parking brake VOLKSWAGEN TRANSPORTER 1990 T4 / 4.G User Guide

Downloaded from www.Manualslib.com manuals search engine
VEHICLE OPERATION

For
best roadability adjust your load to the
maximum allowed tongue load. To be sure

measure
tongue load of loaded trailer on
bathroom
scales.

Check
that
both sides of your trailer can be

seen
from the driver's seat. If necessary in­
stall extended rear-view mirrors.

Check
proper working of vehicle and
trailer lights.

Check
cold
tire
pressure of both vehicle

and
trailer.

Be
sure trailer safety chains are properly

connected
from trailer to the hitch on the

vehicle.
Leave enough slack in the chains
to permit turning corners.

Trailer
towing
tips
Your
vehicle handles differently when tow­ ing a trailer because of the additional
weight. Safety, performance and economy
will greatly depend on how carefully you
load
your trailer and operate your "rig."
Before
you actually tow your trailer, prac­
tice turning, stopping and reversing in an
area
away from
traffic
until
you learn the
feel of your vehicle and trailer
unit.

Reversing
is
difficult
and requires practice.

Steering
while reversing is generally oppo­
site of
that
when backing your vehicle with­
out a trailer.

Observe
speed limits. In some areas

speeds
for vehicles towing trailers are lower than for regular vehicles.
Maintain a greater distance between your

vehicle
and the one in
front.
You will need more room to stop.

When
passing remember
that
you cannot
accelerate
as fast as you normally would

because
of the added load. Make sure you
have
enough room to
pass.
After passing
allow plenty of room for your trailer before

changing
lanes again.

Avoid
jerky starts or sudden acceleration.
Slow
down in crosswinds and on rougi"

roads.
Be especially carefull when
pas­

sing
other vehicles and trucks.

When
parking always block the wheels o: both vehicle and trailer. Do not park
with
a
trailer on a slope. If it cannot be avoided dc
so
only after the following:
• Apply brakes.
• Have someone place wheel blocks
under both vehicle and trailer wheels.
• With wheel blocks in place slowly re­

lease
brakes
until
wheel blocks absorb the

load.

• Apply parking brake.
•
Place
transmission in
"P"
for automatic
or in
first
or reverse gear for manual trans­
mission.

74


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
OPERATION

WARNING continued
•
The permanently engaged allwheel-
drive
will
provide
good
performance on relatively wet or slippery
roads.
Be
sure
to use these features and advantages
wisely. Do not let the excellent traction
which your VW
SYNCRO
offers lead

you
to underestimate the difficulties
and risks involved in negotiating wet or
slippery
roads. Always drive defen­

sively
and adapt vehicle operation and
driving speed to road and
traffic
condi­

tions.
Driving Off-Road
WARNING
The Vanagon/Transporter
Syncro
is not an off-road or all
terrain
vehicle. Use of
this or any other vehicle under off-road
conditions
requires special skills and knowledge. The off-road operation of
this or any other
vehicle
can
lead
to per­
sonal
injury.

•
Driver and all
passengers
must
wear

safety belts at all times.

•
Keep your thumbs and fingers on
the outside of the steering wheel.
Potholes
or rocks can
jerk
the
wheel

from your grip; it really hurts if a spoke
catches
you on the way around.

Off-Road
Driving
Driving off-road places extra demands
on

your vehicle and on you, the driver.
If
under

exceptional
circumstances
you
judge
it

safe
and
appropriate
to
leave
the
paved highway,
first
make sure
that
your vehicle

is
in top
mechanical condition. Make cer­

tain
that
all
vehicle systems
are
function­ ing normally,
in
particular,
for
example,

that
the engine, especially the cooling
sys­

tem,
is
operating properly and
that
trans­
mission,
brakes and steering are function­ ing normally. Tires must have adequate

tread,
be
free
of
damage
and be
adequately inflated.

Before
driving over
difficult
terrain, such as

mud,
sand,
water, snow
or
steep
slopes,

we recommend engaging
the
differentia lock*
at low
speed.
Important
information
regarding
the
differential lock
is on
page

33/34.

Whenever
you
operate your
car you
should
be
well
and fit, but
your physical

and
mental condition
are
especially
im­

portant
when driving
off
the road.

As
a
general rule
you
should
go
only where others have gone before.

Always
obey applicable
Federal,
State
and
local regulations
and
above
all re­

spect
and protect the environment. Do
not

scar
the
land, avoid unnecessary wheel
spinning and other driving behavior which

will
create
ruts
and destroy vegetation.
Be

careful when parking and when standing

with
a hot
engine. The catalytic converter

with
which your vehicle
is
equipped devel­

ops
very high temperatures which can set
dry grass and brush
on
fire. Respect
the

wildlife, leave animals
to
themselves
and

do not destroy their areas
of
refuge. Above
all,
be
considerate and operate your vehi­

cle
sensibly and safely. Nature
is a
natural
resource
which belongs
to
all
of
us.
'where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE OPERATION

I'iving
off-road on Steep Inclines
I Sidehills
Before reviewing how to drive up steep
• s and along sidehills, make note of an -oortant point. If you don't make it to the

co.
or your vehicle is about to slide or roll
= :eways,
turn
off the engine, put it
into

I
'3t
gear, put on the parking brake and get

W
on the uphill side and walk down. An
:^nce
of prevention is
worth
a pound of i.re.
Steep
Inclines
When preparing to climb a steep incline,
first
find out whether you can make it. If
necessary,
walk the course. Be sure there

is
enough clearance on all sides of the ve­
hicle to avoid damage. If you have the
slightest doubt don't try it! It is always a
good idea to make a
trial
run to get the feel
of the surface and how much
effort
is
needed.
Go straight uphill. When the tires
begin to
spin,
apply a
little
extra gas and let
them dig in slightly. Step on the brakes
while you shift
into
reverse and drive straight back down. That's
right
- in re­

verse
gear, clutch out and driving.
Abso­
lutely not in neutral and
trying
to let your­
self down on the brakes. To avoid sideroll remember never
turn
your vehicle
side­

ways on a hill or steep incline.
On
your attempt, give yourself a running
start. Accelerate to the hill and then,
just

as
you approach the top,
ease
off the gas
to slow down.
When driving down, keep the vehicle heading straight downhill in low gear and
under control. If it begins to slide, don't lock up the brakes. You can't steer a
skid­

ding wheel. Touch the gas instead to
straighten your car out.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE

ENGINE
COMPARTMENT LID

mu
have access to the engine compart-

•Mit
lid from inside the luggage compart- -ent.

"lb
open the
lid,
roll the floor covering out of
~9
way and
turn
both lock handles to the
Tb close the lid, reverse the above proce- ;jre.
ENGINE
COMPARTMENT
Always exercise extreme caution when
working on the engine. WARNING
•
Before you check anything in the en­
gine compartment, stop the engine,
fully set the parking brake and remove
the ignition key.

•
Do not work on
your
car if you are
tired or ill, under emotional stress or under influence of drugs, medication
or alcohol.

•
Always let the engine cool down. Hot
components will burn skin on contact.

•
Do not spill engine oil, ATF, brake

fluid,
antifreeze and washer solvent on hot engine components, especially not
on the exhaust system.
These
fluids
are
flammable.

•
Always disconnect the battery
ground strap if you must work on the

fuel
system or the electrical system.
Never
smoke or work near heaters or
other fire hazards if you must work
around
fuel.
Always keep an approved
fire extinguisher immediately
avail­
able.
Be
especially careful if engine is run­

ning:

•
If work must be done with the engine
running, always fully set the parking

brake,
and make sure the shift lever is
in Neutral (Manual transmission) or

Park
(Automatic transmission).

•
Always be alert and extremely
cau­

tious around the engine at
all
times par­
ticularly when the engine is running.

•
Always exercise extreme caution to

prevent
neckties,
jewelry,
long hair or
loose clothing from getting caught in
the fan blades, the V-belts, or any other
moving
engine parts.

•
To avoid electrical shock and per­

sonal
injury
never
touch ignition ca­
bles
or components of the high voltage
electronic ignition system while the en­
gine is running or even when starter is

cranked.

97


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE
AUTOMATIC TRANSMISSION FLUID / MANUAL TRANSMISSION OIL
Automatic Transmission Fluid
The torque converter and the transmis­
sion are lubricated with Automatic Trans­ mission Fluid (ATF).
The final drive requires hypoid oil SAE 90,
which does not have to be changed.
Checking the ATF level
The ATF has to be checked at frequent intervals, for instance, when the engine
oil is being checked or at least at the intervals specified in your Maintenance
booklet.
Always heed WARNINGS on page 97. A correct ATF level is very important for
transmission operation.
To obtain an accurate reading, the
vehicle must be on level ground, and the
fluid must have reached operating
tem­

perature. Normally, after a cold-start the
fluid will reach operating temperature when the vehicle has been driven for ab­
out 6 miles or 10 km. If the ATF is too cool
or too hot, the fluid level reading will be inaccurate.
WARNING Before checking the ATF, the selector
lever must be securely locked in the Park position and the parking brake ap­
plied firmly.
Checking the ATF level is potentially hazardous because the hot engine has
to be running during the check. Do not
attempt to check the ATF before read­ ing all WARNINGS on page 97.
The ATF filler neck is in the engine com- partement on the left hand side. The dip­
stick is attached to the
plug.
Pull it out
and wipe clean first before inserting it to
take a reading. The Automatic transmission may be da­
maged by even a tiny speck of dirt.
Only use lint free rags to wipe the dip­
stick.
To get a true reading, the ATF must be at operating temperature.
You have enough ATF if the fluid level is between the two marks on the dipstick. I:
should never be above or below these marks. If level is too high or too low do not
just add or drain ATF. Have your dealer check and correct the cause as soon as possible.
For correct ATF specifications, see "Lub­
ricants" on page 85.
Changing the ATF
The ATF has to be changed at the inter­ vals specified in your Maintenance boo­klet.
Do not tow the vehicle or run the engine
without ATF in the transmission.
Manual Transmisson Oil Both transmission and final drive are
combined in one housing. The lubrican: used is hypoid oil which does not have tc
be checked or changed. If you shoulc
suspect a leak, contact your VW dealer.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
HANGING
AWHEEL

DO-IT-YOURSELF-SERVICE

WARNING
•
If you have a flat tire, move a safe

distance
off the road.
Turn
off the
engine, the emergency flasher on and use other warning devices to alert
other motorists.

•
Passengers must not remain in the
vehicle when it is
jacked
up.

•
Make
sure that passengers wait in a

safe
place away from the vehicle and

well
away
from
the roadway
and
traffic.

•
Before you change a wheel, be sure
the ground is level and
firm.
If neces­
sary, use
a
board under the jack.

•
Set the parking brake and block the
wheel opposite the defective wheel on
the other side of the vehicle. Engaging

a
gear or placing the Automatic trans­
mission
selector lever in P (Park)
posi­

tion is not a substitute for fully setting
the parking brake.
Stepl

•
Take out the bag with jack and tools
from under the driver's seat.
Step 2
•
With the wheels
still
firmly resting on
the ground, remove the hub cap/wheel
cover of the defective wheel. Wheels with wheel cover

(left
illustration)

•
The wheel cover can be pulled off with
puller clip and lug wrench.
Wheels with hub cap
(right
illustration)

•
Remove chrome plated hub cap with
puller clip and lug wrench.
Insert
clip in
holes at rim of a hub cap. Put wheel
wrench through
clip,
brace one end of
wrench on wheel rim and pull lightly on
other end.
When you place the hub cap face down, you can use it as a
tray
for lug bolts
(front

wheels) or lug nuts
(rear
wheels).

125


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF-SERVICE

EMERGENCY
STARTING

Starting by
pushing
or towing

Vehicles
with
Automatic Transmission
cannot
be started by
pushing
or
towing.

Vehicles
with
Manual
Transmission
must
not
be started by
pushing
or
towing.

Damage to the catalytic converter and/or
other parts of the vehicle may result. Starting
with
jumper
cables

WARNING
•
Always shield your eyes and avoid
leaning over the battery whenever
pos­

sible.

•
Do not allow battery acid to contact

eyes
or
skin.
Flush any contacted area

with
water
immediately.

•
Improper use of booster battery to
start a vehicle may
cause
an
explosion.

•
Vehicles batteries generate explo­

sive
gases.
Keep sparks, flame and lighted cigarettes away from batteries.

•
Do not charge a frozen battery; allow
it to thaw out first. Gas trapped
in the ice may cause an explosion.

•
Do not try to jump start any vehicle

with
a low electrolyte level in the bat­ tery.

•
The voltage of the booster battery
must also have a 12-volt rating. The

capacity
(Ah) of the booster battery

should
not be lower than
that
of the
dis­

charged
battery. Use of batteries of dif­
ferent voltage or substantially different

Ah
rating may cause an explosion and
personal
injury.
•
Applying
a
higher
voltage
booster

battery
will
cause
expensive
damage
tc

sensitive
electronic
components,
such
as
relays,
radio,
etc...

•
Vehicle
with
discharged
battery: turn off

lights
and
accessories,
move
lever
to N or

P
(Automatic
transmission)
or into
Neutra

(Manual
transmission)
and set
parking

brake.

Always
heed WARNINGS on page 97.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
TECHNICAL
DESCRIPTION

FRONTWHEEL SUSPENSION
• Independent upper and lower control
arm
• Stabilizer
•
Coil
springs • Shock absorbers
Syncro • Independent wheel suspension by

means
of double wishbones
with
coil
springs and telescopic shock absorbers.
• Double
jointed
shafts
• Stabilizer bar
•
Viscous
coupling

Steering
•
Rack
and pinion
• Safety steering column REAR WHEEL SUSPENSION
• Independent semi-trailing arms
with

integrated axle support
•
Coil
springs
• Shock absorbers
Syncro • Independent wheel suspension by way
of diagonal arm axle
with
coil springs and

telescopic
dampers.
• Double
jointed
drive shafts
• Differential lock as optional extra.
BRAKES

• Hydraulic dual-circuit power-assisted
brake system
with
pressure regulator for rear wheel circuit. Front wheels
with
disc

brakes,
rear wheels
with
self-adjusting
drum brakes.
• Parking brake for rear wheels.
Body/Chassis • All steel unitized body
• Frame plates reinforced
with
side and

cross
members.

143


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL INDEX
page
Introduction 2
Instrument illumination 46
Instrument panel 4 Instruments 40
Interior light 63,133
Jack and tools 123 Jack points 126
Keys 7
Kickdown 37
Lane changer 48
License plate lights 133 Lifting vehicle 140
Light switch 46 Light alloy wheels 92
Lights 46,130
Locks 7
Lubricants 98
Luggage compartment 28
Maintenance 95
Maintenance booklet 2
Manual Transmission 32 Manual Transmission Oil 102
Mirrors 13
Notes to owner 2 page
Octane rating 86
Oil change 100
Oil filter changing 101 Oil pressure warning light 43
OXS (Oxygen sensor) 144
Parking 31,145
Parking brake 31 Pedals 29
Power steering 103
Power windows 12
Radio 5, 135
Rear lid 11 Rear seat bench/bed combination 26
Rear view mirrors 13
Rear window defogger 47
Rear window wiper/washer 50
Refill Tank 105
Reverse 32
Roof rack 68
Safe driving hints 70
Safety belts 14
Safety belts warning light 18
Safety compliance sticker 151
Seats 20 Secondary heat exchanger 53
Selector lever 35 page
Service manuals 152 Side marker lights 132
Sliding door 10 Sliding roof 62
Sliding windows 12
Snow chains 119 Spare wheel 124
Spark plugs 146
Speedometer 40
Speed ranges 69
Starter switch 38 Starting procedures 39
Steering lock 38
Stopping engine 39
Sunroof 62 Sun visors 67
Switches 46
Swivel seats 22 Syncro Differential lock 33
Driving with the-all-wheel-drive . . 75
Snow chains 119
Technical Information 142 Towing 139
Tachometer 41
Tail lights 132
Technical data 146


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans