brake rotor VOLVO S90 2022 Warranty and Maintenance Records Information

33
WARRANTY

the date the part was originally purchased. Some
genuine Volvo parts/accessories are covered by
their own specific limited warranty for a different
period. For those parts/accessories, the applicable
warranty is supplied at the time of purchase,
including a list of conditions and limitations.
Customer AssistanceShould you have questions regarding the
warranties or repairs, please review the article
“Customer Support and Assistance” in this
booklet for owner information and instructions.
Non-commercial vehicles are covered by On Call
®,
a roadside assistance program which provides
coverage for some specific items not covered by
the warranties (e.g., towing). A separate booklet
describing this program is supplied in your
Owner’s Wallet.
Wear and Tear ItemsAs part of your vehicle’s normal service and
maintenance requirements, certain parts may
need to be replaced due to wear and tear. Since
these parts are consumed at varying rates,
replacement is based on the operation and
condition of your vehicle and on fixed schedules
under normal operation and use of your vehicle.
These items include, but may not be limited to, the
following list: filters, fuses, batteries, belts, brake
pads, brake rotors, wiper blades, shock absorbers,
floor mats, upholstery/rugs, etc.
Replacement of these items are the owner’s
responsibility, with the exception of those items
covered during the Adjustments Coverage Period
(see the following section) or where specific
manufacturing defects may be demonstrated.
Adjustments CoverageAdjustments which are refinements to the original
factory fittings and alignments, and which are
required as part of the break-in period, will be
made during the Adjustments Coverage Period.
Exceptions are items covered under normal
maintenance services, including Pre-Delivery or
items excluded in the New Vehicle section. The
duration of the adjustment coverage is twelve
(12) months or 12,000 miles/20,000 kilometers,
whichever occurs first.
The term “Adjustments” as used in this warranty
refers to minor repairs not usually associated with
the replacement of parts or normal maintenance
service items. Parts which are covered for
replacement because of wear during the
Adjustments Period only are: brake pads, brake
rotors and shock absorbers. These items may also
be covered under the Basic Warranty Period if
manufacturing defects cause the failure. Examples
of labor only repairs which are covered during the
Adjustments Period are wheel balancing, window
regulator adjustment and hood adjustment.What Is Not Warranted
Tires• Tires fitted to the vehicle as original
equipment are warranted separately by the
tire manufacturer. Therefore, any adjustments
must be handled through their authorized
service outlet.
• The applicable tire warranty booklet is in the
Owner’s Wallet.
Routine Maintenance and Services
• Repairs which are required because of a lack
of maintenance, or improper maintenance.
Correct maintenance procedures are
referenced in your Owner’s Manual or
the Warranty and Maintenance Records
Information booklet.
• Scheduled or unscheduled maintenance
services.

44
WARRANTY
• Supercharger Bypass Valve
• Supercharger Pressure Sensor
• Temp & Manifold Air Pressure Sensor (TMAP)
• Transmission Control Module (TCM)
Hardware
• Temperature Sensor, Inlet Manifold
• Transmission Control Module (TCM) Software
• Turbocharger
HYBRID (T8) SPECIFIC Emission
Components
• AC Compressor (Electrical)
• Active Brake Booster
• Battery Coolant Pump
• Battery Energy Control Module HW (BECM)
• Battery Energy Control Module SW (BECM)
• Booster Pedal Travel Sensor
• Brake Control Module (BCM2)
• Brake Control Module Software
• Chiller Shut-Off Valve
• Chiller Shut-Off Valve (Kit)
• Combined Inverter DC/DC (CIDD)
• Combined Inverter DC/DC Software
(CIDD SW)
• Condensor
• Coolant Temperature Sensor (ED)
• Coolant Thermostat Kit (ED)
• Cooling Fan (Hybrid)
• Electric Drive Coolant Pump
• Electric Engine
• Electric Oil Pump (EOP)
• Electric Oil Pump Control Module
• Electric Rear Axle Drive (ERAD)*
• Electric Vacuum Pump (EVP)
• Electric Vacuum Pump Control Unit (EVP)
• Electrical 3-Way Valve (ED)
• Rear AC with Shut-Off Valve
• High-Voltage Battery**
• High-Voltage Coolant Heater
• Hybrid ED (Electric Drive) Radiator
• Integrated Starter Generator (C-ISG)
• Inverter Electric Motor HW
• Inverter SW
• On Board Charger (OBC) HW
• On Board Charger (OBC) SW
• Pedal Angle Sensor
• Pressure Sensor AC Hybrid
• Rotor Position Sensor (C-ISG)
• SRS Unit
• Steering Wheel Angle Sensor (SAS)
• Thermal Expansion Valve (TXV) with Shut-Off
Valve
• Vacuum Sensor in Active Brake Booster
• Wheel Speed Sensor (Front)
• Wheel Speed Sensor (Rear) Miscellaneous items used in above systems
Manifolds, hoses, clamps, fittings, tubing, sealing
gaskets or devices, pulleys, belts, fuel lines, wiring
harnesses and mounting hardware and electronic
controls (all models) used with the components
listed above.
NOTE
Parts listed under the 2022 Emission Warranty
Parts List – Federal – U.S. and Canada are
only covered components when they apply to
specific engine variants. Not all parts listed
apply to all engine types.
NOTE
Model year 2022 vehicles with engine VIN
code BR or BK sold and registered in California,
Connecticut, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Rhode Island
or Vermont are classified as Transitional Zero
Emissions (TZEV) vehicles. TZEV vehicles have
a defects and performance emissions warranty
on all emissions components, except the hybrid
battery, for fifteen (15) years or 150,000 miles,
whichever occurs first.
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.
** Covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first.