engine VOLVO S60 2020 Warranty and Maintenance Records Information

50
WARRANTYfor diagnostic and repair expenses. If the failure
is caused by a combination of warrantable and
nonwarrantable conditions, the owner shall not be
liable for the portion of diagnostic and repair costs
relating to the warrantable condition. If the failure
is caused by a nonwarrantable condition, the
vehicle owner shall be liable for all diagnostic and
repair expenses, but not to exceed the maximum
permissible under the inspection program. The
owner may choose to have the vehicle repaired at
a facility other than a Volvo retailer; however, if a
warrantable condition is found, the owner must
bring the vehicle to an authorized Volvo retailer to
have the repairs completed at no cost for parts,
labor, and diagnosis. Volvo will not reimburse
the owner for diagnostic costs incurred at the
unauthorized service facility except in the case of
an emergency.Hybrid models The following provisions apply to vehicles
which fail to pass the California, Connecticut,
Delaware, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Pennsylvania,
Rhode Island, Vermont or Washington Smog
Inspection. Should your vehicle fail a smog check
test during the warranty period, you may choose
to have the vehicle repaired at any authorized
Volvo retailer. The authorized Volvo retailer will
make the necessary repairs within the three (3)
year/50,000-mile period so that the vehicle will
pass the inspection. After three (3) years/50,000
miles, but before a period of use of seven (7)
years/70,000 miles, the authorized Volvo dealer
will repair or replace only those parts listed in the

article “2020 Model Year Emission Parts List” in
this booklet. After seven (7) years/70,000 miles,
but before a period of use of eight (8) years/
80,000 miles, the authorized Volvo retailer will
cover only the catalytic converter, engine control
module, central electronic module and onboard
diagnostic device. TZEV vehicles identified in the
article “Volvo’s 2020 New Vehicle Warranties”
in this booklet have all emissions components
covered for a period of fifteen (15) years or
150,000 miles. Volvo will pay for the repair
unless the failure was caused by abuse, neglect,
improper maintenance, or the use of leaded
fuel or fuels not recommended in your Owner’s
Manual or this booklet. If the failure is covered
under this warranty, Volvo shall be liable for
diagnostic and repair expenses. If the failure is
caused by a combination of warrantable and
nonwarrantable conditions, the owner shall not be
liable for the portion of diagnostic and repair costs
relating to the warrantable condition. If the failure
is caused by a nonwarrantable condition, the
vehicle owner shall be liable for all diagnostic and
repair expenses, but not to exceed the maximum
permissible under the inspection program. The
owner may choose to have the vehicle repaired at
a facility other than a Volvo retailer; however, if a
warrantable condition is found, the owner must
bring the vehicle to an authorized Volvo retailer to
have the repairs completed at no cost for parts,
labor, and diagnosis. Volvo will not reimburse
the owner for diagnostic costs incurred at the
unauthorized service facility except in the case of
an emergency.
What Is Not Warranted (applies to all
models)1. Required maintenance services as specified in
the article “Maintenance Service Operations”
in this booklet. Items that affect emissions
and require scheduled replacement are
warranted up to their first replacement point
[such as spark plugs, filters, belts, etc.].
Once these parts have been replaced at the
scheduled replacement point, they are no
longer covered by this Emission Warranty.
2. Malfunctions in any part caused by misuse,
improper adjustments (by other than a
Volvo dealer during warranty repair work),
modification, alteration, tampering or
disconnection of system parts.
3. Damage resulting from accidents, acts of
nature, or events beyond the control of Volvo.
4. The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual or in the
articles “Fuel requirements” and “Engine oil”
in this booklet, may not be warranted.


52
WARRANTY2020 Model Year Emission Parts ListNon-hybrid models onlyCalifornia, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey, New York,
Oregon, Pennsylvania, Rhode Island, Vermont and
Washington The components listed in the chart below apply to
non-hybrid models and are covered by the Long
Term Defect and Performance Warranty for seven (7) years or 70,000 miles/113,000 kilometers,
whichever occurs first.
ENGINE VIN CODE NUMBER
A2 10 16 AC
Catalytic Converter
A
XXXX
Charge Air Cooler XXXX
CVVT Timing Device (Exhaust)XXXX
CVVT Timing Device (Inlet)XXXX
Electronic Throttle Module (ETM)XXXX
Engine Control Module
A
XXXX
Fuel Pump XXXX
Fuel Tank AssemblyXXXX
Transmission Control Module XXXX
Turbocharger XXXX
Supercharger X
Supercharger Bypass ValveX
A The Engine Control Module and Catalytic Converter are also covered by the 8-year or 80,000-mile Long Term Emissions Warranty. Please see the list in the article “2020 Emission Warranty Parts List –
Federal – U.S. and Canada” in this booklet.

53
WARRANTY
Transitional Zero Emissions (TZEV)
VehiclesModel year 2020 vehicles with engine VIN
code BR or BK sold and registered in California,
Connecticut, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Rhode Island
or Vermont are classified as Transitional Zero
Emissions (TZEV) vehicles. TZEV vehicles have
a defects and performance emissions warranty on
all emissions components for fifteen (15) years or
150,000 miles, whichever occurs first.