battery VOLVO S60 2015 Owner´s Manual

09 Maintenance and specifications
Hood and engine compartment 09
342
Opening and closing the hood
Turn the handle located under the left side of the dash approximately 20-25degrees clockwise to release the hoodlock.
Lift the hood slightly. Press the release control (located under the right front edgeof the hood) to the left, and lift the hood.
WARNING
Check that the hood locks properly when closed.
Engine compartment, overview
Coolant expansion tank
Power steering fluid reservoir
Dipstick-engine oil
Filler cap-engine oil
Cover over brake fluid reservoir
Battery
Relay/fuse box
Washer fluid reservoir
Engine compartment - 4-cylinder engines only
Filler cap-engine oil
Coolant expansion tank
Radiator
Brake fluid reservoir
Battery
Relay/fuse box
Washer fluid reservoir
Air cleaner
The appearance of the engine compartment may vary depending on engine model.

09 Maintenance and specifications
Battery09
}}
357
Warning symbols on the battery
Wear protective goggles.
Keep away from children.
Avoid smoking, open flames, and/or sparks.
See the owner's manual.
Contains corrosive acid.
Risk of explosion
Recycle properly
NOTE
A used battery should be disposed of in an environmentally responsible manner. Con-sult your Volvo retailer or take the batteryto a recycling station.
Handling
•Check that the battery cables are cor- rectly connected and tightened.
• Never disconnect the battery when theengine is running (for example, whenreplacing the battery).
• If the battery is fully discharged a numberof times, this may shorten its service life.
• The service life of a battery is affected byfactors such as the number of starts, driv-ing conditions and climate. Extreme cold may also further decrease the battery’sstarting capacity.
• Because the battery’s starting capacitydecreases with time, it may be necessaryto recharge it if the vehicle is not drivenfor an extended period of time or if thevehicle is usually only driven short dis-tances.
• Never use a quick charger to charge thebattery. Only traditional types of batterychargers should be used.
CAUTION
The infotainment system's energy-saving feature may not function correctly or at all,and/or a message may be displayed if abattery charger or jumper cables are notconnected properly.
• The negative terminal on the battery must
never be used to connect a
jumper cable or a battery charger.Only the ground point on the chassismay be used.
See page 123 for an illustration and addi- tional information.

09 Maintenance and specifications
Battery 09
358
WARNING
•Never expose the battery to open flame or electric spark.
• Do not smoke near the battery.
• Battery fluid contains sulfuric acid. Donot allow battery fluid to contact eyes,skin, fabrics or painted surfaces. Ifcontact occurs, flush the affected areaimmediately with water. Obtain medi-cal help immediately if eyes are affec-ted.
NOTE
The life of the battery is shortened if it becomes discharged repeatedly.
Maintenance
•
Use a screw driver to open the caps or cover and a flashlight to inspect the level.
• If necessary, add distilled water. The levelshould never be above the indicator.
• The fluid level should be checked if thebattery has been recharged.
• After inspection, be sure the cap overeach battery cell or the cover is securelyin place.
• Check that the battery cables are cor-rectly connected and properly tightened. •
Never disconnect the battery when theengine is running, or when the key is inthe ignition. This could damage the vehi-cle's electrical system.
• The battery should be disconnected fromthe vehicle when a battery charger isused directly on the battery.
• To help keep the battery in good condi-tion, the vehicle should be driven for atleast 15 minutes a week or connected toa charger with an automatic chargingfunction.
• If the battery is fully discharged a numberof times, this may shorten its service life.Keeping the battery fully charged helpsprolong its service life.
• The service life of a battery is affected byfactors such as driving conditions and cli-mate. Extreme cold may also furtherdecrease the battery’s starting capacity.
• Because the battery’s starting capacitydecreases with time, it may be necessaryto recharge it if the vehicle is not drivenfor an extended period of time or if thevehicle is usually only driven short dis-tances.
CAUTION
•Always use distilled or deionized water (battery water).
• Never fill above the level mark in thecell.
Replacing

09 Maintenance and specifications
Battery09
}}
* Option/accessory, for more information, see Introduction.359
WARNING
Connect and disconnect the positive and negative cables in the correct sequence.
RemovalSwitch off the ignition, remove the remote key from the ignition slot and wait at least5 minutes before disconnecting the battery sothat all information in the vehicle's electricalsystem can be stored in the control modules.
Open the clips on the front cover and remove the cover.
Release the rubber molding so that the rear cover is free.
Remove the rear cover by pulling it away.
Detach the black negative cable.
Detach the red positive cable
Detach the ventilation hose from the
battery
Loosen the screw holding the battery
clamp.
Move the battery to the side and lift it up.
WARNING
PROPOSITION 65 WARNING! Battery posts, terminals, and related accessories contain lead and lead com-pounds, chemicals known to the state ofCalifornia to cause cancer and reproduc-tive harm. Wash hands after handling.
Rally bar R-Design models*
Rally bar and bulkhead hatch
Vehicles with the optional R-Design package are equipped with a rally bar in the enginecompartment that must be removed beforethe battery can be replaced.

09 Maintenance and specifications
Battery 09
360
1. Remove the hatch in the bulkhead onboth sides of the engine compartment (pry them up carefully with a plastic knifeor similar object).
2. Remove the screw on each side of the engine compartment holding the rally barin place.
3. Lift out the rally bar. > The battery can now be removed (seethe instructions in the previous sec-tion).
• After a new battery has been installed (see the following section), reinstall therally bar in the reverse order.
NOTE
When reinstalling the rally bar, tighten the screws to 22 ft lbs (30 Nm).
Installation1. Lower the battery into the battery box.
2. Move the battery inward and to the side
until it reaches the rear edge of the box.
3. Tighten the clamp that secures the bat- tery.
4. Connect the ventilation hose. > Be sure that it is correctly connectedto the battery and the vent in the vehi- cle's body.
5. Connect the red positive cable.
6. Connect the black negative cable.
7. Press in the rear cover. (See Removal).
8. Reinstall the molding. (See Removal).
9. Reinstall the front cover and secure it with the clips. (See Removal).

09 Maintenance and specifications
Fuses09
371
PosFunctionA
Circuit breaker: fusebox A
under the glove compartment (see page 366)60
Circuit breaker: central elec- trical module in the trunk60
Climate system blower40
––
––
Starter motor relay30
Internal diode50
Auxiliary battery70
Central electrical module: auxiliary battery referencevoltage, auxiliary batterycharging point15

10 Specifications
Specifications
10
388
Other fluids and lubricants
FluidSystemVolumeSpecification
Transmission oilAAutomatic (TF-80SC)7.4 US qts (7 liters)Transmission fluid AW-1
Automatic (TG-81SC)7 US qts ( 6.6 liters)
Coolant3.0T/T59.4 US qts. (8.9 liters)Coolant with corrosion inhibitor mixed with water (50/50 mix), see packaging.
All 4-cyl. engines8.8 US qts. (8.3 liters)
Air conditioningAll models1.6 lbs (720 g)Refrigerant: R134a (HFC134a), PAG oil
Brake fluid0.63 US qts (0.6 liters)DOT 4 boiling point >536 °F (>280 °C)
Power steering-Power steering fluid WSS M2C204-A2 or equivalent product.
Washer fluid6.8 US qts (6.5 liters) 4.7 US qts (4.5 liters B
)Use a washer antifreeze recommended by Volvo, mixed with water.
Fuel tank volume17.8 US gallons (67.5 liters)See page 293 for fuel recommendations
A Under normal driving conditions the transmission oil does not need changing during its service life. However, it may be necessary under adverse driving conditions.
B Models without headlight washers
Electrical system
General information
WARNING
PROPOSITION 65 WARNING!
Battery posts, terminals, and related accessories contain lead and lead com-pounds, chemicals known to the state ofCalifornia to cause cancer and reproduc-tive harm. Wash hands after handling.12 volt system with a voltage-regulated alter- nator. Single pole system in which the chas-sis and engine block are used as conductors.The negative terminal is connected to thechassis.

10 Specifications
Specifications
10
* Option/accessory, for more information, see Introduction.389
MotorVoltage (V)Cold start capacity
CCA (Cold Cranking Amperes) (A)Reserve capacity (minutes)
Engines with Start/Stop*12760A135
All other engines12520–800100–160
A
AGM (Absorbed Glass Mat) batteries have to be used on models with Start/Stop
CAUTION
If the battery is replaced, replace it with a battery of the same cold start capacity andreserve capacity as the original (see thedecal on the battery).

11 Index
11
394
1, 2, 3 ...
12-volt sockets........................................ 240
A
ABS (anti-lock brake system).................. 140
Accessory installation warning.................. 13
Active chassis system............................. 237
Active high beams..................................... 99Active yaw control................................... 148
Adaptive brake lights............................... 139
Adaptive cruise control.................... 155, 157 queue assist........................................ 160
Airbags disconnecting the front passenger’s
side................................................. 27, 28
front...................................................... 23
inflatable curtain................................... 33
side impact........................................... 31
Air conditioning........................................ 226
Air distribution.......................................... 222
Air distribution table................................. 229
Air vents................................................... 223 All Wheel Drive......................................... 128
Ambient temperature sensor..................... 85
Anti-freeze....................................... 290, 346Anti-lock brake system
warning light......................................... 83
Anti-lock Brake System (ABS)................. 140
Approach lighting.............................. 59, 105Audio system AUX/USB sockets............................... 267 Bluetooth ®
devices............................. 270
Bluetooth ®
hands-free system........... 272
Bluetooth streaming audio................. 270
getting started.................................... 245
HD digital radio................................... 255
introduction......................................... 244
media player....................................... 262
overview.............................................. 244
radio functions.................................... 253SiriusXM ™ satellite radio.................... 257
sound settings.................................... 248
steering wheel keypad........................ 245
voice control....................................... 281
Auto-dim rearview mirror......................... 111
Automatic locking retractor....................... 39 Automatic transmission
Eco (driving function).......................... 132
Geartronic........................................... 126
general description..................... 125, 126
oil........................................................ 388
shiftlock override................................ 128
Axle weight.............................................. 317
B
Battery maintenance....................................... 358
remote key, replacing........................... 63
replacing..................................... 358, 359
specifications...................................... 388
warning symbols................................. 357
Blind Spot Information System (BLIS)..... 206
Bluetooth cell phone connection............. 272
Booster cushions....................................... 48
Brake lights.............................................. 139Brake system ABS..................................................... 140
Brake pad inspection.......................... 139
checking fluid level............................. 346
emergency brake assistance.............. 140

11 Index
11
399
P
Paint, touching up.................................... 375
Park assist....................................... 194, 196
Park Assist Camera................................. 198
Park Assist Pilot....................................... 202Parking brakeelectric, applying/releasing................. 142
warning light......................................... 83
Parking lights........................................... 102
Pedestrian detection................................ 175Personal Car Communicator, unique
functions.................................................... 61
Polishing.................................................. 373Power front seat memory function................................... 91
with keyless drive................................. 92
Power meter............................................ 130
Power mirrors.......................................... 110 defroster............................................. 111
Power moonroof...................................... 115Power steering adjustable........................................... 237
fluid..................................................... 347
Power steering fluid................................. 388 Power windows....................................... 108
Pregnancy, using seat belts during........... 21
Private locking........................................... 65
PROPOSITION 65 WARNING.. 123, 359, 388
R
Radio
SiriusXM ™ satellite radio.................... 257
Radio functions........................................ 253 HD digital radio................................... 255
Rain sensor.............................................. 106
Rear fog lights.......................................... 102
Rear park assist............................... 194, 196Rear seats center head restraint............................. 93
folding................................................... 93
heated................................................. 225
Rearview mirror auto-dim function............................... 111
compass............................................. 113
Rear window defroster............................ 111
Recalls, child restraints.............................. 40
Refrigerant............................................... 388 Refueling.......................................... 292, 293
fuel filler cap....................................... 295
fuel filler door...................................... 294
fuel tank volume................................. 388
Registering child restraints........................ 40 Remote control private locking...................................... 65
Remote key................................................ 56 approach lighting.................................. 59
immobilizer........................................... 58
key blade.................................. 56, 62, 65
locking the vehicle................................ 59
Personal Car Communicator.......... 59, 61
replacing the battery............................. 63
unlocking the vehicle............................ 59
Remote key/PCC common functions................................ 59
Reporting safety defects............................ 17
Roadside Assistance............................... 393
Road sign information (RSI)..................... 151
Roof loads............................................... 299