cooling VOLVO 940 1982 Service Owner's Manual

70019401960 Specifications
Section
3 E lectrical System
I
960 1991
Fuse Fed by C ircuit s protecte d Fuse
960 1991
Fuse Fed by Circuit s protected Fuse nurn-rating nurn- r
ating
b er
ber
1 Light
Left
parking lights, 10 A
19 Ignition Control unit, ECC 15
A
switch Licence plate
light switch X Power
mirrors Bulb failure waring
Power seats (controls)
-outer rear lights
Tailgate wash/wipe t---2 Right
parking lights, 10 A Cigar lighter I----Bulb failure
warning 20 Horn 25
A -inner rear lights
Windshield wash/wipe
3 Main
light Left
main beam 15
A Headlight wash /wipe
relay Left auxiliary beam 21 Ignition Automatic pre-heat, diesel 5A r---4 Right
main beam 15 A switch
15 Mode selector I----Right auxiliary beam
22 ABS (control unit)
5
SRS diagnostic socket (Combined instrument not fused) 5A I----
6 Bulb failure Left dipped beam 15
A
warning , Beam length
control, left t---9-pole 7 Right
dipped beam 15
A 23
Control unit, AW 30-43 (A/power) 10 A
Control unit, fuel system Relay,
electric cooling fan
Beam length control, right (B
230/B 280)
8 Light
Foglights front
15 A Diagnostic
socket (B 6304)
r---switch
9 Foglights rear 10 A Indicator light, foglights rear -
24 Battery + Control unit, AW 30-43 10 A
(B/m emory) Control unit , fuel system
10 Lighting : 5A -Instrument panel
- Controls
-
Mode selector
-Beam length control Control
unit
, ignition system t---25 Hazard flash lights 25 A Central locking (Light switch not fused) I-----(Sun roof
26 Clock 10 A
-
ECC controls Courtesy lights
-Radio Door
warning lights
- Clock Engine compartment lighting
-Cigar lighter Trunk lighting
-Ashtray, front and rear -Shift selector scale
- Seat heating -Seat belt locks
I----27 Brake light switch 15
A Bulb failure warning sensor -brake lights P-shift inhibitor (solenoid)
11 Ignition Back-up lights 15 A
switch
151 Turn indicators
Cruise control
I----28 Heater
fan (ECC) 30 A
ECC compr essor t---t---12 Reduced
dip beam (Dim-dip) 15 A
P-shift inhibitor (control circuit) r---
29 Power antenna 30 A
Trailer (Turn indicator switch not fused)
13 Heated
rear window 25 A
Heated mirrors
t---
30 Relay,
fuel Tank pump 10 A
injection Lambda-sond
14 Exhaust
temp. warn. (Japan)
10 A
Overdrive
(M 46, AW 70/71)
Power windows (controls)
31 Battery + Relay, fuel injection 25
A -Fuel pump
Power sun roof
(controls) 32 Battery + Amplifier, radio 15
A
Heated seats (controls) Fasten seat belt reminder
I----33 Radio 10 A
Bulb
failure warning, 14-pole t---15 Reserve t---16 Reserve 3
4
Relay , power Power
windows (motors) 30 A
windows Power
sun roof (motor)
t---35 Heated
seats (power) 30 A
Power seats (motor)
17
Ignition Reserve t---switch X
18 Radio 5A (SRS
Airbag not fused)
136

(
Delco R4 Compressor
Compressor, coupling plate ................................... 14-34
Kiki Compressor
Front cover bolts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Drive
plate centre bolt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Rear cover connection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
Oil drain/filler plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
York Compressor
Compressor mounting bolts ........................ .......... .
Oil drain/filler plug ........................................... .
Pulley/clutch centre bolt. ..................................... .
Rear bearing housing
.................................. ...... .
Con rods .
.................................................. .
Lower cover
........................................ .. ...... .
Valve plate/upper cover ...................................... .
Sankyo Compressor
30
5
25-30
20
20
20-30
20-30
Oil drain plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Pulley/clutch
centre bolt. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Valve plate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Pressure sensor
(Only fitted to vehicles with D 24, D 24 T and tropic type radiator)
70019401960 Specifications
Section 8 Body and interior
10-25
16
11
16
8
22
3.5
18-22
14
14
14-22
14-22
7
27
11
Electric cooling fan engaged at pressure ....................... .
disengaged at pressure
.................... .
2.0 MPa (284 psi)
1 .7 MPa (242 psi)
Performance test
Test conditions
Bonnet . . . . . . . . . . .. closed
Doors . . . . . . . . . . . .. closed
Engine
speed. . . . .. 33 r/s (2000 r/min)
Control settings
Fan speed ........................... ...................... .
Temperature
control . ................................. ....... .
Mode
selector . ............................................. .
AC switch ............. ..................................... .
.
Recirculation switch ......................................... .
Recorded operating conditions
Ambient temp
(in front of car) 20°C (68°F) 30°C (86°F)
40°C
(104 °
F)
Temp of expelled air, measured 5-8°C 5-8°C 8-12°C
CU + AC
3
COOL
MAX
at centre panel vents
(41-46°F) (41-46 °F) (46-54°F)
ACC
Max cool
Auto Hi
ECC
5
Max cool
Vent
-In
In
143985
161
·11 lit ·11 lit ·11 lit ·11 III II