door lock VOLKSWAGEN CARAVELLE 1992 T4 / 4.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine
CONTENTS
DASHBOARD AND

CONTROLS

Layout
4
i\='-:ng
lamps 6

CONTROLS
AND

EQUIPMENT

•
e.s. Central locking system 7, 8
I:cs, Tailgate 9, 10
I'I
~g doors 11

..
-^ows, Mirrors 12, 13
Sea: belts 15 5re:y for children 18
-ead restraints 19

Seats
20 _:ariing/sleeping surface 26

__ggage
compartment cover 27 __cgage compartment/load surface ... 28
-edals, Brakes 29 Vanual gearbox 31
--tomatic gearbox 32
gnition
lock 36
Starting / Stopping the engine .... 37, 38 "struments 40

.'.
arning lamps 47
Switches 50
~yn signal and dip lever 52

3'uise
control system 53 .'.'indscreen wiper 54
-eating and ventilation 55

Air
conditioner 57
Recirculating air switch 61
Auxiliary heater 63
Additional
water heater 67
Sun roof, Sliding/tilting roof 70, 71
nterior lights, Sun visors 72, 73
Ashtray, Cigarette lighter 73
-oof
rack 75
DRIVING
TIPS

The first 1500 km - and afterwards ... 76 Driving safely 78
Driving economically and

ecologically
79
Trailer towing 81

GENERAL
MAINTENANCE
Filling the tank, Fuel 85, 86
Care of car, Maintenance 88, 93 Bonnet, Engine compartment 94, 95
Engine oil, Gearbox oil 96, 99

Air
cleaner 100 Power assisted steering 100

Cooling
system 101
Brake fluid 104
Battery 106
Windscreen washer system 108
Wheels 110
Arduous operating conditions 115
Winter driving 116
Accessories, modifications and
renewal of parts 117
Mobile
telephones and two way
radios 117

DO-IT-YOURSELF

First
aid kit, Warning triangle 118
Vehicle tools 118 Spare wheel/changing wheel ... 119, 120
Fuses
122

Changing
bulbs 124
Adjusting/masking headlights .. 128,129
Headlights 129
Installing radio 129
Emergency starting 130
Tow starting/towing 132
Lifting vehicle 134
TECHNICAL
DESCRIPTION

Engine 136
Emission control system 137
Activated charcoal filter '38 Power flow '39
Steering, Axles 139 Brakes, Body -139,
1
AC
Environment compatibility 140

TECHNICAL
DATA
Engine 141
Performance 142
Fuel consumption 143
Spark plugs 145
V-belts 145
Wheels,
Tyre
pressures 146, 147

Weights,
Trailer weights 148, 151 Dimensions 152
Capacities 153
Vehicle identification data 154

SPECIAL
INFORMATION

Adjusting the brake pressure regulator 155

ALPHABETICAL
INDEX

Alphabetical index 156

CHECKS
WHEN
FILLING

THE TANK
Overview 160
3
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND EQUIPMENT

Central
locking system*
With this system all the doors, and - de­
pending
on the position of the tailgate or
wing door lock - the tailgate or wing door

can
also be locked and unlocked.

The
system is operated from the
driver's
door or
front
passenger door - from

outside
with the key, from inside with the
locking
knob.

Note

The
central locking system can only func­
tion correctly when the driver's and
front
passenger
doors are properly
closed.

When
locking,
the locking knobs on all doors must move down. If the knob on one door

does
not move at any time, open the door

concerned
and close it properly.

Attention

•
When
the locking knobs in the

driver's
or
front
passenger doors
are pressed
down
all
other
doors
are locked
automatically.
Since it
would
be
difficult
to ren­
der assistance
from
the outside in an emergency,
when
the doors
are locked, children should
never
be
left
in the vehicle on
their

own. • Locking the doors can
prevent

them
from
bursting open in an
extraordinary
accident situation. Locked doors also
prevent
per­

sons
from
entering
the car forci­ bly e.g. at
traffic
lights.
However,
in an emergency
they
make
it

more
difficult
for outside
help
to
open the doors.
Notes: If the central locking system should develop

a
fault, all the locks can be operated nor­
mally,
see next page.

The
sliding door can be secured or released
separately
with the safety catch.
Sliding door and
tailgate
or
wing

door can be locked or unlocked separately
with the key.
To
unlock the tailgate or wing door insert key

and
turn
it to right (c). Hold in this position

and
press button in.
If the key is withdrawn in the horizontal
posi­

tion (a), locking of the tailgate or wing door
will be controlled by the central locking
sys­

tem when it is closed again.

When
the key is withdrawn in the vertical
position (b) and tailgate or wing door
closed,

it will be locked all the time. The tailgate can
then only be unlocked with the key.
8
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND
EQUIPMENT

Doors
Cab doors
From outside
the
front
doors can be
coked
or unlocked
with
the key. When un-
D
eking,
the locking knobs go up, when lock-

"5
:hey go down.

Ihe
front
passenger door can be locked

from
outside
without
using the key: Just
:"5ss
locking knob down and close door.

~~e
driver's door cannot be locked when
coen
by pressing the locking knob down
and closing door. This prevents you from
esving
the key in the car and forgetting it.

From inside
all the doors can be locked by

messing
down the locking knobs.

-s
long as the knobs are pressed down the

coors
cannot be opened from inside or out-

skte.

Attention Locking
the
doors
can
prevent
them from bursting open
in an
extraordinary accident situation. Locked doors also prevent per­
sons from entering
the car
forci­
bly e.g.
at
traffic lights. However,
in
an
emergency they make
it

more difficult
for
outside help
to

open
the
doors.

Sliding door

From outside,
the sliding door can be

locked
and unlocked
with
the key.
The sliding door can also be locked from out­
side
without
using the key:
Press
locking knob down and close door.

From inside,
the sliding door is locked by
pushing down the locking knob.

As
long as the knob is pressed down the
door cannot be opened from inside or out­

side.

When the vehicle is moving, the door must always be properly
closed,
but when carry­ing passengers the locking knob should be

left
in the upper position so
that
the door can
be opened from outside in an emergency.

Note

In the opened position the sliding door is
held open by a retainer. Child-proof
catch

When the child-proof catch is engaged - lever on door lock down - the inner lock re­

lease
lever is inoperative. The door can only
be opened from outside
with
the locking
knob in the up position.
9
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

Wing
doors*

Righthand
door

From
outside
the wing door can be rcked and unlocked with the key. When un-
;cking the locking knob goes up, when
:eking it goes down.

From
inside
the door is locked by pressing down the knob.

-s
long as the knob is pressed down the

;3or
cannot be opened from inside or out.
- the fully open position (approx. 90°) the
;cor is held by a check strap.
Lefthand
door

The lefthand door can be opened when the righthand door is open.
To open, pull release lever (see illustration) and open door.

Note

When
closing
the
wing
doors
always
ensure
that
the
left
door
is
closed

first.
Unhooking
door
check
strap

Both doors are held in the open position (ap­
prox. 90°) by check straps.
To open the doors further the check strap can be unhooked (see illustration).
When doors are closed the check straps en­ gage again automatically.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT
The lap part of belt must always fit tightly across the pelvis. If necess­
ary,
pull the belt tight.
Particularly in the case of pregnant

women,
the lap part of the belt should be as low across the pelvis as
possible so that no pressure is ex­
erted on the abdomen.
Taking belt off
K release the belt, press the orange-co- :_red button in the lock. The tongue will
"en spring out.
-ass the tongue towards the door by hand
so that the retractor can roll the belt up
oroperly. A plastic knob in the belt holds the
:ongue in a convenient position.
Lap belt
The belt lock is used in the same way as on the three-point inertia reel belts.
The belt must always fit tightly across the pelvis.
For safety reasons a lap belt not being used
should always be connected to the buckle. To lengthen belt hold the tongue at right
angles to belt and pull belt through to the re­
quired length - see illustration.
The belt is easier to adjust if tongue and cap are pressed together.
To shorten belt it is only necessary to pull
the free end of belt.
The surplus belt length is taken up by mov­ ing the plastic slide. Automatic retracting lap
beits

The single seats* in the ca;;e-;e'
;im­
pertinent are equipped with =- —5; ;
retracting lap belt.
Putting belt on
Pull the belt out and insert the tors_e ~:
the appropriate lock part until tongue en­ gages (pull to check).
The belt must always fit tightly across the pelvis, if necessary,
pull

the belt tight.
Note
If the belt is pulled too tight, it can
be released by pressing in the
but­

ton located on the belt reel.
Taking belt off
Press the orange-coloured button in the
lock part and guide belt by hand sc :na: :~s
retractor can roll the belt up properly.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND
EQUIPMENT

Seat
stop
(3)*
the second battery* is located under the •ft seat. To get to the battery the seat can

:e
cashed forward past the normal stop:
• Dush seat fully forward
• Dul stop outwards and push seat
further
":~.vard.

Pivoting
seats*
me release mechanism of both seats is lo­ rded on each seat base at bottom
right.

Seats
are released by pulling up the lever.

E::^
seats are turned anti-clockwise so
:~at it might be necessary to push the seat
':".vard slightly or open the doors.

Attention

When
vehicle
is
moving
the
seats
must
be
facing
forward
and be

properly
secured.
Two-seater
passenger bench*

To
lower the backrest, press locking knob to
the rear.
When lowered, the backrest is locked. The locking knob must therefore be pressed
again to
lift
backrest up.

Attention
For
safety
reasons the
backrest

must
always
be locked
when
ve­

hicle
is in
motion.
Head
restraints

The head restraints should be ac _s:e; body
size
- see page 19.

Seat
heating*

Seat
cushion and backrest of
front
seats can
be heated electrically when ignition is on. Further details are given under "Switches",
page 51.
Armrests*
The armrests on the
front
seats can be hinged up if they are not required.
The angle of the armrests can be adjusted

as
required
with
a knurled knob, underneath
the armrest.

2!
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Wheels

General
notes

• New tyres do not give maximum grip straight away and should therefore be run in
at moderate speeds and a careful style of
driving for about the
first
100 km. This will help to make the tyres last longer.
• Check tyres for damage from time to time (cuts, splits, cracks and lumps) and re­move any foreign bodies embedded in the
treads.
• To avoid damage to tyres and wheels crive over curbs and similar obstacles very
slowly and as nearly at
right
angles as
poss­
ible.
Damage
to wheels and tyres is not always

easy
to see, so if you
think
that
a wheel is
damaged,
it must be checked by a Volks­
wagen dealer.
• Keep grease, oil and fuel off the tyres.
• Replace missing dust caps as soon as
possible.

• Mark wheels before taking them off so
that
they rotate in the same direction when put back on again. • When taken off, the tyres should be
stored in a
cool,
dry and preferably dark
place.

Tyres
which are not on wheels should be stored in a vertical position.

Tyre
life

Tyre life depends to a considerable extent on the following factors:

Inflation
pressure
The inflation pressure is very important par­
ticularly at high
speeds.
Therefore, the pres­
sures
should be checked at least once a month and before every long journey.
At this opportunity do not forget the spare

wheel:

• The spare wheel should always be in­ flated to the highest pressure required on
the vehicle.
Always
check the pressures when the tyres are cold.
When
warm,
the pressure is
higher
but do not
reduce.
The pressur­

es
are given on page 147 and on a sticker on
the driver's door lock pillar.
Pressures
which are too high or too low
shorten
tyre
life - quite apart from the detri­ mental influence on vehicle handling.

Attention

At
continuous
high
speeds a
tyre
in
which
the pressure is too low

flexes
more
and
heats
up excess­
ively.
This can cause
tread
separ­

ation
and
tyre
blow
out.

pCU
A
pressure
which
is too low in- oo
creases
the
fuel
consumption

and
this
burdens
the
environment
unnecessarily.

Mode
of
driving
Fast
cornering, hard acceleration and viol­
ent braking also increase
tyre
wear.
'0
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Changing
wheels

Park
the vehicle as far as possible away
from the
traffic
flow, if necessary switch on emergency warning lights and place the
warning triangle in position - note legal re­
quirements.
• All vehicles occupants should leave the vehicle and move to a safe area (e.g. behind
the barrier).
• Apply handbrake firmly. If the car is on a
slope,
block one of the wheels on the oppo­
site side
with
a stone or some similar object.
• Take the tools out of the vehicle.
• Take spare wheel out of carrier at rear of vehicle - see previous page.
JB70
- 121J
•
Push
the wheel spanner as far as
poss­
ible onto the wheel bolt as shown and
turn

the spanner anti-clockwise. When doing this, grip the spanner as far as possible to­
wards the lever end.
If the bolts cannot be loosened, one can in
an emergency, carefully push the spanner
down
with
a
foot
on the end of the lever.
One
should ensure
that
one has a
firm

stance
and a good grip on the vehicle.

Loosen
wheel bolts about one turn. 8"" 1 •>!
•
Place
jack under vehicle: - Depressions in the side member at
front
and rear indicate the points at which the
jack must be
fitted
- see arrows in illus­
tration. On the sliding door side
ensure

that
the
claw
of the
jack
does not
fit
under
the sliding door.
- On the Pick-.up the jack is placed under the mounting of the trailing arm (triangu­lar mark) at the rear.
- If the
jack
is not
placed
at the
marked
points, the
vehicle
can be

damaged.

120
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
TECHNICAL DATA

Tyre
pressures
Attention

The
tyre
pressures
must
be
checked
at
least
once
a
month.

They
are
very
important
particu­
larly
at
high
speeds-see
page
110.
These
pressures are for cold tyres. When
tyres are warm the pressure is higher but do
not reduce it.
The inflation pressures are given on a sticker on the inside of the driver's door lock pillar. As the pressures may be altered at
short notice fortechnical reasons there may

Tyre
pressures
for
vehicles
with
a
permissible
axle
load11 on one
axle
of less
than
1285 kg
Tyres
Pressure
in bar
Front
Rear

Spare

185 R 14 C 97/99N (or 97/99P) 3.0 3.8
3.8
195/70 R 15 97 S reinforced 2.6 3.4
3.4
205/65 R 15 98 S reinforced 2.6 3.4
3.4
215/65 R 15 100 T (or 102H) reinforced 2.4 3.0
3.0

Tyre
pressures
for a
vehicle
with
a
permissible
axle
load11 on one
axle
of 1285 kg or
more

Tyres
Pressure
in bar
Front
Rear

Spare

185 R 14 C 97/99N (or 97/99P) 3.4
3.8 3.8
195/70 R 15 97 S reinforced 3.0 3.4 3.4
205/65 R 15 98 S reinforced 3.0 3.4 3.4
21 5/65 R 15 100 T (or 102H) reinforced 2.4
3.0 3.0 be differences between sticker and Instruc­

tion
Manual. If this should be the
case,
ask your Volkswagen dealer for the correct
pressures.

The permissible
front
and rear axle loads are givenonpage148.
147
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
TECHNICAL DATA

Vehicle
identification
data

The
type
plate
is
secured to the
front
passenger's door lock
pillar.

Vehicles
for
certain export countries have no Type plate. 2
3

FAHRZG.
IDENT -NR.

VEHICLE
IDENT NO.

MOTORKB.
/ GtTR
-KB.
[
[NC.COM/TRANS.C0M
I

LACXNR./INNENAUSST.
[
PAINT
NO./
INTERIOR i

M-AUSST./

OPTIONS

8 17
183

The
vehicle
data
sticker
is
stuck underneath
the
instrument panel

near
the central electrics.
The sticker contains the following data: 1- Production control number

2-
Vehicle identification number

3-
Model code number

4-
Model explanation/engine
output
5-
Engine and gearbox code letters
6- Paint number/interior
trim
code
7- Optional extra number
The vehicle data 2-7 is also given in the
Ser­
vice
Schedule. The
vehicle
identification

number

(Chassis
number)

is
stamped on the outside on
right
below the

windscreen.

The
engine
number

is
stamped
in the
block below the cylinder

head
or is on a
sticker on
the
toothed belt

guard.

154
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans