interior lights VOLKSWAGEN CARAVELLE 1992 T4 / 4.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

Notes

Pools of
water
under
the
vehicle

• When the ambient temperature is high
and
the air very humid, condensed water

can
drip off the evaporator and form a puddle under the vehicle. This is quite nor­

mal
and does not indicate a leak.

Operating
faults

• Should the air conditioner not work at
any
time, either:
- the ambient temperature is below about + 5 degrees C,
- the fuse has blown.

Check
fuse and if necessary renew it - see

page
122. If the trouble is not due to
a
defec­
tive fuse, switch the system off and have it
checked.

- the air conditioner has switched off due to the coolant temperature being too high -
see
page 41
also.

• If the cooling
output
drops off, switch the
A/C
off and have the system
checked.
Using air
conditioner

economically
In cooling operation the air conditioner
com­

pressor
places demands on the engine and
therefore influences the fuel consumption.

To
keep the period switched on as short as
possible,
the following points should be

noted:

• If the inside temperature is very high after the vehicle has been parked in the sun, it is recommended to open doors or win­

dows
briefly to enable the hot air to
escape.

• The air conditioner should not be
switched
on during a journey if the windows

or
sliding/tilting
roof*
are open.
• If the desired interior temperature can be attained
without
switching on the air condi­
tioner, the fresh air operation should be se­
lected.
Recirculating
air
switch

If badly contaminated air is to be prevented
from entering the vehicle, e.g. when driving
through a tunnel, the recirculating air switch in the instrument panel can be
pressed.

When
the recirculating air system is
switched
on, a small warning lamp lights up in the switch.

However,
the recirculating air system

should
only be used for a short period other­

wise
the windows will mist up.

60
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND
EQUIPMENT

Interior
lights

Front interior light

Switch
positions:
Front: Light on continuously

Centre:
Off
Rear:
Door contact switch
Rear interior light

Switch
positions:
1: Light on continuously

0:
Off
2:
Door contact switch
Engine
compartment

light*

This
light
works when side or headlights are
on.

It is located on the inner side of the bonnet

and
is switched off or on
with
a rocker switch - see illustration.
72
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Fuse
layout

<*'om
left
to
right)

No.
Component
A11
' - Dipped beam
left,
headlight range control
left
10
I- Dipped beam
right,
headlight range control
right
10
3-
Instrument
and number plate lighting 10
--
Rear
wiper, seat heating 15

5-
Windscreen wiper,
windscreen and rear window

washer/elec.
heated

washer
jets 15

5-
Blower, air conditioner 30
/- Tail and side
light
right,
engine compartment
light
10

3-
Tail and side
light
left
10
9-
Rear
window heating, mirror heating 20

10-
Fog lights, rear fog
light
15
II- High beam
left,
high beam
warning lamp 10

12-
High beam
right
10

13-
Horn, radiator fan (run-on) 10
1 Ampere No.
Component
A

14-
Reversing lights, electric outside mirrors, sliding/tilting
roof,
shift pattern auto, gearbox,

cruise
control system
(cancel contacts on the brake
and clutch pedal) 10

15-
Engine electronics 10

16-
Warning lamps,
dash
panel insert,
glove box
light
15

17-
Turn signals 10

18-
Electric fuel pump,

Lambda
probe 20

19-
Radiator fan, air conditioner 30

20-
Brake lights 10

21-
Interior
and luggage compartment lights, make-up mirror
light,

clock,
radio,
central locking 15

22-
Cigarette lighter 10
Additional
fuses
(in separate holders)
• above the relays A11

Fuse
for electric windows 20
• In the engine compartment on the bulk­
head
above the brake servo:

Glow
plugs21 50
• Under the driver's seat

Fuse
for additional water heater 10

Fuse
for heater blower .30

Fuse
for water heater
glow plug 20
Fuse
for auxiliary heater3' 25
Fuse colour code:

Red:
10 Ampere

Blue:
15 Ampere

Yellow:
20 Ampere

Green:
30 Ampere
21 This fuse should only be renewed by
a
Volks­
wagen dealer.
31 On vehicles
with
swivelling seats this fuse
can
be found in the side
trim
behind the
driver's seat.

123
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF

Rear
fog
light

• Renewal of the bulbs for the rear lights
is
done from the luggage compartment
through the rear panel trim.
• Take housing out.
• Turn bulb holder out to the
left.

• Take bulb out and renew.
• Turn bulb holder back in.
•
Insert
left
side of housing in the recess
first
and press in
firmly
until
the tabs en­

gage.
Number
plate
lights

The lights are secured
with
2 screws.
• Take lens off
• Pull complete
light
out
• Pull bulb housing out • Pull defective bulb out and renew
•
Insert
bulb housing
• Secure lens
firmly

Interior
and
reading
light*

Interior
light
(A)
•
r.sert
a knife blade or something similar
into
gap between housing and lens and
carefully lever lens off.
• Change bulb.
• Dress lens
into
housing again, when doing this the lug on the lens must fit in the
recess
in the housing.
'26
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL
INDEX

Engine
-Code
letters 154

-Data
141
- Intervals of oil change 93

-Number
154

-Oil
96 - Oil capacity
1
53
- Oil change intervals 98
- Oil consumption 97
- Oil level 97
- Oil pressure 47
- Starting/stopping 37

Engine
compartment 95

Engine
compartment
light
72
Engine
number 154 Environment
- Activated charcoal
filter
738

-Battery
707
- Brake
fluid
705 - Care of car 88
- Coolant 103
- Driving environment consciously 79 - Driving
with
low emissions/noise 79
- Emission
control
system 737
- Engine oil 98
- Filling the
tank
85
-Fuel 86 - Maintenance 93
-Old oil 98 - Old
tyres
712 - Petrol vapour accumulator .... 738
-
Tyre
pressure
7
70
- Tyres 7 72
- Unleaded
fuel
86
- Washing the vehicle 89

F

Fan
103

Filling
the tank 85

Filter
preheating 87

First
aid kit 118

Fog
lights 51, 125
Folding
seat 25

Foot
mats 29

Fresh
air ventilation 56
Front axle load 148 Front seats 20

Fuel
86

-Additives
86, 87

-Consumption
79,143
- Filter 116
- Filter preheating 87 - Gauge 46
- Saving 79

Fuses
122

G

Gear
change marks 40, 77

Gear
lever 31

Gearbox
oil 99

Glove
box 74
Glow
plugs 38
H

Handbrake
31
Head
restraints 19

Headlight
beam control 50

Headlight
flasher 52

Headlight
washer system 54

Heated
rear window 51

Heating
55, 57

High
beams 48

Horn
4
I
Identification data 154
Ignition
lock 36

Increased
payload 149

Inertia
reel belts 16 Inside mirror 13
Inspection intervals 98
Installing seat 22

Instrument
lighting 50
Instruments 40
Interior
lights 72, 126
Intervals of inspection 93
Intervals of oil change 93

J
Jack
120

Jacking
points 120

Jumper
cable 130

157
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans