transmission oil VOLVO C70 1999 Owners Manual

CAUTION: Certain models have reduced ground clearance due to the design of the front spoiler. Please observe
caution when e.g., driving onto garage hoists, through drifted snow or when other road debris is encountered, or
when parking near curbs
©1998 Volvo Cars of North America Inc.
Shiftlock (automatic transmission only)
When your car is parked, the gear selector is locked in the (P)ark position. To release the selector from this position,
turn the ignition key to position II (or start the engine), depress the brake pedal, press the button on the front side of the
gear selector and move the selector from (P)ark.
If it is necessary to manually override the shiftlock system:
Turn the starting (ignition) key to position I
Press firmly on the "SHIFTLOCK OVERRIDE" button located near the base of the gear selector.
While holding the override button down, press the button on the front of the gear selector.
Move the gear selector from the ( P)ark position.
Keylock (automatic transmission only)
This means that when you switch off the ignition, the gear selector must be in the (P)ark position before the starting
(ignition) key can be removed from the ignition switch.
Clutch interlock (manual transmission only)
The clutch must be fully depressed before you can start you car. If the clutch is not depressed, it will not be possible to
start the engine.
Anti -lock Brake System (ABS)
The ABS system in your car performs a self -diagnostic test when the vehicle first reaches the speed of approximately
12 mph (20 km/h). The brake pedal will pulsate several times and a sound may be audible from the ABS control
module. This is normal.
Fuel tank cover
The fuel tank cover is locked and must be popped open using the control on the driver's door.
Contents
Chapter 1 - Occupant safety1
Chapter 2 - Instruments, switches and controls15
Chapter 3 - Body and interior39
Chapter 4 - Starting and driving55
Chapter 5 - Wheels and tires75
Chapter 6 - In case of an emergency81
Chapter 7 - Car care99
Chapter 8 - Volvo Service105
Chapter 9 - Specifications123
Chapter 10 - Audio systems131
Index188
ProCarManuals.com

Chapter 4 - Starting and driving
pg. 55 Starting and driving
Starting and driving

This section on starting and driving contains items such as starting the engine, operating the gear selector, towing,
trailers, etc.
Break-in period
56
Fuel requirements, Refueling56-57
Driving economy58
Starting the engine59
Manual transmission60
Automatic transmission61
Points to remember64
Emergency towing66
Vehicle towing information67
Jump starting68
Three-way catalytic converter69
Brake system70-71
Trailer towing72
Winter driving73
Long distance trips74
pg. 56 Break-in period, Fuel requirements
A new car should be broken -in

Refrain from utilizing your car's full driving potential during the first 1,200 miles (2,000 km) including the "kick -
down" function (automatic transmission).
NOTE - ENGINE OIL:
Although some oil consumption occurs during normal engine operation, more oil is consumed when the engine is new
as the internal parts generate higher friction while wearing-in to each other. From the time the engine is new until
the first service is performed, the oil consumption could be higher than normal. For this reason, it is especially
important to check the oil every time you refuel your car during this period. See page 114
.
In general, the rate of oil consumption depends on such factors as: engine temperature, length of trip, driving
conditions, oil viscosity and quality, engine speed and acceleration/deceleration.
Checking your engine oil level each time the car is refueled is one of the most important items you can perform to
help keep your car in good running order.
ProCarManuals.com

Chapter 8 - Volvo Service
pg. 105 Volvo Service
Service - an investment

An investment which will pay dividends in the form of improved reliability, durability, and resale value.
Label information
106
Maintenance service, Warranty107
Maintenance schedule108-109
Servicing110-111
Fuel/emissions systems112
Lubrication113
Engine oil114-115
Power steering fluid, Brake/clutch system fluid reservoir116
Automatic transmission fluid117
Drive belt118
Windshield washer nozzle, Washer fluid reservoir119
Coolant120
Engine compartment121
Battery maintenance122
pg. 106 Label information
ProCarManuals.com

Chapter 9 - Specifications
pg. 123 Specifications
Specifications

This chapter contains facts and figures pertaining to the technical specifications of your car.
Oil/Fluids specifications
124
Engine specifications125
Cooling/fuel/distributor ignition systems126
Front/rear suspensions126
Transmission, Capacities, Vehicle loading127
Electrical system/bulbs128
Dimensions and weights129
Service manuals, Road assistance130
pg. 124 Oil/fluid specifications
Oil quality

Meeting API specification SG, SG/CD, SH or Energy Conserving (EC) II
For best fuel economy and engine protection, consult with your authorized Volvo retailer for recommended oils. Oil
with a different quality rating may not provide adequate engine protection. Synthetic oils complying with oil quality
requirements are recommended for : driving in areas of sustained temperature extremes (hot or cold), when towing a
trailer over long distances or for prolonged driving in mountainous areas.
Extra oil additives must not be used unless advised by an authorized Volvo retailer.
NOTE: SAE 15 W -40 oil should only be used in extreme operating conditions such as trailer towing in sustained
ambient temperatures over 104° F (40° C). However, SAE 10W -30 synthetic oil would be a better alternative in such
conditions.
SAE 15W-30 should not be used under normal operating conditions.
Viscosity (stable ambient temperatures):
Engine oilQuality: Meeting API specification SG or
SH Capacity (incl. filter): 6.1 US qts. (5.8
liters)*
Automatic transmission
fluid Quality:
ATF Dexron IIE/ III and Mercon Capacity: 8 US qts. (7.6 liters)
ProCarManuals.com

Manual transmission fluidQuality: Volvo synthetic gearbox oil
1161423
Capacity: 2.2 US qts (2.1 liters)
Power steering fluid Quality: ATF Capacity: 0.95 US qts. (0.9 liters)
Brake fluid Quality: DOT 4+ Capacity: 0.64 US qts. (0.6 liters)
* Add 0.95 qts. (0.9 liters) if the oil cooler has been drained
All specifications are subject to change without notice.
pg. 125 Engine
Engine

Liquid-cooled gasoline, 5-cylinder, in-line engine. Aluminum alloy cylinder block with cast-iron cylinder liners cast
directly into block. Aluminum alloy cylinder head with double overhead camshafts and separate intake and outlet
channels.
Engine lubrication is provided by an eccentric pump driven from the crankshaft. Full-flow type oil filter. Exhaust
emission control accomplished by multiport fuel injection, heated oxygen sensor(s) and three-way catalytic converter.
Designation: Volvo B 5254 T
Output 190 hp at 5100 rpm (142 kw 85 rps)
Max torque 199 ft. lbs. at 1800 -4998 rpm (270 Nm/30 -83.3 rps)
Number of cylinders 5
Bore 3.27" (83 mm)
Stroke 3.54" (90 mm)
Displacement 2.4 liters
Compression ratio 9.0:1
Number of valves 20
Valve clearance Self -adjusting
Designation: Volvo B 5234 T3
Output 236 hp at 5100 rpm (176 kw/85 rps)
Max torque 243 ft. lbs. at 2700 -5100 rpm (330 Nm/45 -85 rps)
Number of cylinders 5
Bore 3.19" (81 mm)
Stroke 3.54" (90 mm)
Displacement 2.3 liters
Compression ratio 8.5:1
Number of valves 20
Valve clearance Self -adjusting
All specifications are subject to change without notice.

Contents | Top of Page
ProCarManuals.com

Keyless entry system.......................43Keylock....................................59Keys.......................................42Kick -down..................................61
L
Label information.........................106Lifting the car...........................110Locks......................................42Long distance trips........................74Long load storage..........................50Lubrication...............................113
M
Maintenance schedule......................108Maintenance service.......................107Malfunction indicator lamp..............17,18Manual transmission....................60,127Manual transmission fluid.................124Memory function - front seats..............46Mirrors - rear/side view...................48
O
Occupant safety............................12Octane rating..............................57Odometer...................................16Oil (engine)......................114,115,124Oil pressure warning light.................18On-call...................................130
P
Paint touch -up............................100Parking brake...........................17,30Parking brake reminder light...............18Parking lights.............................20Polishing.................................103Power seats.............................46,47Power steering fluid..................116,124
R
Radio
General information.....................184
SC-813..................................132 SC-816..................................145 SC-900/901..............................161Radio Data System - RDS...................166Reading lights.............................49Rear (side) windows - opening..............37Rear fog light..........................17,22Rear suspension...........................126Rear window demister.......................23Rear/side -view mirrors....................48Refueling..................................57Remote control (central locking system)....43Remote keyless entry system................43Replacing bulbs.............85,86,87,88,89,90Replacing fuses............................91Reporting Safety Defects...................12Roadholding................................65Roof rails/racks...........................65
S
Safety defects (reporting).................12Seat belt maintenance......................12Seat belts.............................2,3,10 Automatic Locking Retractor..............10 Emergency Locking Retractor..............10Seat belts - cleaning.....................104
ProCarManuals.com