fuel VOLVO C70 CONVERTIBLE 2005 Owner´s Manual

62
Fuel requirements, Refueling
52





 
"

0
2
3


F" /




>(


Refueling
 
 $
<>5
D







$




1


I
I



 


$
& 

" 




"

/ I9 I  

"



/




'


 "




 

8"
 



>
=#
•-







2
2


"




•
"






'


L

•$





,



 


•    

B
 


"  



4( 3
 &


•-



 " 
 


 








5 


4
(  3
 &


2302505a
0



 !

Fuel filler door
The fuel filler door (on the right rear fender) is
locked and must be popped open using the
control on the driver's door.
Open fuel filler cap slowly during hot
weather conditions.
!
"#$%4 

 
  

2
 "




"

6

106
In case of emergency
Shiftlock release (automatic transmission only)
 

 


  
#
<






2
:

H5F2%3,)K,(?992-?I












=
&  



"










0


;


A
Manually opening the fuel filler door
 







 






W3DNRP
L
P
3L
W
ND
ROVERRIDESHIFTLOCK
4302013A8300921AA

115
Chapter 8 - Volvo Service
Label information 116
Maintenance service, Warranty 117 Servicing 118
Emissions maintenance 119
Fuel/emissions systems 120 Lubrication 121
Engine oil 122
Power steering fluid, Brake/clutch system fluid reservoir 124 Washer fluid reservoir 125Coolant 126
Engine compartment 127
Battery maintenance/Proposition 65 warning 128 Three-way catalytic converter 129

116
 )

  >  # 
E(



"







 
 % 
 
 


"
(



/ )
 
 
0 .
;

>


;
6 A
 

(  2

 4
 (24

) 
"

 




"






9 )

#
  
3)#45
 (24








 (24



 

D 

A )

'
' 
3A)''4 
  3='
4 
A   3>A)''4  &
 3>
E(




"








/ 
 % 
 


 
"  

(


*
. 


= ' 

;
Label information
L  ( 2

4
(24 
'

 


 


LL  


 



 

,
  
   

CATALYST
ENGINE:B5254SEVOPARATIVEFAMILY:TVV1143AYPEA(86.130-96PROCEDURES)EXHAUSTEMISSIONCONTROLSYSTEM:SFI,HO2S(2),TWC,AIR
TUNE-UPSPECIFICATIONS:NOADJUSTMENTSNEEDEDTHISVEHICLECONFORMSTOUSEPAANDCALIFORNIAREGULATIONSAPPLICABLETO1996MODELYEARNEWTLEVPASSENGERCARS.OBDIICERIFIED
ENGINEDISPLACEMENT:2435cm149cuinENGINEFAMILY:TVV2.4VJGKEKEXHAUSTEMISSIONArialSIN-USECERTIFICATIONTLEVArialCATEGORYTLEV24VJGKEF
VEHICLEEMISSIONCONTROLINFORMATIONMANUFACTURER:VOLVOCARCORP.,SWEDEN
NSPOA
MFD.BYVOLVOGOTHENBURGSWEDEN
MOTORVEHICLESAFETYANDBUMPERArialSINEFFECTONTHEDATEOFMANUFACTURESHOWNABOVE
G.A.W.R.FRONT
N
VIN
DATE GV.W.RG.A.W.R.REAR
SPARETIRE
OPTIONALPRESSURE
IF TIRES ARE HOT FROM DRIVING ADD 4PSI (28 kPa) TO THESE RECOMMENDED PRESSURES
SEEOWNER’SMANUALFORADDITIONALINFORMATI
OCCCUPANTS
RECOMMENDEDFORFUELECONOMY
VCM
SS
VACUUMHOSEROUTING
TIRESIZE
SIZE
VEHICLECAPACITY
LOADMAXWEIGHT FRTRR
N
C
RT
984
TR
DACNAA
AVS
INFLATIONPRESSUREPSI
PSI
FRONTTOTALREARPSI
VOLVOCARCORP.
KGKGKGKG
2.1.
MADEINSWEDEN
0300382a

119
Emissions maintenance
Periodic maintenance helps minimize
emissions
Periodic maintenance will help keep your vehicle running well. Your
Warranty and Service Records Information booklet provides a
comprehensive periodic maintenance schedule up to 150,000 miles
(240,000 km) of vehicle service. The schedule includes components that
affect vehicle emissions. This page describes some of the emission-
related components.
Engine air filter
The engine air filter cleans particles from air entering the engine.
Replace the engine air filter cartridge with a new one every 37,500
miles (60,000 km) under normal driving conditions. Replace the
cartridge more often when the vehicle is driven under dirty and dusty
conditions. The cartridge cannot be cleaned, and should always be
replaced with a new one.
Fuel filter
The fuel filter should be replaced at 105,000 miles (168,000 km). The
filter is replaced as a complete unit. Replace more frequently if
contaminated fuel is introduced into the tank, or if there is reason to
suspect that this has occurred.
Fuel system, including filler cap, tank, lines,
and connections
The ability of the fuel system to contain hydrocarbons depends upon a
leak-free system. Inspect fuel lines every 30,000 miles (48,000 km).
Check for proper sealing of the fuel filler cap, which contains “O”\
ring
seals.
NOTE: If the fuel filler cap is not closed tightly or if the engine is
running when the car is refueled, the Check Engine light (Malfunction Indicator) may indicate a fault. However, your vehicle’s performance
will not be affected. Use only Volvo original or approved fuel filler caps.
Timing belt
For proper functioning of the engine and emission control systems, the
timing belt and belt tensioner must be replaced every 105,000 miles
(168,000 km). Engine damage will occur if the belt fails.
PCV system
(on turbocharged models)
The nipple in the intake manifold and the filter at the end of the PCV
hose in the air cleaner should be inspected and cleaned at 105,000 miles\
(168,000 km), and again at 150,000 miles (240,000 km).
Spark plugs
The spark plugs should be replaced every 60,000 miles (96,000 km)
under normal driving conditions. City driving or fast highway driving
may necessitate replacement sooner.
Under normal driving conditions, spark plugs require no maintenance
between replacement intervals. When installing new plugs, be sure to
use the right type and to tighten them correctly. When changing the
plugs, clean the terminals and rubber seals. Also check that the
suppressor connectors are in good condition. Cracked or damaged
connectors should be replaced.

120
Fuel system
 



 2
  



"












2




6

 



"









$ 
 

Heated oxygen sensor(s)
 




  
$




$ 



 $ 



 
  6

 











6 

  
" 

$$
4,$

 

 


Fuel/emissions systems
Crankcase ventilation
 



    
  




 

2
"





   

Evaporative control system
 '




  




 

 




""%3

(
(%3(("
" 
""




2
"








)
)())(


 

"



  
 

%3((




 
" 

2200090A
4'
 
 


& 


"


 


/






 


•2




 

"
 0
 2
 3




•-

"




 
88






'



  
 




>
5
?




)
91
2$
 "









>
=#%


 



 


  
 


131
Chapter 9 - Specifications
Oil/fluids specifications 132Engine specifications 133
Cooling/fuel/distributor ignition systems 134 Front/rear suspensions 134
Transmission, Capacities, Vehicle loading 135 Electrical system/bulbs 136
Dimensions and weights 137
On Call Roadside assistance 138

134
All specifications are subject to change without notice.
Specifications
Cooling system
# 
 "  

 
\f

\b
\f
<+M%*M)
)\f
# (\b\f \f
.\f
8
)\f\f
# *
>5 '

*
+

Fuel system
 \b'
\f

6



Distributor ignition system
%\b #<:A=
-


 \b
 

\b# 4
 \f6
\f

5\f \b# ) \f 9)* E)  '\f

5\f\b\b\f# +
+=!+
*A
\b
\b
'# <




N.=
*



:A4N.A 4
!
"#$%
 


\b

\f
\f
 \b 
\f\b
5\f
\f
\f




6
\f


\b
 #
•9\f\b 


 \b
 
 
\b
 \b"
"


•-

 \f\f




\b


 
\b\b
 \f



\f
6

Front suspension
5\b



\b\f
 \f

\f
\f



\f
 \f
\f\f
\b

5\f


\b

 \f\b
\f
\f
\f\f\f

"
\f
\f\f 

\f
 # :
N.+
*
\f
# :
@N.+
@
Rear suspension
-
\f\f\f 
\b
\f

\f"
\f\f
\f

\f

# MN.<+M

135


\b 

,
  \f
 \f  

Specifications
Capacities
%
\f <>5\b\f
D

)\b 
 *
>5'

*
+

?\b

 D
<>5'

A



\f

\f :>5\b\f*
D

0\f\f
\f :
:>5'

:
<

 
\b  +
@A>5'
+
@

&\f    
*>5'


A

1\f.
  
 +
D>5'
+
D

Vehicle loading
The tires on your Volvo should perform to specifications at all normal
loads when inflated as recommended on the tire information label. The
label is located on the inside of the fuel filler door. The label also lists
vehicle load limits. Do not load your car beyond the indicated limits.!
"#$%
2\f


"\f\f
 
\f\b\f\f
\f
\f
\b 



\f\b

Power transmission
Manual transmission: M 56 H
5\b\f


  \f\b\f\b
7
\b\f
\f
,\f
\f\f
\b\f


  
++#<
"
   
<
\b\f =
+*#<
:\b\f <
**#<
=\b\f <
<@#<

\b\f +
*#<
A
\b\f +
*+#<
9 :
@@#<
Automatic transmission: AW 55-50 LE
A\f
\f

\f
\b\f
$\b\f
\f
'

\f
7\f
\f\b\f"

\b\f
 \f 

,\f
\f\f
\b\f

- \f



\f 6
 \f

 ,


  :
#<
"
   
<
\b\f 
**#<
:\b\f =
++#<
=\b\f <
@D#<

\b\f <
=:#<
A
\b\f <
+:#<
9 =
:=#<