engine VOLVO S80 2010 Owner´s Manual

06 Maintenance and specifications
Wheels and tires
06
262
WARNING
If heavy vibrations, unsteady steering
behavior, or noises should occur while driv-
ing, reduce speed and park the vehicle in a
safe place. Recheck the tire for bumps,
cracks, or other visible damage, and
recheck its inflation pressure. If the pressure
is below 19 psi (1.3 bar), do not continue
driving. Have the vehicle towed to a trained
and qualified Volvo service technician.
Stage 2: Checking inflation pressure1. Connect the tire sealing system as descri-
bed in stage 1.
2. Refer to the inflation pressure tablesfor the
correct inflation pressure. If the tire needs
to be inflated, start the tire sealing system’s
compressor. If necessary, release air from
the tire by turning the air release knob
counterclockwise.
CAUTION
The compressor should not be used for
more than 10 minutes at a time to avoid
overheating.
WARNING
If you interrupt your trip for more than 1
hour, check the inflation pressure in the
damaged tire again before continuing.
Replacing the sealing compound
container
The sealing compound container must be
replaced if:
•the tire sealing system has been used to
repair a tire
•the container’s expiration date has passed
(see the date on decal).
NOTE
•After use, the sealing compound bottle,
the hose, and certain other system
components must be replaced. Please
consult your Volvo retailer for replace-
ment parts.
•If the sealing compound bottle’s expi-
ration date has passed, please take it to
a Volvo retailer or a recycling station
that can properly dispose of harmful
substances.
Inflating tires
The tire sealing system can be used to inflate
the tires. To do so:
1. Park the car in a safe place.
2. The compressor should be switched off.
Ensure that the on/off switch is in position
0 (the 0 side of the switch should be
pressed down).
3. Take out the electrical wire and hose.
4. Remove the valve cap from the tire’s infla-
tion valve and screw the hose connector
onto the valve as tightly as possible by
hand.
5. Connect the electrical wire to the nearest
12-volt socket in the vehicle.
6. Start the vehicle’s engine.
WARNING
•The vehicle’s engine should be running
when the tire sealing system is used to
avoid battery drain. Therefore, be sure
the vehicle is parked in a well ventilated
place, or outdoors, before using the sys-
tem.
•Children should never be left unattended
in the vehicle when the engine is running.

06 Maintenance and specifications
Vehicle care
06

267
CAUTION
•Avoid waxing or polishing plastic or rub-
ber components
•Polishing chromed strips can wear
away or damage the surface
•Polishes containing abrasive sub-
stances should not be used
Automatic car wash
•We do NOT recommend washing your car
in an automatic wash during the first six
months (because the paint will not have
hardened sufficiently).
•An automatic wash is a simple and quick
way to clean your car, but it is worth
remembering that it may not be as thor-
ough as when you yourself go over the car
with sponge and water. Keeping the under-
body clean is most important, especially in
the winter. Some automatic washers do
not have facilities for washing the under-
body.
CAUTION
•Before driving into an automatic car
wash, turn off the optional rain sensor to
avoid damaging the windshield wipers.
•Make sure that side view mirrors, auxil-
iary lamps, etc, are secure, and that any
antenna(s) are retracted or removed.
Otherwise there is risk of the machine
dislodging them.
•Chromed wheels: Clean chrome-
plated wheels using the same deter-
gents used for the body of the vehicle.
Aggressive wheel-cleaning agents can
permanently stain chrome-plated
wheels.
WARNING
•When the vehicle is driven immediately
after being washed, apply the brakes,
including the parking brake, several
times in order to remove any moisture
from the brake linings.
•Engine cleaning agents should not be
used when the engine is warm. This
constitutes a fire risk.
Exterior lightingCondensation may form temporarily on the
inside of the lenses of exterior lights such as
headlights, fog lights, or taillights. This is nor-mal and the lights are designed to withstand
moisture. Normally, condensation will dissi-
pate after the lights have been on for a short
time.
Polishing and waxing
•Normally, polishing is not required during
the first year after delivery, however, wax-
ing may be beneficial.
•Before applying polish or wax the vehicle
must be washed and dried. Tar spots can
be removed with kerosene or tar remover.
Difficult spots may require a fine rubbing
compound.
•After polishing use liquid or paste wax.
•Several commercially available products
contain both polish and wax.
•Waxing alone does not substitute for pol-
ishing a dull surface.
•A wide range of polymer-based waxes can
be purchased today. These waxes are easy
to use and produce a long-lasting, high-
gloss finish that protects the bodywork
against oxidation, road dirt and fading.
•Do not polish or wax your vehicle in direct
sunlight (the surface of the vehicle should
not be warmer than 113 °F (45 °C).

06 Maintenance and specifications
Specifications
06
276
Engine specifications
Specification/
Model3.2 6-cyl.3.2 6-cyl.3.0TV8
Engine designationB6324SB6324S2B6304T2B8444S
Output (kW/rps)175/103168/103210/93232/99
Output (hp/rpm)235/6200225/6200281/5600311/5950
Torque (Nm/rps)320/53300/57400/25 – 80440/66
Torque (ft. lbs./rpm)236/3200221/3400295/1500 – 4800325/3950
No. of cylinders6668
Bore (in/mm)3.3/843.3/843.23/823.7/94
Stroke (in/mm)3.78/963.78/963.67/93.23.13/79.5
Displacement3.19 liters (194.8 cu. in.)3.19 liters (194.8 cu. in.)2.95 liters (175 cu. in.)4.4 liters (269.4 cu. in.)
Compression ratio10.8:110.3:19.3:110.4:1
Engine oil
Engine oil must meet the minimum ILSAC
specification GF-4, API SL, or ACEA A1/B1.
Lower quality oils may not offer the same fuel
economy, engine performance, or engine pro-
tection.
Volvo recommends Castrol.Depending on your driving habits, premium or
synthetic oils may provide superior fuel econ-
omy and engine protection. Consult your Volvo
retailer for recommendations on premium or
synthetic oils.
Oil additives must not be used.
Synthetic oil is not used when the oil is
changed at the normal maintenance services.This oil is only used at customer request, at
additional charge. Please consult your Volvo
retailer.
Oil viscosityIncorrect viscosity oil can shorten engine life
under normal use. SAE 5W-30 will provide
good fuel economy and engine protection. See
the viscosity chart.

06 Maintenance and specifications
Specifications
06

277
G023491
Viscosity chart
Extreme engine operationSynthetic oils meeting SAE 0W-30 or 0W-40
and complying with oil quality requirements arerecommended for driving in areas of sustained
temperature extremes (hot or cold), when tow-
ing a trailer over long distances, and for pro-
longed driving in mountainous areas.
American Petroleum Institute (API)
symbol
G022917
The API Service Symbol "donut" is divided into
three parts:
•The upper section describes the oil's per-
formance level.
•The center identifies the oil's viscosity.
•The lower section indicates whether the oil
has demonstrated energy-conserving
properties in a standard test in comparison
to a reference oil.
Oil volume
Engine modelOil volume between MIN and
MAXVolume (incl. filter)
3.2 (6-cyl.)B6324S/S21.27 US qts (1.2 liters)7.82 US qts (7.4 liters)
3.0T (6 cyl.)B6304T21.27 US qts (1.2 liters)7.82 US qts (7.4 liters)
V8B8444S1.0 US qts (1.1 liters)7.4 US qts (7.0 liters)

06 Maintenance and specifications
Specifications
06
279 Electrical system
General information12 volt system with a voltage-regulated alter-
nator. Single pole system in which the chassis
and engine block are used as conductors. The
negative terminal is connected to the chassis.
Performance, battery
Engine3.2
6-cyl./3.0TV8
Voltage (V)1212
Cold start
capacity (A)520-700600-8
00
Reserve capacity
(min)100-135120-1
60
WARNING
PROPOSITION 65 WARNING!
Battery posts, terminals, and related acces-
sories contain lead and lead compounds,
chemicals known to the state of California
to cause cancer and reproductive harm.
Wash hands after handling.
CAUTION
If the battery is replaced, replace it with a
battery of the same cold start capacity and
reserve capacity as the original (see the
decal on the battery).

07 Index
07
283
specifications...................................... 228
trunk lighting....................................... 228
C
Capacity weight....................................... 252
Catalytic converter................................... 203
CD player/changer................................... 144
Cell phone, hands-free connection......... 147
Central locking system, introduction......... 52
Chains...................................................... 254
Check engine light..................................... 74
Child restraints
recalls and registration......................... 45
Child restraint systems.............................. 36
booster cushions.................................. 42
convertible seats.................................. 40
infant seats........................................... 38
ISOFIX/LATCH anchors........................ 43
top tether anchors................................ 44
Child safety.......................................... 34, 35
booster cushions.................................. 42
child restraint systems.......................... 36
convertible seats.................................. 40
infant seats........................................... 38Child safety locks...................................... 48
Climate system........................................ 130
air distribution............................. 127, 132
air vents.............................................. 128
Interior Air Quality System.................. 127
introduction......................................... 126
passenger compartment filter............ 127
refrigerant........................................... 126
Clock
analogue............................................... 78
Clock, setting............................................. 78
Cold weather driving................................ 198
Collision warning system......................... 161
Compass in rearview mirror..................... 155
Conserving electrical current................... 197
Convertible seats....................................... 40
Coolant............................................220, 278
Cooling system, general information....... 197
Courtesy lighting........................................ 94
Crash mode............................................... 33
Cruise control..................................159, 160
adaptive.............................................. 167
Curb weight............................................. 252
Current, conserving................................. 197
D
Defroster.................................................. 130
Detachable key blade................................ 57
Disconnecting the front passenger’s air-
bag....................................................... 24, 25
Dome lighting............................................. 94
Door mirrors............................................. 100
Driver distraction warning.......................... 10
Driving economically................................ 196
Driving in cold weather............................ 198
Driving through water..............................197
E
ECC.........................................129, 130, 131
Economical driving.................................. 196
Electric parking brake.............................. 116
Electronic Climate Control.......128, 130, 131
air distribution table............................ 132
Interior Air Quality System.................. 131
ventilated seats................................... 129
Emergency brake lights............................. 92
Emergency locking retractor...................... 35

07 Index
07
284
Emergency starting.................................. 109
Emergency towing...........................209, 210
Emission inspection readiness................ 215
Engine
overheating........................................... 76
specifications...................................... 276
starting................................................ 107
switching off....................................... 109
Engine compartment overview................217
Engine oil
checking............................................. 218
low pressure warning light.............. 75, 76
specifications...................................... 276
volumes.............................................. 277
Environment............................................... 11
Eyelets for anchoring loads..................... 204
F
Federal Clean Air Act............................... 214
Fluid specifications.................................. 278
Fog lights
front...................................................... 75
front/rear............................................... 92
Four C (active chassis system)................158Front airbags.............................................. 20
disconnecting passenger’s side air-
bag.................................................. 24, 25
Front fog lights..................................... 75, 92
Front park assist.............................. 182, 184
Front seats..................................... 82, 84, 87
heated................................................. 129
lumbar support (S80 Executive only).... 87
massage function (S80 Executive only) 87
moving passenger's seat (S80 Execu-
tive only)................................................ 88
Fuel filler cap........................................... 202
Fuel filler door, opening........................... 202
Fuel level warning light.............................. 75
Fuel requirements............................ 200, 201
Fuel tank volume.....................................278
Fuses............................... 235, 236, 239, 242G
Gasoline requirements............................. 201
Gas tank volume...................................... 278
Gauges...................................................... 73
Geartronic................................................ 112Geartronic automatic transmission.. 111, 112
Generator warning light............................. 76
Glossary of tire terminology..................... 252
Grocery bag holder.................................. 205
Gross vehicle weight...............................252
H
Hazard warning flashers............................ 93
HD digital radio........................................ 138
Headlights
Active Bending Lights........................... 91
changing bulbs...........................223, 224
high/low beams.................................... 90
high beam flash.................................... 90
Headlight washers..................................... 97
Heartbeat sensor (alarm system).........55, 56
Heated front seats................................... 129
Heated oxygen sensors........................... 203
Heated rear seats.................................... 129
High beams................................................ 90
indicator light........................................ 75
Hoisting the vehicle.................................215
Home safe lighting..................................... 94

07 Index
07
286
retractable........................................... 100
vanity.................................................. 191
Moonroof................................................. 102
Motor oil
checking............................................. 218
specifications...................................... 276
volumes.............................................. 277
O
Occupant safety........................................ 14
Occupant weight sensor...................... 24, 25
Octane recommendations.......................201
Odometer, trip........................................... 78
Oil
specifications...................................... 276
volumes.............................................. 277
On Call Roadside Assistance.................. 280
Overhead courtesy lighting........................ 94
Overheating, engine................................... 76
Oxygen sensors, heated.......................... 203
P
Paint, touching up.................................... 269
Park assist.......................................182, 184
Parking brake
electric, applying/releasing................. 116
warning light......................................... 76
Parking lights............................................. 91
changing bulbs................................... 225
Personal Car Communicator, unique func-
tions........................................................... 55
Polishing.................................................. 267
Power front seat
memory function................................... 83
with keyless drive................................. 84
Power mirrors.......................................... 100
defroster............................................. 101
Power moonroof...................................... 102
Power steering
fluid..................................................... 221
speed-dependent............................... 158
Power steering fluid................................. 278
Power windows......................................... 98
laminated glass..................................... 99
Pregnancy, using seat belts during........... 18PROPOSITION 65 WARN-
ING..................................... 11, 109, 234, 279
R
Radio
Sirius satellite radio............................141
Radio functions........................................ 135
HD digital radio................................... 138
Rain sensor................................................ 96
READ button............................................ 124
Rear fog light............................................. 92
Rear park assist............................... 182, 184
Rear seats
folding................................................... 85
heated................................................. 129
Rearview mirror
auto-dim function............................... 101
compass............................................. 155
Rear window defroster............................101
Recalls, child restraints.............................. 45
Refrigerant............................................... 278
Refrigerator (S80 Executive only)............ 192

07 Index
07
287
Refueling..........................................200, 201
fuel filler cap....................................... 202
fuel filler door...................................... 202
fuel tank volume.................................278
Registering child restraints........................ 45
Remote key................................................ 52
approach lighting.................................. 54
immobilizer.....................................52, 53
key blade........................................ 52, 57
key memory.......................................... 52
locking the vehicle................................ 54
Personal Car Communicator..........54, 55
replacing the battery............................. 57
unlocking the vehicle............................ 54
Remote key/PCC
common functions................................ 54
Reporting safety defects............................ 15
Roadside Assistance............................... 280
Roof loads............................................... 206
S
S80 Executive
analogue clock..................................... 78
front seat lumbar support..................... 87
front seat massage function................. 87glasses................................................ 192
moving the front passenger's seat....... 88
refrigerator.......................................... 192
Safety, occupant........................................ 14
Safety defects, reporting........................... 15
Seat belt
reminder................................................ 17
Seat belts
Automatic locking retractor/Emergency
locking retractor.................................... 35
buckling................................................ 16
maintenance......................................... 16
pretensioners........................................ 16
reminder................................................ 16
reminder warning light.......................... 76
securing child restraint sys-
tems.......................................... 38, 40, 42
unbuckling............................................ 16
use during pregnancy........................... 18
using.....................................................16
Seats, front....................................82, 83, 87
Side door mirrors..................................... 100
Side impact airbags................................... 28
Side marker lights, changing bulbs......... 225
Sirius satellite radio.................................. 141
Snow chains............................................ 254Snow tires................................................ 254
Sound settings, audio system................. 134
Spare tire................................................. 255
Speed-dependent steering...................... 158
Spin control............................................. 156
SRS............................................................ 19
Stability system....................................... 156
indicator light........................................ 75
Starting the engine..................................107
with keyless drive............................... 107
Starting the vehicle
after a crash (crash mode)....................33
Start inhibitor (immobilizer)..................52, 53
Steering wheel
adjusting............................................... 89
horn....................................................... 89
keypad.................................. 89, 122, 133
Stone chips, touching up......................... 269
Storage spaces........................................ 189
Studded tires........................................... 254
Sunroof (moonroof).................................. 102
Sun shade.................................................. 99
Supplemental restraint system.................. 19
warning light......................................... 76