fuel reserve VOLKSWAGEN TRANSPORTER 1990 T4 / 4.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

WARNING continned •
The
engine compartment
of any

motor vehicle
is a
potentially hazard­
ous
area.
Before you check anything in the engine compartment, stop
the

engine and
let it
cool down. Always
exercise extreme caution when work­
ing
one the
engine. Heed
all of the

WARNINGS on page
97.

Reduce the risk
of
scalding from
hot

coolant by following these steps.
• If the coolant reservoir cap must be
removed, wait until
the
engine
has

cooled down.
• Protect face, hands
and
arms
by

covering
the cap
with
a
large, thick
rag
to
protect against escaping fluid
and
steam.

• Carefully and slowly
turn
cap
one

turn
to
allow excess pressure
to es­
cape before completely removing

cap.

•
To
help avoid being burned,
do not

spill
antifreeze
or
coolant
on the ex­

haust system
or hot
engine parts.
Under
some conditions, the ethylene
glycol
in
engine coolant
is
combusti­
ble.
If a
visual check shows that coolant level
and V-belt
are
normal,
but the
warning light continues to
flash,
contact
your
near­
est dealer
to
have
the
cause located
and

corrected.
For more details see "Cooling system"
on

page 104.

If the
coolant gauge needle nears
the

upper end
of
the scale and the engine ap­
pears
to be
overheating,
turn
off the air

conditioner.
Do
not
install accessories
(fog
lights
or
in­
sect screens,
for
example)
on top of the

front
bumper.
They
may
restrict engine
cooling.
5
-
Fuel gauge
The needle
in
the fuel gauge will indicate the fuel level
in the
tank shortly after
the
ignition is switched on.
The fuel tank capacity is
16
gal/60
(syncro
18.5/70)
liters.
When
the
needle reaches the
red
area
at
the bottom there
is a
reserve
of
about 2.6 U.S. gal.
or
10 liters
of
fuel left in the tank.
Time to refuel.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE
=UELTANK
|he fuel filler neck is located above the -gnt
front
wheel. Syncro model: above the
-;nt rear wheel.
mm key A (see page 7) is used for the lock-
acle
tank cap. The syncro model has a separate key for the lockable tank cap.
capacity of the tank is 16.0 gal/60

:ers
(Reserve is 2.5 gal/10 liters of
total

rapacity).
5/ncro model: 18.5 gal/70 liters (Reserve

2
5 gal/10 liters of
total
capacity). Trouble-free refueling depends on the cor­
rect use of the filler nozzle.

Always
insert the nozzle fully
into
the fuel filler neck, to completely open the spring-loaded flap located
just
below the filler
neck opening. Make sure the filler nozzle

is
not tilted.

Do
not
fill
the fuel tank too quickly, other­
wise the fuel may foam up and cause the
nozzle
to switch off too
soon.

As
soon as the nozzle switches off auto­ matically for the
first
time, the tank is full.
Do
not try to add more fuel, because the

expansion
space in the fuel tank will be
filled - the fuel can then overflow when it
becomes
warm.
WARNING

Never
carry
additional
fuel
containers

in
your
vehicle.
Such
containers,
full
or

empty,
may
leak,
cause an explosion,
or
result
in
fire
in case of a collision.

85


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
TECHNICAL DATA

V-BELTS
CAPACITIES
for waterpump/alternator. 9.5 x 1100 LA
Fuel
tank 16.0 gal/60 liters
for A/C compressor . . . 12.5x1153 LA Syncro:
for power steering .... 9.5 x 1080 18.5 gal/70 liters Noteg
Reserve
(of
total
capacity) >. .. 2.5 gal/10 liters
The V-belts are among the most severely Coolin3
sVstem186
^t/17-5 ll,ers
stressed
parts of a vehicle. The belts there- Automatic
fore have very high quality requirements. transmission fluid (ATF) 3.2 qt/3.0 liters
When replacing a belt, it is not sufficient to Windshield washer container 4.3 qt/4.2 liters
use
just
any belt of the same
size.
For safe
operation, use only Original Volkswagen
Rear
window washer container 1.1 qt/1.0 liters

V-belts
specially designed for your Engine oil

vehicle.
The correct belts can be obtained
with
filter
change 4.8 qt/4.5 liters at your Volkswagen dealership.
without
filter
change 4.2 qt/4.0 liters

Do
not
fill
above "max" mark.
The oil level should be checked while topping up.
Difference between "min" and "max" marks
on the dipsticks is approx. 1 qt/1 liter


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans