tire VOLKSWAGEN GOLF 2008 User Guide

Eng in e:
Water separator: Drain water engin e
o nly)
Wind shiel d washer: fluid level, add if
necessary
Automatic shift lock: cluding park/neutral position switch
Brake system:
Wheels: Rotate from front to rear
Rear sp oiler: Lubric at e (New Beetle only)
Date: ........................
Mile
s/km: ...................
whic hever occurs
Airbag system: Visual ch eck every 12 months regardless of mileage (kilometers )
l2V sta rter and auxil iary battery: check
(where applicable)
Timi ng belt: Replace (TDI engine only)
Tires: tread depth, adjus t tir e pressure
if necessary.
Tire pressure monitoring sys tem sensors:
cable).
date and Volkswag en Dealer stamp
Service at
Engine: oil and oil
Date: ............ ........... .
M
iles/km : ....... ........... .
whichever occurs
Today's date and Volksw agen Dea ler stamp
Warranty Voucher 19

Engine: oil and oil filter
Engine: for leaks
Exhaust system: fo r damage and leaks
Water separator: Drain water (TDI e ngi ne only)
Fuel
electrolyte level
Battery: (Golf, )etta, New
Door check straps: Lubricate
s ystem:
Windshield washer:
Automatic sh ift lock:
Automatic transmiss ion:
Manual transmiss ion:
Wheels:
Tires/spare wheel :
Date: .................. ... ...
Miles/km: .................. .
which ev
er occurs first
Brake system: for damage/leaks, brak e pad thickness and brake fluid
Drive shafts: boots
On-Board diagnos tic system: fault
memory; purge if nece ssary
Roof frame: and lubricate
Front axle: jo int s and tie rod ends; ch eck tie rods
Hea dligh ts : Adjust
Rear sp oile r: Lub ricate (New Beetle only)
Airbag system: Visual check every 12 months regardless of mileage (kilom eters)
Road test: kickdown , braking, steering, heating and ventilation , air condi­tioning, powe r accessories and electrical sys­tems
Timing belt: Replace (TDI engine only)
starter and auxiliary banery: check
( w here applicable)
T ires: tread dept h, adjust tire pressure
if nec essary _
Tire pressure monitoring system sen sors: battery charge, replace wheel electronics and aluminum valve if necessary (whe re appli­
cable) .
date and Volkswagen Dealer stamp

Table of contents
Limited New
. . . .
7 What is not covered . . . . . . . . . . . . . . . . . . . . . 8
Limited Warranty Against
What is covered . . . . . . . . . . . . . . . . . . . . . . What is not covered . . . . . . . . . . . . . . . . . . . . . 11
24 Hour Roadside Assi stance
The 24 Hour Roadside Assistance program .................... .
Emissions Warranties ...
Emissions System Defect
Warranty . ............. ................ .
1.2 USA Warranty
Emissions Warranties .
requires us to provide you
with the
Emiss ions Warranty
Statement: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WARRAN TY STATEMENT . . . . . . . . . . . . . . . .
Emiss ions System Defect Warranties . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 For 3 years . .. .. .. .. .. .. . . 22
.. .. .. .. .. .. .. .. .. .. . 28
....................
dispute
services .................................
Service . . . . . . . . . . . . . . . . 31
literature Ordering
.................................. 31
Tire Manufacture rs ................. 32
list of tire manufacturers for new
..................... 32
of contents

1.2 USA Warranty
What is not covered
Tires
Tires arc not cove red by th is
a list of tire manufacwrers
Maintenance services and
nance serv ice.
Thi s
warranty does not cove r the replacement of filters, oil, lubricants, flu ids, or air conditioner refrigerant charge. unless their replacement is a necessary of warranty service on covered component.
Mechanica l a dju stments not with a
defect in material or workmanship are not ered after the first year or miles, ever occurs first (i.e. headlight adjustment). This warranty docs not cover wheel alignmem or tire
Damage or
damage or malfunct ions which arc the result of improper repair of of
a ny non Genuine Volkswagen pa n s alte r th e ve hicle perfo rmance specifications from those se t by the veh icle manufacturer.
modificat ions to the vehicle (including the ginc management syste m). accessories su ch as a larm syste ms, remote roof
new parts not sold or approved by Volk swagen, or used part s, or the damage to associated or sys te m s: or
damage or m alfunct io ns w hi ch the vehicle. in particular any major or structural alt e ra tion s such as the veh icle to a convertibl e or the
modification of the roof to accommodate a glass roof or other similar structural
damage or malfunctions caused by in tiona) or unintentionalmisfueling. collision or modificat io ns th e vehicle, including, but not limit ed to the or engine components approve d by Volkswagen; or
damage or malfunctions resulting from the use the vehicle in competitive events or caused by acci dent or fire; or
damage or malfunctions resulting from the vehicle a warning gauge reading o r other warnin gs indicate mechanical or operation al problem: or
damage or malfunctions due to suspension modifications, su ch as the installat ion
be a loss by
bled from or repaired

program is your assurance that help will be there should yo ur Volk swagen have a mechanical breakdown under norma J3l driving conditions. Whether this happen s th ousands of miles from home (a nywhere in th e U .S . or or in
your own dri vew ay, you only have to call one
toll -free number and h elp
To
tancc is ava ilab le to you for th e firs t fou r years of
your new vehicl e ownersh ip.
T he Volkswagen 24
Hour Roadside Assistance includes th e following em ergency roadside services : emergency towing, battery jump sta rt , flat tire change. em ergen cy fuel
Please refe r to your 24 lo u r ta nce Guide for specific detail s on the services provided.
for the Serv ice

The Magnuson-Moss Warranty Federal Trade Commission lmprovemelll Act of 1975 and lations issu ed pursuan t to the act require that a
t ire warranty be p laced in every new vehicle prior sale.
T o a
ssis l yo u in information, the follow ing lis t o f tir e turers and addresses is being provided.
Tire Manufacture rs
Dunlo p Tire Corp. 1144 Marke t Slree t
A kro n, 44316 Tel.: I 548-4714
13rid ges tone/Fires tonc Inc.
I 13ridgestone Nas hville. TN 372 14 Tel. : I
443 16 T el.: I 321-2136
Continenta l General
Continemallllvd .
C harloue. NC 28273 Tel.: I
13ox G reenville, Tel.: I
Pirclli Tires North Ameri ca Geo rge S lh F loor
New I Iaven, CT 747-3554
Goo drich Tire Co.
Tel.: I

driver.
For your safety and the safety of your pas­
sengers, before driving always:
- Make sure
that all lights and signals are
operating corr ect ly.
- Make su re
that the tire pres sure is cor­
r
ect.
- Make sure that all windows are clean
and afford good visibility to the outside .
- Secure all luggage and
other items care ­
page
re­
stra int correctly to protect children
53.
- S it properly in your seat and make sure
that your passengers do the same
4.
- Fasten your safety belt and wear it prop ­
erly. Also instruct your passenge rs to
fasten their safety belts properly
Safe driving is directly related to the condition of the vehicle, the driver as well as
the driver' s ability to concentra te on the road without being distracted.
The driver is responsible for the safety of
the vehi cle and all of its occupants. If your
ability to drive is impa ir ed, safety risks for
everybody in
the vehicle in crease and you
a lso becom e a hazard to everyo ne else
on
the There fo re:
- Never let yourse lf be di stracted by pas­
sengers
or by using the Infotainm ent
syste m or a cellular tel ephone.
- Never drive w
hen your driving ability is
impa ired (by medication s, alco hol,
drugs,
etc.) .
- Observe a
ll traffic laws, rules of th e road
and speed limit s and plain common sense. -
Alway s
adjust you r speed to road, traffic
a
nd weathe r conditions.
- Take frequen t breaks on long trip
s.
Don't drive for more than two hours at a
s tretch.
-
Do n ot drive when you are tir ed, unde r
pressure
or when you are stresse d.
WARNING
Impaired driving safety increases the risk of serious personal injury and death whenever a
vehicle is being used

Safety
wear safety
Wearing safety belts correctly saves lives!
Fig. 5 of principle: occu pants wearing safety belts
This Booklet expla in s w hy safety belt s are
necessa ry . how they work and how to
just and wear them correctly .
Number of seats
Your vehicl e has a total of five se ating position s:
two in t h e fron t and three in th e re ar. Eac h seating positio n has a sa fe ty belt.
WARNING
Not wearin g safety belts or wea ring them
- Read all the information that follows
and heed all of the instructio ns and
WARNINGS in thi s bookl et.
WARNING
No t wearing safety belt s o r wearing them properly increases the ris k of se rious pe rson al
injury and death.
Safety belts are th e s ingle most effective
means availa ble to reduce the risk of serious inju ry and death in automobile acciden ts . For your protection and that of your passengers,
a lways correctl y wear safety belts when the hicle is fig. 5 .
Pregnant women, injured, or physically
i mpaired person s must also use safety belts.
Like vehicl e occ upants, th ey are more like ly
to be se riously injured if th ey do not wear safety belts. The best way to protect a fetus is to protec t the mother throughout the entire
pregnancy
(continued !
Never strap more than one person, cluding cially dangerous to plac e a safety belt over a child sittin g on your lap.
Neve r let more people ride in the ve hicle than there are safety belts available.
B e sure everyo ne ridin g in the vehicl e is properl y res trained with a separate sa fety belt
o r chil d res train t
Safety

Safety
sengel:
Fig. 16 Safe ty
out fig . 16 . Never use th e safe ty belt
ex tende r for any oth er purpo se includin g th e tachment of a c hild restraint.
Th e
exte nder adds a boutB inches mm) to
the safery belt. Whe n it is not require d , always
s hop for a ss is tan ce if an extende r is requ ired .
H ow to fas te n the s
afety belt extender properly 24, th e sa fe ty belt
crea ses the risk of seriou s personal injury and death.
a safery belt exten de r w hen not needed can increase the risk of injury , cially in a collision. it is worn low
and snug, and in the cor rec t seating position.
R emove and sto w safe ly when not needed.
Never use the safet y belt extender if yo u
ca n fasten the sa fety belt without it.
Never use more than one extender with a
safery be lt. The use of m ore than one extender c a n ch ang e the way the sa fe ty belt passes over
the body and can cause se rious injury .
Never leave the saferybelt extender ta ched to the veh icle safe ty belt latch when it is not needed and being used because th e airbag control module will not re ceive the correc t
s ign al from the safety b elt la tc h and prevent the Advanc ed Airbag from working properly .
Never use the safe ty belt extender to secure
a child restraint.
Never use a safery belt ex tender from
Nev er u se the safery belt extend er yo u tained for your vehicle for any other vehicle,
regardless of make, model or model year.
A driver or pass enger w ho is not correct ly
re strained can be seriously injured b y striki ng the interior of the passe ng er compartment or by the safery b elt its elf whi ch can b e di spla ced
from stronger parts of the body into se nsiti ve areas lik e th e abdomen.
Always read and heed all WARNINGS and other important pa ge
signal th e airbag
co ntrol unit that the front passenge r seat is
ca use the s afery belt prete nsio n er to deploy necessarily and fron t to deplo y la ter in
collision s th at would trigge r the front
a irb ag earlie r in th e to help pro tect an unrestrain ed front seat occ upant. A sioner that has dep loyed can not b e repair ed.
T he entire sa fety belt mu st b e rep laced.
Safety

replace any airbag in your vehicle and assure system effectiveness in a crash.
Booklet 2.1 Safety first
Never permit salvaged or recycled ai rb ags
to be installed in your
low ering th e veh icle, changing the
s tiffness of th e suspe nsion , including the spring s, suspe nsion struts, shock absorber s etc.
ca n change th e forces that are meas ured by th e
air bag senso rs and sen t to the electron ic control
unit. s u sp ensio n chang es for ample, increase the force level s m eas ured by the
sensors and make the airb ag system deploy in
cras hes in wh ic h it wou ld no t dep loy if th e
c h a nges had no t bee n made. kind s of ch a nges may reduce the force leve ls mea sured by the senso rs and preve nt the airbag from ploying whe n it should.
The Advanced Airbag will not work the
way it s houl d if th e o ptional safety belt exte nder is not removed from the safety belt latch when
the seat i s occup ie d and the sa fe ty belt is not bei ng used. Leaving th e extender attach ed to the safety belt buck le when the front seat is
s ig na l the airbag control unit that the front seat is occup ied and that the sa fety belt is being used. The elec tron ic co ntro l unit for the airbag system
will then rece ive incorrect information that will cause the safe ty belt pretens ioner to deploy
has deployed can not be re pair ed.
T he entir e safety belt must be rep laced . For that
rea son, a lways re move the sa fety belt exte nde r
w hen it is not nee ded and stow it sa fely
23. In ad d ition, the safet y belt extender must never be used to secure child rest raint s to
th e front passenge r seat.
T he se ns
ors in the safety belt buckle for the driver and front passenge r seat tell th e troni c control module if the safe ty belt is latc hed or If th e sa fe ty belt is being used, the front airbag
will deploy
at a sl ightly highe r rate of hi cle dece leration than if the sa fe ty belt is not
b eing used . Therefore , in a particular collision, it
i s possible that an airbag will not deplo y at a seatin g position where the safety belt is being
u sed but infla te at the position where the safe ty belt is not bei ng use d. It is important that n othing interfere with the safety belt buck les so
that the sensors can send the correct tion abou t safety belt use to the elec tron ic
C hanging the ve hicl e's suspension including
us e of unapproved tire-rim combinations ca n change Advanced Airbag performance and crease the risk of se rious personal injury in a
c ras h.
Never install s uspension components that do not h ave the same performance ist ics as th e components originally in stalled on your ve hicl e.
Never use tire-rim combin a ti o ns th at have not been approved by Volkswage n.
Leaving the optional safety belt extender tached to th e safety belt latch on the front senger seat when the safety belt is not being
u se d will prevent the Adva nced fro m functioning properl y and ca n in crease the risk of se riou s pe rso nal injury in a
Always remove the safety belt extende r
w hen it is not needed and stow it safely whe n
it is not bei ng used with the safety belt.
Never use th e safety belt exte nder to secure
a c hild restraint at any seating position.
buckle and the cente r conso le can cause the sensors
Airbag system 45