 182.
12. Have the new wheel balanced on the vehicle.
Check the tyre pressure of the
installed tyre 3 216.
Check the wheel bolt torque.
Have the defective tyre renewed or
repaired as soon as possible.
Spare wheel
Some vehicles are equipped with a tyre repair kit instead of a spare wheel
3 188.
If mounting a spare wheel which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,
even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.

Vehicle care195
Lead connection order:1. Connect the red lead to the positive terminal (1) of the booster
battery.
2. Connect the other end of the red lead to the positive terminal (2) of
the discharged vehicle battery.
3. Connect the black lead to the negative terminal (3) of the
booster battery.
4. Connect the other end of the black
lead to a vehicle grounding point
(4), such as the engine block or an
engine mounting bolt. Connect as
far away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump start.
2. After five minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
one minute.
3. Allow both engines to idle for approx. three minutes with the
leads connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle The towing eye is stowed with thevehicle tools 3 182.
Release cap using a suitable tool.
Screw the towing eye clockwise into
the front towing point and tighten fully
using the wheel wrench.
Attach a tow rope - or better still a tow rod - to the towing eye, never to the
bumper or front suspension units.

196Vehicle careCaution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Caution
Activate the child locks in the rear
doors if the rear seats are
occupied. Child locks 3 30.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Notice
Depending on version, it may be
necessary to switch on the engine to
permit operation of brake lights.
Transmission in neutral.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
Switch on hazard warning flashers
3 109.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the air recirculation system 3 115 and
close the windows.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and replace cap.
Towing another vehicle
The fixed towing eye is located under the rear bumper, on the left vehicle
side.
Attach a tow rope - or better still a tow
rod - to the rear towing eye, never to
the rear axle and suspension units.
The rear towing eye must only be
used for towing and not recovering a
vehicle.

Vehicle care197Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
Trailer hitch 3 159.
Appearance care
Exterior care
Locks The locks are lubricated at the factoryusing a high quality lock cylinder
grease. Use de-icing agent only when absolutely necessary, as this has adegreasing effect and impairs lockfunction. After using a de-icing agent,
have the locks regreased by a
workshop.
Washing
The paintwork of your vehicle is
exposed to environmental influences, therefore wash your vehicle regularly.
When using automatic vehicle
washes, we recommend one with
textile brushes and a programme
without wax additives. Restrictions for
filmed or matt painted body parts or
decor tapes, see "Polishing and
waxing".
Never use a steam-jet or high-
pressure jet cleaner for the engine
compartment.Wax painted parts of the vehicle
regularly.
Bird droppings, dead insects, resin,
pollen and the like should be cleaned off immediately, as they contain
aggressive constituents which can
cause paint damage.
If using a vehicle wash, comply with
the vehicle wash manufacturer's
instructions. The windscreen wipers
and rear window wiper must be
switched off and the exterior mirrors
must be folded in. Remove antenna
and external accessories such as roof
racks etc.
If you wash your vehicle by hand,
make sure that the insides of the
wheel housings are also thoroughly
rinsed out.
Clean edges and folds on opened
doors and the bonnet as well as the
areas they cover.
Clean bright metal mouldings with a
cleaning solution approved for
aluminium, to avoid damage.

220Customer information● vehicle reactions in particulardriving situations (e.g. inflation of
an airbag, activation of the
stability regulation system)
● environmental conditions (e.g. temperature)
These data are exclusively technical
and help identifying and correcting
errors as well as optimising vehicle
functions.
Motion profiles indicating travelled
routes cannot be created with these
data.
If services are used (e.g. repair
works, service processes, warranty cases, quality assurance),
employees of the service network
(manufacturer included) are able to
read out this technical information
from the event and error data storage
modules applying special diagnostic
devices. If required, you will receive
further information at these
workshops. After an error has been
corrected, the data are deleted from
the error storage module or they are
constantly overwritten.When using the vehicle, situations
may occur in which these technical
data related to other information
(accident report, damages on the
vehicle, witness statements etc.) may be associated with a specific person -possibly, with the assistance of an
expert.
Additional functions contractually
agreed upon with the client (e.g.
vehicle location in emergency cases)
allow the transmission of particular
vehicle data from the vehicle.
Radio Frequency
Identification (RFID)
RFID technology is used in some
vehicles for functions such as tyre
pressure monitoring and ignition
system security. It is also used in
connection with conveniences such
as radio remote controls for door
locking/unlocking and starting, and in-
vehicle transmitters for garage door
openers. RFID technology in
Vauxhall vehicles does not use or
record personal information or link
with any other Vauxhall system
containing personal information.

222IndexAAbsorptive Glass Mat battery .....168
Accessories and vehicle modifications .......................... 162
Adaptive forward lighting ...........108
AdBlue .................. 98, 103, 137, 201
AdBlue tank ................................ 215
Adjustable air vents ...................125
AGM battery ............................... 168
Airbag and belt tensioners ...........95
Airbag deactivation ................62, 95
Airbag label............................. 57, 62
Airbag system .............................. 57
Air conditioning regular operation ................................ 126
Air conditioning system .............. 115
Air intake .................................... 126
Air recirculation ...................115, 195
Air vents...................................... 125
Alert ............................................ 102
Antifreeze ................................... 166
Antilock brake system ................ 144
Antilock brake system (ABS) .......97
Anti-theft alarm system ................36
Anti-theft bolts............................. 191
Anti-theft locking system .............. 35
Anti-theft security lock ..................24
Appearance care ........................197
Armrest ........................................ 48
Ashtrays ....................................... 88Automatic anti-dazzle ..................41
Automatic fuel cut-off ..................132
Automatic light control ...............107
Automatic locking ........................30
Autostop ............................. 131, 133
Auxiliary heater ........................... 119
B Battery ........................................ 168
Battery discharge protection ......113
Battery, jump starting.................. 194
Belts.............................................. 53 Bench seat.................................... 74
BlueInjection ............................... 137
Bonnet ....................................... 163
Bottle holders................................ 74
Brake and clutch fluid .................201
Brake assist ............................... 145
Brake fluid .................................. 167
Brakes ............................... 144, 167
Brake system ............................... 96
Breakdown.................................. 195 Bulb replacement ....................... 172
C
Capacities .................................. 215
Car Pass ...................................... 20
Catalytic converter .....................137
Central locking system ................24
Centre high-mounted brake light 174
Changing tyre and wheel size ...187

223Charging system .......................... 96
Child locks ................................... 30
Child restraint installation locations ................................... 66
Child restraints.............................. 63
Child restraint systems ................63
Cigarette lighter ........................... 88
Cleaning the vehicle ...................197
Climate control ............................. 15
Climate control systems .............114
Clock ............................................ 86
Coat hooks ................................... 73
Coin holder ................................... 71
Collision damage repair ..............219
Control indicators.......................... 92
Control of the vehicle .................128
Controls ........................................ 83
Controls in steering wheel ............83
Convex shape .............................. 39
Coolant ....................................... 166
Coolant and antifreeze ...............201
Coolant heater ............................ 119
Cooling (A/C) .............................. 115
Cornering light ............................ 108
Cruise control ....................100, 149
Cupholders .................................. 73
Curtain airbag system .................. 61D
Danger, Warnings and Cautions ...4
Dashboard .................................... 10
Daytime running lights ........107, 108
Declaration of conformity ............217
DEF ............................................ 137
Demisting and defrosting ..............15
Diesel exhaust fluid ....................137
Diesel fuel filter .......................... 170
Diesel fuel system bleeding .......170
Diesel particle filter ....................136
Directional tyres ..................183, 192
Distance to service .......................91
Document tray .............................. 73
Door locks..................................... 24
Door open .................................. 100
Door panel storage .......................74
Doors ............................................ 31
Double cab ................................... 74
DPF (diesel particle filter) ...........136
Driver assistance systems ..........149
Driver Information Centre ...........100
Driving characteristics and towing tips .............................. 159
Driving economically................... 127
Driving hints ........................ 127, 128
Driving style indicator ...................91E
ECO mode .................................. 127
ecoScoring.................................. 103
Electric adjustment ......................39
Electrical accessories ...................86
Electrical system......................... 178
Electronic climate control system 116
Electronic data recording ..............41
Electronic key system ...................22
Electronic Stability Program 97,
147, 160
Electronic Stability Program off ...97
End-of-life vehicle recovery .......163
Engine air filter............................ 165
Engine air flow indicator .............165
Engine coolant ........................... 166
Engine coolant temperature ........97
Engine data ............................... 206
Engine Drag Torque Control ......147
Engine exhaust .......................... 136
Engine identification ...................204
Engine oil ...........164, 201, 205, 215
Engine oil additives ....................201
Engine oil level .......................... 102
Engine oil pressure ......................98
Engine oil viscosity grades .........201
Enhanced Traction function 146, 147
Entry lighting .............................. 112
Event data recorders ..................219
Exhaust gases ....................136, 195

225JJack ............................................ 182
Journey record............................ 103
Jump starting ............................. 194
K
Keys ............................................. 19
Keys, locks ................................... 19
L
Lashing eyes ............................... 77
Lashing straps .............................. 77
Laying up the vehicle ..........162, 168
LED spotlights ............................ 110
Light covers, misted.................... 110
Lighting ....................................... 106
Lighting features .........................112
Light switch ................................ 106
Load compartment ................33, 76
Load compartment cover .............77
Load compartment grille ...............79
Load compartment lighting .........111
Loading information .....................80
Load-through feature ....................74
Low fuel ....................................... 99
Luggage floor net .........................77
M
Malfunction indicator light ............96
Manual adjustment ......................39
Manual anti-dazzle ......................40Manual transmission .................. 143
Maximum speed limiter............... 152
Messages ................................... 101
Mirror adjustment ........................... 8
Mirrors .................................... 39, 40
Misted light covers .....................110
N New vehicle running-in ..............129
Number plate light .....................176
O
Object detection systems ...........152
Odometer ..................................... 89
Oil ............................................... 164
Oil, engine .................. 164, 201, 205
Oil pressure .................................. 98
Outside temperature ....................85
Overcab storage ..........................76
Overrun cut-off ........................... 133
P Parking ................................ 18, 136
Parking assist ............................ 152
Parking brake ............................ 145
Particulate filter ........................... 136
Pedals......................................... 128
Performing work ........................163
Phone controls.............................. 83
Phone holder ................................ 71
Pollen filter ................................. 126Power button........................ 17, 129
Power outlets ............................... 86
Power steering fluid ....................166
Power windows ............................ 42
Preheating ........................... 98, 131
Puncture ..................................... 191
R
Radio Frequency Identification (RFID) ..................................... 220
Radio remote control ...................20
Reading lights ............................ 111
Rear air conditioning system .....118
Rear courtesy lights ....................110
Rear door manual lock .................24
Rear doors .............................. 24, 31
Rear fog light ............................... 99
Rear fog lights ....................106, 110
Rear heating system .................. 118
Rear parcel shelf .......................... 77
Rear seats ................................... 49
2nd row seats ............................ 49
3rd row seats............................. 49
Folding ...................................... 49
Installing .................................... 49
Rear seat access ......................49
Removing .................................. 49
Seat cushion adjustment ...........49
Rear view camera ...................... 154
Rear windows .............................. 42

227Tyre pressure monitoringsystem ............................... 98, 185
Tyre pressures ........................... 216
Tyre repair kit ............................. 188
Tyres .......................................... 183
Tyres and wheel size, changing. 187
U Ultrasonic parking assist............. 152
Underseat storage .......................74
Upholstery .................................. 199
Upshift .......................................... 97
USB socket ................................... 86
Using this manual ..........................3
V
Vehicle battery ...................168, 194
Vehicle checks............................ 163
Vehicle data ................................ 205
Vehicle data recording and privacy ..................................... 219
Vehicle dimensions .................... 210
Vehicle Identification Number ....203
Vehicle jack ................................ 182
Vehicle messages .....................101
Vehicle security ............................ 35
Vehicle shutdown ......................132
Vehicle specific data ......................3
Vehicle storage ........................... 162
Vehicle tools ....................... 182, 195
Vehicle unlocking ........................... 6Vehicle weight ........................... 208
Ventilation ................................... 114
W
Warning chimes .........................102
Warning lights ............................... 89
Warning messages .....................101
Warning triangle .......................... 80
Washer and wiper systems .........14
Washer fluid ............................... 167
Washing the vehicle ...................197
Welcome lighting ........................112
Wheel changing .........................191
Wheel cover hook .......................182
Wheel covers ............................. 187
Wheels and tyres .......................183
Wheel wrench ............................. 182
Wide view mirror ........................... 40
Windows ................................. 41, 42
Windscreen................................... 41
Windscreen stickers .....................41
Windscreen wiper/washer ...........84
Winter tyres ............................... 183
Wiper blade replacement ..........171