trunk VOLVO 240 1990 Owners Manual

Volvo 1990 240 Model
pg. 6 240 DL Sedan
pg. 7 Before you drive
pg. 8Instruments and controls
pg. 10Instruments
pg. 11Warning lights
pg. 12Clock, ambient temperature gauge
pg. 13Oil pressure gauge, voltmeter
pg. 14Ignition switch, turn signals
pg. 15Lighting
pg. 16Windshield wipers, washer nozzles
pg. 18Washer fluid reservoir
pg. 18Rear window demister, heated seat, hazard warning flasher
pg. 19Parking brake
pg. 20Cigarette lighter, ash trays
pg. 21Electrically operated windows
pg. 22Heating and ventilation
pg. 24Air conditioning
pg. 25Audio systems
pg. 26Child safety
pg. 28Seat belts
pg. 30SRS (Supplemental Restraint System)
pg. 32Doors and locks
pg. 33Trunk lid
file:///K|/ownersdocs/1990/1990_240/90240_01.htm (1 of 5)12/30/2006 8:\
25:01 AM

Volvo 1990 240 Model
NOTE: The driver's door can only be locked using the
key.

The lock buttons should not be In the down (locked) position during dr\
iving. In case of an accident, this
may hinder rapid access to the occupants of the vehicle.



Child safety locks

The buttons are located on the rear door jambs.
A The lock functions normally.
B The door cannot be opened from the inside.
WARNING: In the event of an accident, the rear seat passengers cannot op\
en the doors from the inside
with the buttons in position B.

Wagon model contains child safety lock on tailgate. The lock differs fro\
m that shown above. See section
titled "Wagon, tailgate".
pg. 33 Trunk lid/light
file:///K|/ownersdocs/1990/1990_240/90240_07.htm (2 of 6)12/30/2006 8:\
25:04 AM

Volvo 1990 240 Model


Trunk lid

The trunk lock is incorporated in the central locking system. This means\
that you can either lock or
unlock the trunk by means of the drivers door lock.
You can also operate the trunk lock directly with the owner's key even i\
f the vehicle is centrally locked.


Unlocking Locking

Withdraw key in vertical position

The trunk lock can also be disconnected from the central locking system \
by turning the key
counterclockwise as shown below:

Withdraw key in horizontal position
The trunk is now always locked.
This option can be used if for example, you lend your car to somebody. I\
f you give only the service key
to the driver it will not be possible to open the trunk.
file:///K|/ownersdocs/1990/1990_240/90240_07.htm (3 of 6)12/30/2006 8:\
25:04 AM

Volvo 1990 240 Model
To reconnect the lock to the central locking system:

Withdraw key in vertical position



Trunk light

A Light always off.
B Light on when trunk lid is open.
pg. 34 Hood, Long load storage


To open the hood
file:///K|/ownersdocs/1990/1990_240/90240_07.htm (4 of 6)12/30/2006 8:\
25:04 AM

Volvo 1990 240 Model
l It is necessary to balance trailer brakes with the towing vehicle brakes\
to provide a safe stop (check
and observe State regulations).
l More frequent vehicle maintenance is required.
l Remove the ball and drawbar assembly when the hitch is not being used.
l Increase tire pressure to recommended full-load pressure. See section 'W\
heels and Tires."
Note: Refer to section entitled "Automatic transmission" for additional \
trailer hauling
tips.
Warning: Do not drive with trunk lid or tailgate
open!

Poisonous exhaust gases may enter via the open trunk lid or tailgate. (\
This is especially true for wagon
models.)
If the trunk lid or tailgate for any reason must be open, proceed as fol\
lows:
l Close the windows.
l Set the heating system controls for floor and defroster to max. and the \
blower to full speed (4). See
section titled "Heating and Ventilation".

Handling, roadholding

Vehicle load, tire design and inflation pressure are important for prope\
r handling. Therefore check that
the tires are inflated to the recommended pressure according to the vehi\
cle load.
Loads should be distributed so that capacity weight or maximum permissib\
le axle loads are not
exceeded.
It is recommended to use tires of the same make and dimensions on all fo\
ur wheels.

Warning: Do not mix radial ply and bias ply tires as this will adversely\
alter the vehicle handling
characteristics.

Roof rack

Permanent and removable roof racks are available from Volvo Accessories.\

file:///K|/ownersdocs/1990/1990_240/90240_11.htm (2 of 6)12/30/2006 8:\
25:06 AM

Volvo 1990 240 Model
Trunk, hood hinges
and latches L
L L L L L L

1) For services beyond 60,000 miles (96,000 km), consult your "Mainte\
nance Service Chart".




Contents | Top of Page
file:///K|/ownersdocs/1990/1990_240/90240_12.htm (7 of 7)12/30/2006 8:\
25:07 AM

Volvo 1990 240 Model
Fluid type: DOT 4
Replace: every 2 years or 30,000 miles (48,000 km).

Check, without removing the cap, that the level is above the "MIN" mark \
of the fluid reservoir.
Always entrust brake fluid changing to a Volvo dealer.
Change brake fluid every year when driving under extremely hard conditio\
ns (mountain driving etc.)
and if the car is equipped with a non factory air dam. pg. 73 Body Lubrication


Chassis maintenance

To simplify maintenance, your Volvo has been equipped with ball joints s\
teering rods and propeller
shafts that do not require regular lubrication Points that normally requ\
ire lubricating have been packed
with very durable grease at the factory and then carefully sealed, elimi\
nating the need for subsequent
lubrication.

Lubricate body

To avoid rattles and unnecessary wear, the body should be lubricated onc\
e a year. Hinges on hood, doors
and trunk lid as well as door stops should be lubricated every 10,000 mi\
les (16,000 km).

file:///K|/ownersdocs/1990/1990_240/90240_15.htm (5 of 10)12/30/2006 8\
:25:09 AM

Volvo 1990 240 Model


Door hinges (lower) and door stop

A grease B oil

No. Lubricating point Lubricant
1 Trunk lid lock keyhole Low temperature grease
2 Trunk lid hinges Oil
3 Door lock keyhole
outer sliding surfaces Oil
4 Sunroof wind deflector Oil
5 Hood hinges Oil
6 Hood lock Oil
7 Front seat slide rails
and latch devices Oil
8 Window regulator Oil, grease
Locking device Silicon grease
(Accessible after door
upholstery panels
removed)
9 Door hinges Grease
Door stop Oil
pg. 74 Cooling system
file:///K|/ownersdocs/1990/1990_240/90240_15.htm (6 of 10)12/30/2006 8\
:25:09 AM

Volvo 1990 240 Model

All tail lamp bulbs are replaced from inside of trunk.
1 Unscrew and remove tail lamp inside cover. Note that inside cover is h\
ooked at the upper edge. Lift
the lower end out up and unhook upper edge.
2 Turn bulb holder approx 3,8" (1 cm) counterclockwise and remove it. \

3 Depress bulb n bulb holder turn it slightly counterclockwise and remov\
e it.
4 Install a new bulb Install bulb holder in tail lamp.
NOTE: One of the bulb holder tabs is wider and fits only in correspondin\
g
recess.

Turn bulb holder clockwise. Check that bulb lights Replace tail lamp ins\
ide cover.


Power
Power
Bulbs CP W Socket US Bulb
No
1 Rear fog light 32 21 Ba 15s 1156
2 Back-up light 32 21 Ba 15s 1156
file:///K|/ownersdocs/1990/1990_240/90240_16.htm (3 of 10)12/30/2006 8\
:25:10 AM

Volvo 1990 240 Model
stop light pg. 80 Replacing bulbs


Interior light

Insert a screwdriver through the opening in the right side of the housin\
g and depress the catch tab. Pull
out the housing assembly and replace the bulb.

Bulb Power Socket
Interior light 10 W S 8.5 - 8



Engine compartment light, Trunk light
file:///K|/ownersdocs/1990/1990_240/90240_16.htm (8 of 10)12/30/2006 8\
:25:10 AM