ECU VOLVO 850 1996 User Guide

1996 Volvo 850
l Fold the cushion back to a nearly horizontal position
l Lift out the cushion

WARNING! Do not place extremely heavy articles against the front seats, \
as the backrest which is
folded down is then placed under severe strain.
Be sure to secure cargo. Hard and sharp articles could otherwise damage \
the frontseat backrest and/or
cause injury to passengers in the event of rapid braking or a collision.\

pg. 2:19 Concealed storage bin (wagon)

file:///K|/ownersdocs/1996/1996_850/96850_218.htm (2 of 7)12/30/2006 9\
:59:25 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

The luggage net helps prevent cargo and animals from being thrown forwar\
d should the vehicle stop
suddenly or be involved in an accident. The luggage net unreels from the\
rear upped edge of the rear seat
backrest.
The luggage net must be accessed from the cargo storage area.

1 Open the cover on the passenger side seat back and pull the luggage ne\
t toward you.
2 Hook the rod onto the bracket on the right side ceiling.
3 Pull out the left side of the rod and attach it to the bracket on the \
driver's side ceiling.
4 Unreel the driver's side luggage net.
5 Hook it to the rod.
6 Make sure the nets are securely attached to the hooks under the covers\
and pulled taut.
Use the reverse procedure procedure to retract the net.

The luggage net can also be used when the rear seat is folded down. Howe\
ver, extra brackets (optional)
must be installed on the upper front door hand grips. pg. 2:21 Securing cargo

Eyelets in trunk (sedans)

Securing cargo
file:///K|/ownersdocs/1996/1996_850/96850_218.htm (4 of 7)12/30/2006 9\
:59:25 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

As a safety precaution, your car is equipped with four eyelets (six on \
wagons) to which straps can be
attached to secure luggage.


Eyelets inside car (sedans/wagons)
WARNING! The eyelets are not to be used as passenger restraints or as an\
chorages for child restraints.
See page 3:9.
Station wagons only:
Unless the station wagon is equipped with Volvo's auxiliary seat for chi\
ldren (option) passengers
should not ride in the rear cargo area.

Station wagons only:
If the optional auxiliary seat for children is in use, fold this seat do\
wn before folding down the rear seat
backrest.

file:///K|/ownersdocs/1996/1996_850/96850_218.htm (5 of 7)12/30/2006 9\
:59:25 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
l Move the seat as far forward as possible
WARNING! Cover sharp edges on load to help prevent injury to occupants. \
Secure load to help
prevent shifting during sudden stops.



Long load storage (sedans)

There is a flap located in the panel behind the rear seat which makes it\
possible to carry long loads such
as skis, etc. To open, pull the strap forward.
Protective covers (for skis) should be used to avoid soiling or tearin\
g the upholstery. Please note that the
flap in the rear seat is only intended for light loads such as skis, car\
pets, etc.
Max length: 6 1/2 ft (2 meters) Max weight: 55 lbs (25 kg)
WARNING! Always turn engine off and apply parking brake when loading/unl\
oading the vehicle.
Place transmission selector in P (PARK) position to help prevent inadv\
ertent movement of selector.




Contents | Top of Page
file:///K|/ownersdocs/1996/1996_850/96850_218.htm (7 of 7)12/30/2006 9\
:59:25 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 3:9 Child safety

Child Restraint Anchorages

Volvo cars can be fitted with Child Restraint Top Tether Anchorages in t\
he rear seat.
Sedans: There are three pre-drilled anchorage points under the rear wind\
ow shelf which are not visible from the passenger
compartment.
Wagons: The anchorage points are on the rear seat backrest and are hidde\
n by plastic covers. The backrest must be folded down to
access the center anchorage point.

In cars designated for Canada, one top tether anchorage set will be in t\
he glove box.

Installing the top tether

Sedans: The pre-drilled holes for the child restraint anchorages are und\
erneath the rear window shelf and can be accessed from the
trunk or by lowering the rear seat backrests.
Wagons: Remove the plastic cover on the anchorage point you intend to us\
e.

On either model, refer to the child seat manufacturer's instructions for\
securing the seat.

An additional bolt may be required. This may be obtained from your autho\
rized Volvo retailer.
WARNING! Child Restraint Anchorages are designed to withstand only those\
loads imposed by correctly fitted Child Restraints.
Under no circumstances are they to be used for adult seat belts or harne\
sses. The anchorages are not able to withstand excessive
forces on them in the event of collision if full harness seat belts or a\
dult seat belts are installed to them. An adult who uses a belt
anchored in a Child Restraint Anchorage runs a great risk of suffering s\
evere injuries should a collision occur. Do not install rear
speakers which would require the removal of the top tether anchors or in\
terfere with the proper use of the top tether strap.
file:///K|/ownersdocs/1996/1996_850/96850_309.htm (1 of 7)12/30/2006 9\
:59:30 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 3:10 Child safety

Integrated booster cushion (certain models)

Volvo's own integrated booster cushion has been specially designed to he\
lp safeguard a child seated in the center position of the rear
seat. When using the integrated booster cushion, the child must be secur\
ed with the vehicle's three-point seat belt. The booster
cushion is approved for children weighing between 22.7 and 36 kg (50 an\
d 80 lbs) and between 117 and 137 cm (46 and 54 in ) in
height. It is not intended for children under 3 years of age.

With the child properly seated on the booster cushion (see illustration\
), adjust the head restraint to support the child's head (
see page
3:3). The hip section of the three-point seat belt must fit snugly across \
the child's hips, not across the stomach.
The shoulder section of the three-point seat belt should be positioned a\
cross the chest and shoulder (see illustration). The shoulder
belt must never be placed behind the child's back or under the arm.
WARNING! Failure to follow the instructions on this page will increase t\
he risk of your child being injured during a sudden stop
or collision.
In the event of a collision while the integrated booster cushion was occ\
upied, the entire booster cushion and center seat belt must
be replaced. The booster cushion should also be replaced if it is badly \
worn or damaged in any way. This work should be
performed by an authorized Volvo retailer only. The booster cushion shou\
ld be cleaned while in place if the vehicle if possible. If
not, please consult your Volvo retailer.

file:///K|/ownersdocs/1996/1996_850/96850_309.htm (2 of 7)12/30/2006 9\
:59:30 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
WARNING! Both rear seat backrests must be up when the auxiliary seat is \
being
used.
Do not use a booster cushion or child seat in conjunction with the auxil\
iary seat.


Spool-out

To make child seat installation easier, each seat buckle (except for th\
e driver's belt) is equipped with a locking mechanism to help
keep the lap section of the seat belt taut.

When attaching the seat belt to a child seat:
l Make sure the red lock button is moved to the right (see illustration A\
). A coin, etc. can be used to move the button.
l Attach the seat belt to the child seat according the child seat manufact\
urer's instructions.
l Pull the lap section of the seat belt taut.

The lap section of the seat belt cannot be loosened as long as the red l\
ock button is in the right position.
The lap section of the seat belt can be adjusted when the lock button is\
in the left position (see illustration B).

NOTE: Before exiting the car, check that the seat belt retracts fully af\
ter being unbuckled. If necessary, guide the belt back into the
retractor slot. When not in use, the child restraint should be secured w\
ith the seat belt to help prevent movement during a sudden
stop.
WARNING! Do not use child safety seats or child booster cushions/backres\
ts in the front passenger's seat. We also recommend
that children who have outgrown these devices sit in the rear seat with \
the seat belt properly fastened.
pg. 3:12 Child safety
Child safety

Volvo recommends the proper use of restraint systems for all occupants i\
ncluding children. Remember that, regardless of age and
file:///K|/ownersdocs/1996/1996_850/96850_309.htm (4 of 7)12/30/2006 9\
:59:30 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
size, a child should always be properly restrained in a car.

Restraint systems for children are designed to be secured in the vehicle\
by lap belts or the lap portion of a lap-shoulder belt. Such
child restraint systems can help protect children in cars in the event o\
f an accident only if they are used properly. However, children
could be endangered in a crash if the child restraints are not properly \
secured in the vehicle. Failure to follow the installation
instructions for your child restraint can result in your child striking \
the vehicle's interior in a sudden stop.

Holding a child in your arms is NOT a suitable substitute for a child re\
straint system. In an accident, a child held in a person's arms
can be crushed between the vehicle's interior and an unrestrained person\
. The child could also be injured by striking the interior, or
by being ejected from the vehicle during a sudden maneuver or impact. Th\
e same can also happen if the infant or child rides
unrestrained on the seat. Other occupants should also be properly restra\
ined to help reduce the chance of injuries or increasing the
injury of a child.

All states and provinces have legislation governing how and where childr\
en should be carried in car. Find out the regulations
existing in your state or province. Recent accident statistics have show\
n that children are safer in rear seating positions than front
seating positions when properly restrained. A child restraint system can\
help protect a child in a vehicle. Here's what to look for
when selecting a child restraint system:
l It should have a label certifying that it meets applicable Federal Motor\
Vehicle Safety Standards (FMVSS 213-80) - or in Canada,
CMVSS 213.
l Make sure the child restraint system is approved for the child's height,\
weight and development - the label required by the
standard or regulation, or instructions for infant restraints, typically\
provide this information.
l In using any child restraint system, we urge you to look carefully over \
the instructions that are provided with the restraint. Be sure
you understand them and can use the device properly and safely in this v\
ehicle. A misused child restraint system can result in
increased injuries for both the infant or child and other occupants in t\
he vehicle.
l If your child restraint requires a top tether strap, consult your author\
ized Volvo retailer for top tether anchorage and installation
information.

When a child has outgrown the child safety seat, you should use the rear\
seat with the standard seat belt fastened. The best way to
help protect the child here is to place the child on a cushion (not ava\
ilable in Canada) so that the seat belt is properly located on the
hips (
see page 3:10).
A specially designed and tested booster cushion for children between 22.\
7 - 36 kg (50 - 80 lbs) and 117 - 137 cm (46 - 54") can be
obtained from your Volvo retailer.
If necessary, an auxiliary seat for children is available for use in the\
luggage compartment of station wagon models. This seat is
designed for two children, each weighing between 23 - 40 kg (50 - 88 lb\
s.) and up to 150 cm (59 inches) in height.

WARNING!
l When using the auxiliary seat for children, both sections of the rear se\
at backrest must be secured in the upright
position
l Do not use a booster cushion or child seat in conjunction with the auxil\
iary seat.
pg. 3:13 Occupant safety
Seat belt maintenance

Check periodically that the anchor bolts are secure and that the belts a\
re in good condition. Use water and a mild detergent for
file:///K|/ownersdocs/1996/1996_850/96850_309.htm (5 of 7)12/30/2006 9\
:59:30 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Loosen wheel bolts Insert flat end of lug wrench and turn


Pull straight out

Changing a wheel

The spare wheel is located under the carpet on the trunk floor. The jack\
and crank are secured in the
wheel recess.
l Engage the parking brake.
l Put the gear selector in (P)ark (automatic) or in Reverse (manual)\
.
l Remove the wheel cap (where applicable) using the lug wrench in the to\
ol kit.
l With the car still on the ground, use the lug wrench to loosen the wheel\
bolts 1/2 - 1 turn. Turn the
bolts counterclockwise to loosen.
l Fold out the crank handle on the jack by pressing the nob on the handle \
downward. To attach the jack,
refer to the illustration on the following page.

NOTE:
To avoid excessive wear and the necessity of rebalancing, mark and reins\
tall wheels in same location
and position as before removal. To lessen the chance of imbalance, each \
wheel hub is equipped with a
guide stud to ensure that a removed wheel can be reinstalled in its orig\
inal position (as when changing
over to winter tires/wheels).

*The guide stud in not visible from the outside of the wheel on turbo mo\
dels.
file:///K|/ownersdocs/1996/1996_850/96850_601.htm (2 of 5)12/30/2006 9\
:59:39 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Bumpers: Wash the bumpers with the same cleaning agent used on the rest \
of the car. Never clean the
bumpers with gasoline or paint thinner. Difficult spots can be removed w\
ith denatured alcohol. To avoid
scratches, do not dry the bumpers with paper. pg. 7:5 Automatic car washing, Polishing and waxing
Automatic washing - simple and quick

An automatic wash is a simple and quick way to clean your car, but it is\
worth remembering that it may
not be as thorough as when you yourself go over the car with sponge and \
water. Keeping the underbody
clean is most important, especially in the winter. Some automatic washer\
s do not have facilities for
washing the underbody.

Before driving into an automatic wash, make sure that the side view mirr\
ors, auxiliary lamps, etc., are
secure, otherwise there is risk of the machine dislodging them. You shou\
ld also lower the antenna
(sedans).

We do NOT recommend washing your car in an automatic wash during the fir\
st six months (because the
paint will not have hardened sufficiently).

Polishing and waxing

Normally, polishing is not required during the first year after delivery\
, however, waxing may be
beneficial.

Before applying polish or wax the car must be washed and dried. Tar spot\
s can be removed with
kerosene or tar remover. Difficult spots may require a fine rubbing comp\
ound.

After polishing use liquid or paste wax.

Several commercially available products contain both polish and wax.

file:///K|/ownersdocs/1996/1996_850/96850_701.htm (6 of 8)12/30/2006 9\
:59:48 AMClassic Cars & Cycles www.ClassicCycles.org