check oil VOLKSWAGEN GOLF PLUS 2004 Owners Manual
[x] Cancel search | Manufacturer: VOLKSWAGEN, Model Year: 2004, Model line: GOLF PLUS, Model: VOLKSWAGEN GOLF PLUS 2004Pages: 541, PDF Size: 98.86 MB
Page 235 of 541
Refueling checklist
first rea d an d note the introductory information and heed the on page 234.
The engi ne compartment of moto r vehicle is a haza rdous engine or in the engin e compartment unless yo u -know exac tl y how to carry o ut the job,
-have the correct technical in formation and the proper too ls and supplies, and -ar e familiar with the necessary safety precautions page 242, Preparation s for working
have the work done by an authorized Volkswagen dealer or authorized Volkswag e n Serv ice Facility. Ser ious personal injury may result from improperly perform ed work. Make
s ure that y ou check the followin g item s re gu larly. The bes t thin g is to check them every time you refue l:
Wind sh ie ld was her fluid leve l page 128
E ng in e oil leve l page 247
Engin e coolant leve l page 252
Brake fluid level page 188
Tire pressure page 276
Vehicle lighting necessary for drivin g safe ty:
-Turn signal s
-
li ghts, low beams and high beams
- Taillights
- Brak e light s
Inf
ormat ion regard ing changing light bul bs page 344.
While dri ving
Page 244 of 541
Engine oil
Introduction
In thi s sect io n you'll find inform ation on the fol
lowing:
Warning and indicator lights . . . . . . . . . . . . . . . . . . . 247
Engine
=>Boo klet Warranty
fo r wor king in the engine compartment=> page 242
accessories, repairs and modifications page303
Im
proper h andling of engin e oil can cause severe burns and other seriou s injurie s.
Always wear eye protection.
Warning and indicator light s
Engine oil is poisonous and must be stor ed out of the rea ch of children.
To reduce
Engine oil becomes ex tremely hot when the engine is running and can ca use severe burns. Alway s le t the engine cool down to the tou ch.
all othe r operat in g flui ds, engine oil can pollut e the envir o nment. leak ing op
erat ing fluid s and dispose of them properly in ac
co rdance with appl icable environmental laws and regu latio ns.
on page 247.
Light s response up
Engine oil level too low. th e engine. th e eng ine oil leve l --=>page 249.
Flashes cause respon se
Switc h off the eng ine.
Engine oil press ure too low.
-If the warning light flashes although the oil level is normal , do continue driving or let the en gine idle. as damage may result. Get ex -pert assis ta n ce.
Take the veh icle to an auth orized Volkswagen Engine oil leve l sensor malfunction. dealer or authorized Volkswagen Service Fa-cility. Have the engine oil sensor checked .
Page 246 of 541
Checking the engine
u
J
Fig. 15 1
information and heed the o n pag e 247.
For a tru e reading of e ng ine oil level, the engine must be at operating temperature. Switch off the engin e and wa it a few minutes for the engine oil to
flow back into the oil pan.
the eng in e hood 242.
The engin e oil filler cap is marked w it h fig . 15 2 . The oil dipstick has a colored handle.
Engin e oil level ranges
Fig. 152 In the engine comportmen t: Engine oil filler cop.
R e insert the dip stick and push it all the way in.
If there is an alignment tab o n the engine oil
th e oil dipstic k out again a nd check the tab le o n page 249.
Afte r read ing th e oil leve l, reinsert the dipstick
in the gu ide tube and push it all the way back in.
fig.l51 Required action according to the respective engin e
Do not refill
T he oil leve l may go into the range,
but not above the range.
lit er). After addin g oil, make sure that the oil
l eve l is
about in the middle of rang e.
Adding engine oil (after checking level)
T o p off gradually w it h sm all amounts of oiL
Unscre w th e cap oft he engine oil filler opening from the cy lind er head cover. If yo u are
not sure where it is , contac t yo ur authorized swage n dea le r or authorized Volkswagen Serv ice Facility .
In the engine comportment
Add oil in sm all amounts-not more than I pint
page 248.
To avo id adding too much oil, wa it a w hile afte r
addin g eac h small qu antity of oil (so that the added oil can reach the oil pa n and the dipstick).
248 249
Page 247 of 541
the oil leve l agai n befo re addin g more
oil. Never add much
O nce th e oil leve l is at least in the ( B) ra nge
oil dip stick all th e way. oil could le ak out while th e en
g in e is running.
Afte r r efilling, car efully put the oil ca p back on and scre w it shut. Oth erwi se, oil could leak out whi le th e e ngine is running.
E ngin e oi l ca n ignite
when it tou ches hot e n g ine parts. T hi s can ca use fires, burns, and other severe injuri es.
Always make sure that the engin e oil fill er cap is screwed on tightly afte r adding oil so that oil cannot leak out ont o hot engin e parts whe n
th e vehicle is moving .
Engine
first r ea d and no te th e introductory information and h eed o n pa ge 247.
To prov ide effective lubricatio n and coolin g for in
ternal engine parts, all internal combustio n en
g ines use some oil. consumption varies from
e ng in e to engi ne and may ch an ge ove r th e life of th e e ng in e. Engi nes te nd to use m ore oil during th e
br eak- in peri od th an they do afterwa rd, when oil
co nsumption has s ta bili zed.
rat e of oil consump
tion dep e nd s on oil quality a s well as v isc osity, e n
g in e s pee d (rpm), outs ide tempe rature, road condit io ns, the amount o f oil dilution caused b y condensed water o r fuel residue, and oxidation of th e
o il. consumptio n may in crease with eng in e
wea r ove r time, until re pla cement of worn eng ine part s may beco me necessary .
Volk swage n recommends th at yo u to c heck the engin e oil leve l
vehicl e may consum e engine oil d epending o n seve ral var iables. A maximum of I quart per miles (!lite r km ) would be
Care, maintenance
Note
D o not start the engine if lhe e ngine oil leve l is
above range expert ass is ta n ce! Otl1envise the ca talytic con verter and engine ca n be dam
aged!
W hen changin g or topping ofT make sure that you pour the into the correct reservoir s. Addi ng incorrec t
The e ngine oil leve l s h o uld never be above ran ge oil ca n be drawn in by
th e cra nkcase ventilation syste m and ent er th e at
mo sphere via th e e xh au st sys te m .
co nside red normal. New vehicles may consume
m ore oil over th e km).
T he oi l pressure warning light is not an indicator oflowe ng in e oillevel.lfthe warning light stays on or whil e d rivin g (above rpm), a chime
will sound. It indica tes that the oil pressure is too
low. th e engine immediately, check the engine oil leve l and add oil if n ecessary . If the engine oil leve l is normal , but the continues to do not kee p driving or let t11e e ngin e idl e, as damage may occur.
If you believe your en g in e uses to o much oil, Volkswagen recommends havin g th e vehicle checked b y an auth orized Volkswagen dea le r or an ri ze d Volk swagen Service Facility. Keep in mind that accurate measurem ent of oi l consumption requires great ca re and m ay take som e time. au
t h orized Volkswa gen d ea ler and a uthorized Volk
s wa gen Facility have instru ctions for how to m eas ure oi l co nsumptio n acc ura te ly.
Dep e ndin g on the wa y th e ve hicl e is dri ven an d th e ope ratin g conditions, oil consump
t ion can be up to I quart per mil es (!liter per
Page 268 of 541
Caring for upholstery
first read and note the int roductory information and heed the on page
Checklist
note the following when it comes to the care and preser va tion of the
Faste n e rs can damage upho ls te 1y fabric . B efore you get into the veh icle, fasteners that could com e int o wit h fabrics and
Sharp-edged objects and items on and phone cases, zippers, rivets, and rhinestones) can materia l and fabri c trim.1b help prevent damage, do no t let su ch items com e into direct contact with the and fa bric trim .
Dust and dirt pa rticles in pores, folds, and seams ca n have surface damage .
clothing for colo r-fas tness to help prevent upho ls tery discoloration, especially to ore d
Note
Disregarding the upholstery-related checklist may lead to damage or of stery and fabric trim.
note and follow the points
oration remove d by an authorized
first read and not e the information and heed the on
Normal
Befor e using a n y
A soft sponge or a commercially free mic rofiber
Vehicle care and maintenance
su rfaces with a cotto n or or a commercially avai lable lint-free
mi cro fib er
fabri c trim with light generalized soiling can be cleaned with a commercially able cleaner.
and trim with h eavy generalized soiling should b e b y specia li sts.
Stain r
emoval
removing stains, it may be to the area around the stain as the s tai ned spot itself. Thi s is especially true if the rounding a rea is darkened by generalized the trea ted area may be lighter than the untrea ted area.
Page 330 of 541
Wheel bolt s and w heel hub threads must
use the
wit h th e jack
Fig . 184 lift point for th e jock .
first re a d and n o te the intro ducto ry infor mat io n and heed th e on page330.
T he jac k
must b e po sition ed at one o f the four lift points m arked on the ve hicl e bo d y ( tw o on each
Checkli st
Never grease or oil th e w heel bolts and the threads in the wheel hubs. The bo lt s can come
loos e w hile driving if greased or oiled, even if
tigh tened to the requi r e d torque.
Neve r loosen bolted connections on w heel
rims with bolted rim rin gs.
the w heel bolts are not tight en ed to the
p ro pe r torque, the wheel can come off the ve
hi cle whe n it is moving. E.xcessive ly
The ve hicle may only be lifte d by a jack positio ned
a t o n e o f th e four jack lift po int s.
F o r yo
ur own safety and that o f your passengers. carry out the follo wing step s in the o rder
tow in g trailer: the tr aile r from the ve hicle and park the trail er properly.
4 . Loosen the whee l b o lts o f th e w heel to be c han ged=> page 332.
5 . Find the ja ck lift
point=> fig. 184 on the ve hicle fram e tha t is closes t to the w heel to be c han ge d.
6.
up th e jack so tha t it still just fits undern eath the lift po int.
Pr actical tip s 332 333
Page 368 of 541
. . . . . . . . . . . . . . . . . . . . . . .
locking . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
locking switc h ....................
switch .................
sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 5 1
C losing ................ 51
Eme rgen cy clos ing . . . . . . . . . . . . . . . . . . 324
Malfun ction ............ 0............ 51
Opening ............... pro tec tion .......... 52
was her .. o o o
windows .
One-to uch closing an d openin g ........ 49
Opening ...... 49
pro tec tion ...
Switch es ................
.......... o 176
Adding e ng in e oi l. ............ ....... 249 C heckin g engin e coolant leve l . . . . . . . . 255
Checking engin e oil leve l. 249 Light bulb re p lace ment .. 346
T ire m obilit y set ..................... 338
Topping off en gin e c ool ant. . . . . . . . . . . 255 Vehicl e battery ............
331
Workin g in the engine compartment .. 245
activities Befo re every trip .........
.... 172
Q
Que ry ing a service message ..... o
R
Rain sensor ..... ........ .... 13 1
Malfun ctio n .............. .. 13 1
Raising the vehicle
Witl1wor ksho p hoi
st. ......
Raising vehicle
Workshop hois t
.................
Reading light ............... 125
Rear Assist. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
212
Operating in structi ons ..... ...... 211
. ..... .......
consid era ti o ns ........... 2 12
Rear backrest
F olding forward .. 143
Rear hatch ........... 45
C losing .............. ................ 47 Driving with an open rear hatch . 139
Eme rgency lockin g and unlocking . . . . 324 Locking ................... 39, 47
Opening ......... 46
U nl ocking .. o o o 39
Warn ing light . . . . . . . . . . . . . . . . . . . . . . . . 46
Rear seat ...... 143
Folding back into place . . . . . . . . . . . . . . 143
Rear window d efogger ..
234
A t th e gas statio n .................... 234 C hecks w hil e ref uelin g .........
237 Fue l gauge. . . . . . . . . . . . . . . . . . . . . . . . . . 235
Indicator light ............ o 235
R elease butto n . o 183
Remote control k eys
see Vehi cle keys ..
............. o
Labe ls. 311 Workshop ho is t ...... .. ..
Replac em ent ke ys
see Vehicle keys .................
Replacing parts ........
Reporting