coolant temperature VOLVO S60 RECHARGE 2022 Warranty and Maintenance Records Information

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common
law, a vehicle manufacturer shall be required
to provide a means for non-franchised repair
facilities to perform Emission Performance
Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2022 Emission Warranty Parts List –
Federal – U.S. and Canada
The following are some items covered by the
Emission Warranty for (2) years or 24,000
miles/40,000 kilometers, whichever occurs
first. Volvo has continued coverage on these
items under the new car warranty for (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first. Components marked with “*” are
covered by the Long-Term Warranty for eight
(8) years or 80,000 miles/130,000 kilometers,
whichever occurs first. Components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
• Ambient Air Temp Sensor
• Camshaft Position Sensor
• Catalytic Converter*
• Charge Air Cooler
• Charge Air Cooler Intake Manifold
• Control Valve (Water Cooled CAC)
• Coolant Pump
• Coolant Temperature Sensor
• Coolant Thermostat
• Crankshaft Positon Sensor
• CVVT Solenoid Valve (Exhaust/Intake)
• CVVT Timing Device (Exhaust/Intake)
• EGR Cooler
• EGR Pressure Sensor
• EGR Valve
• Electrical Supercharger
• Electrical Supercharger Bypass Valve
• Electronic Throttle Module (ETM)
• Engine Control Module (ECM) Hardware*
• Engine Control Module (ECM) Software
• EVAP Carbon Canister
• EVAP Leakage Control Module (ECLM)
• Filler Pipe
• Fuel Filler Pipe (Capless)
• Fuel High-Pressure Sensor
• Fuel Injector
• Fuel Low-Pressure Sensor
• Fuel Pump
• Fuel Pump Electronic/H Module (PEM)
• Fuel Rail
• Fuel Tank
• Fuel Tank Isolation Valve (FTIV)
• Heated Oxygen Sensor(s)
• High-Pressure Fuel Pump
• Ignition Coil
• Integrated Starter Generator (C-ISG)
• Knock Sensor
• Manifold Absolute Pressure (MAP) Sensor
• Mass Air Flow (MAF) Sensor
• Oil Separator with Crankcase Pressure
Regulator
• On-Board Diagnostic System (OBD)*
• Purge Valve
• Purge Valve Assembly incl. Purge Valve
• Spark Plug (Kit)
• Supercharger
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.

44
WARRANTY
• Supercharger Bypass Valve
• Supercharger Pressure Sensor
• Temp & Manifold Air Pressure Sensor (TMAP)
• Transmission Control Module (TCM)
Hardware
• Temperature Sensor, Inlet Manifold
• Transmission Control Module (TCM) Software
• Turbocharger
HYBRID (T8) SPECIFIC Emission
Components
• AC Compressor (Electrical)
• Active Brake Booster
• Battery Coolant Pump
• Battery Energy Control Module HW (BECM)
• Battery Energy Control Module SW (BECM)
• Booster Pedal Travel Sensor
• Brake Control Module (BCM2)
• Brake Control Module Software
• Chiller Shut-Off Valve
• Chiller Shut-Off Valve (Kit)
• Combined Inverter DC/DC (CIDD)
• Combined Inverter DC/DC Software
(CIDD SW)
• Condensor
• Coolant Temperature Sensor (ED)
• Coolant Thermostat Kit (ED)
• Cooling Fan (Hybrid)
• Electric Drive Coolant Pump
• Electric Engine
• Electric Oil Pump (EOP)
• Electric Oil Pump Control Module
• Electric Rear Axle Drive (ERAD)*
• Electric Vacuum Pump (EVP)
• Electric Vacuum Pump Control Unit (EVP)
• Electrical 3-Way Valve (ED)
• Rear AC with Shut-Off Valve
• High-Voltage Battery**
• High-Voltage Coolant Heater
• Hybrid ED (Electric Drive) Radiator
• Integrated Starter Generator (C-ISG)
• Inverter Electric Motor HW
• Inverter SW
• On Board Charger (OBC) HW
• On Board Charger (OBC) SW
• Pedal Angle Sensor
• Pressure Sensor AC Hybrid
• Rotor Position Sensor (C-ISG)
• SRS Unit
• Steering Wheel Angle Sensor (SAS)
• Thermal Expansion Valve (TXV) with Shut-Off
Valve
• Vacuum Sensor in Active Brake Booster
• Wheel Speed Sensor (Front)
• Wheel Speed Sensor (Rear) Miscellaneous items used in above systems
Manifolds, hoses, clamps, fittings, tubing, sealing
gaskets or devices, pulleys, belts, fuel lines, wiring
harnesses and mounting hardware and electronic
controls (all models) used with the components
listed above.
NOTE
Parts listed under the 2022 Emission Warranty
Parts List – Federal – U.S. and Canada are
only covered components when they apply to
specific engine variants. Not all parts listed
apply to all engine types.
NOTE
Model year 2022 vehicles with engine VIN
code BR or BK sold and registered in California,
Connecticut, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Rhode Island
or Vermont are classified as Transitional Zero
Emissions (TZEV) vehicles. TZEV vehicles have
a defects and performance emissions warranty
on all emissions components, except the hybrid
battery, for fifteen (15) years or 150,000 miles,
whichever occurs first.
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.
** Covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first.