spark VOLKSWAGEN GOLF 1999 Owners Manual

Service at km) -ALL
Eng ine:
Engine :
Exhaust system:
Spark
Water sepa rator: Drain water (TDI engine only)
(Golf, Jetta, New Beetle, EuroVan)
Spark
Dus t and (where
add if necessary
Au tomat ic shift
Au tomat ic transmiss ion :
add if necessary; check for
Automatic transmission
B rake system: brake pad thickness and brake
Drive sh afts:
On -Board diagnostic system: memory; purge if ne cessary
Roof frame:
Front on joints and tie rods; check tie rods
Airbag system: check every 12 months
Road test: air condi­tioning, power accessories and systems
Continued on next page
14

Service at
Engine: and
Engine: for leaks
Exhaust system: for damage and leaks
filter: Replace
Water separator: Drain engine only)
Battery:
Battery:
Door check straps: Lubricate
Spark plugs: Replace
Air cleaner: Replace filter element
add if necessary
Dust and
V-belt:
W indshield washer:
Automatic shift lock:
Automatic transmission: for leaks
Manual transmission:
Replace

Battery
Can cause blindness or severe burns.
Flush eyes immediately
with water. Get medical help fast.
Always keep the battery
well out of the reach of
children.
Always wear eye protec­
tion. Do not
Do not expose the battery
to an open flame, electric sparks or an open light. Do not smoke. Do not reverse
polarity.
Battery acid contains
sulfuric acid. Always wear
gloves and eye protection. Do not tilt the battery be­
cause acid could leak out of the ventilation openings.

open flame or electric spark. Hydrogen gas generated by the battery can explode and cause per­
sonal injury.
AND
tap on the sid e
of the window.

is on the instrument from the out­
side through the
-see tio n above.
The safety
with
identification number of
you r
is
reasons your may
h ave either
of the two
is compartment The
identif ication no.
2 -Type code number
The spark ig nit ion system meets no.
equipment numbers
and chapter "CHECKING
AND
datas are
VEHICLE - - ---------------3

DATA
174 hp engine
Engine data
Maximum output SAE net 174 hp at
at rpm
(245 Nm a t rpm)
No.
of
(2.791 cm3)
Stroke 3.55 in
(90.3mm)
Bore
3.19 in (
81.0 mm)
1
Premium or
Capacities
55
ReseNe
in gal. capacity )
washer container in quarts.
Engine liters 6.4 6.1
Maximum
with brakes
chapter Booklet 3.2 .
The engine oil level should be checked while
topping up.
The spark ignition system meets
Booklet 3 .2 .
3) chapter
Booklet 3 .2.
6 ---------ENGIN E

rpm
Maximum torque
SAE net 155 ft. rpm (21 rpm)
No. of
4
(1 .896 cm3)
S troke 3.76 in ( 95.5 mm)
Bore 3.13 in ( 79.5 mm)
55
Reserve in gal.
in capacity )
washer container in quarts.
in quarts.
without brakesn in lbs.
in lbs. /kg 165 75
Note 1l The engine oil level should be checked while
topping up.
Do not Booklet 3 .2 .
See also chapter AND Booklet 3.2.
The spark ignition system meets all requirements of the Canadian
ference-Causing Equipment Regula­
tions.
--------ENGINE DATA,