air VOLVO V60 2012 Manual PDF

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.339
Box AFunctionA
Folding head restraint*15
Infotainment control module5
Audio control module*
Digital radio*, TV*10
Audio15
Telematics*, Bluetooth*5
--
Sun roof*, Interior lighting
roof, Climate sensor5
12 V socket, tunnel console15
Seat heating, rear right*15
Seat heating, rear left*15
--
Seat heating (passenger
side)15
Seat heating (driver's side)15
Box AFunctionA
Parking assistance*, Park-
ing camera*, Towbar control
module *
BLIS*5
AWD control module*10
Active chassis Four-C*10
Box BFunctionA
Rear window wiper15
--
Interior lighting, Driver's
door control panel, power
windows, Power seats,
front*, Remote controlled
garage door opener*7.5
Information display (DIM)5
Adaptive cruise control,
ACC*, collision warning sys-
tem*10
Interior lighting, Rain sensor7.5
Steering wheel module7.5
Box BFunctionA
Central locking system, fuel
filler flap10
Rear window washer15
Windscreen washers15
Unlocking, tailgate10
--
Fuel pump20
Climate panel5
Steering lock15
Siren alarm*, Data link con-
nector OBDII5
--
Airbags10
Collision warning system5
Accelerator pedal, PTC ele-
ment air preheater*, Dim-
ming, interior rearview mir-
ror*, Seat heating, rear*7.5
ProCarManuals.com

08 Maintenance and service
Fuses
08
342* Option/accessory, for more information, see Introduction.
Engine compartment, cold zone - Start/Stop*
Location of fuses for the Start/Stop function.
•Fuses A1 and A2 are of the "MEGA Fuse"
type and must only be replaced by a work-
shop
2.
•Fuses 1-11 are of the "Midi Fuse" type and
must only be replaced by a workshop2.
•Fuse 12 is of the "Mini Fuse" type.
For more information on Start/Stop - see
page 123.
Positions
FunctionA
Main fuse for central electrical
unit in the engine compartment175
FunctionA
Main fuse for central electronic
module (CEM) with fuse box B
under the glovebox, central
electrical unit in passenger
compartment with fuse box A
under the glovebox, central
electrical unit in cargo area175
PTC element, air preheater*100
2An authorised Volvo workshop is recommended.
ProCarManuals.com

08 Maintenance and service
Car care
08
344
Washing the car
Wash the car as soon as it becomes dirty.
Wash the car in a car wash with oil separator.
Use car shampoo.
•Remove bird droppings from the paintwork
as soon as possible. Bird droppings con-
tain chemicals that affect and discolour
paintwork very quickly. An authorised
Volvo workshop is recommended for the
removal of any discoloration.
•Hose down the underbody.
•Rinse the entire car to remove loose dirt.
Do not spray directly onto the locks.
•Wash using a sponge, car shampoo and
plenty of lukewarm water.
•Clean the wiper blades with a lukewarm
soap solution or car shampoo.
•Use cold degreasing agent on very dirty
surfaces.
•Dry the car using a clean, soft chamois or
a water scraper.
WARNING
Always have the engine cleaned by a work-
shop. There is a risk of fire if the engine is
hot.
IMPORTANT
Dirty headlamps have impaired functional-
ity. Clean them regularly, when refuelling for
example.
NOTE
Outside lighting such as headlamps, fog
lamps and rear lamps may temporarily have
condensation on the inside of the lens. This
is normal, all exterior lighting is designed to
withstand this. Condensation is normally
vented out of the lamp housing when the
lamp has been switched on for a time.
Cleaning the wiper bladesAsphalt, dust and salt residue on wiper blades,
as well as insects, ice etc. on the windscreen,
impair the service life of wiper blades.
For cleaning:
–Set the wiper blades in service position,
see page 325.
NOTE
Wash the wiper blades and windscreen reg-
ularly with lukewarm soap solution or car
shampoo.
Do not use any strong solvents.
Automatic car washesAn automatic car wash is a simple and quick
way of washing the car, but it cannot reach
everywhere. Handwashing the car is recom-
mended for achieving optimum results.
NOTE
During the first few months a new car must
only be handwashed. This is because the
paintwork is more sensitive when it is new.
High-pressure washingWhen using high-pressure washing, use
sweeping movements and make sure that the
nozzle does not come closer than 30 cm to the
surface of the car (the distance applies to all
exterior parts). Do not spray directly onto the
locks.
Testing the brakes
WARNING
Always test the brakes after washing the
car, including the parking brake, to ensure
that moisture and corrosion do not attack
the brake linings and reduce braking per-
formance.
Lightly depress the brake pedal now and then
when driving long distances in rain or slush.
The heat from the friction causes the brake lin-
ProCarManuals.com

08 Maintenance and service
Car care
08
346
Under normal conditions the rustproofing does
not require treatment for approximately 12
years. After this period, it should be treated at
three-year intervals. Volvo recommends that
you engage an authorised Volvo workshop for
assistance if the car needs further treatment.
Dirt and road salt can lead to corrosion so it is
important to keep the car clean. The car's rust-
proofing needs to be checked regularly and
touched-up if necessary in order for it to be
maintained.
Cleaning the interior
Only use cleaning agents and car care prod-
ucts recommended by Volvo. Clean regularly
and follow the instructions included with the
car care product.
Vacuuming is important prior to using cleaning
agents.
Carpets and cargo areaRemove inlaid carpets for separate cleaning of
the floor carpet and the inlaid carpets. Use a
vacuum cleaner to remove dust and dirt.
Each inlay mat is secured with pins.
–Take hold of the inlay mat at each pin and
lift the mat straight up.
Fit the inlay mat in place by pressing it in at
each pin.
WARNING
Before setting off check that the inlaid mat
in the driver area is firmly affixed and
secured in the pins in order to avoid getting
caught adjacent to and under the pedals.
A special textile cleaner is recommended for
stains on the floor mat after vacuuming. Floor
mats should be cleaned with agents recom-
mended by your Volvo dealer!
Stains on fabric upholstery and roof
upholstery
A special fabric cleaning agent, available from
authorised Volvo dealers, is recommended to
avoid impairing the fire retardant qualities of
the upholstery.
IMPORTANT
Sharp objects and Velcro may damage the
fabric upholstery.
Treating stains on leather upholsteryVolvo's leather upholstery is chromium-free
and is treated to preserve its original appear-
ance.
Leather upholstery ages and acquires a beau-
tiful patina over time. The leather is refined and
processed so that it retains its natural charac-
teristics. It is given a protective coating, butregular cleaning is required in order to maintain
both characteristics and appearance. Volvo
offers a comprehensive product for the clean-
ing and treatment of leather upholstery which,
when used in accordance with the instructions,
preserves the leather's protective coating.
After a period of use the natural appearance of
the leather will nevertheless emerge, depend-
ing more or less on the surface texture of the
leather. This is a natural maturing of the leather
and shows that it is a natural product.
To achieve best results Volvo recommends
cleaning and the application of protective
cream once to four times per year (or more if
necessary). The Volvo Leather Care kit is avail-
able from your Volvo dealer.
IMPORTANT
•Certain items of coloured clothing (for
example, jeans and suede garments)
may stain the upholstery.
•Never use strong solvents. Such prod-
ucts may damage fabric, vinyl and
leather upholstery.
Washing instructions for leather
upholstery
1. Pour the leather cleaner on the dampened
sponge and squeeze out a strong foam.
ProCarManuals.com

08 Maintenance and service
Car care
08
348
Colour code
Car colour code
It is important that the correct colour is used.
For product decal location, see page 352.
Repairing stone chips
G021832
Before work is begun, the car must be clean
and dry and at a temperature above 15 °C.
1. Apply a piece of masking tape over the
damaged surface. Then remove the tape to
remove any loose paint.
2. Stir the primer well and apply using a fine
brush or a matchstick. Apply paint using a
brush once the primer is dry.
3. For scratches, proceed as above, but
mask around the damaged area to protect
the undamaged paintwork.
4. After a few days, polish the touched-up
areas. Use a soft rag and a small amount
of lapping paste.
NOTE
If the stone chip has not penetrated to the
bare metal and there is an undamaged col-
our coat, you can paint straight after clean-
ing the damaged surface.
ProCarManuals.com

09 Specifications
Fuel09
365
There are several reasons for increased fuel
consumption compared with the table's val-
ues. Examples of this are:
•The driver's driving style.
•If the customer has specified wheels larger
than those fitted as standard on the mod-
el's basic version, then resistance increa-
ses.
•High speed results in increased wind resis-
tance.
•Fuel quality, road and traffic conditions,
weather and the condition of the car.
Even a combination of the above-mentioned
examples can result in significantly improved
consumption. For further information, please
refer to the regulations referred to
1.
Large deviations in fuel consumption may arise
in a comparison with the EU driving cycles
1
which are used in the certification of the car
and on which the consumption figures in the
table are based.
To bear in mindTips that the driver can use in order to reduce
consumption:
•Drive gently and avoid unnecessary accel-
eration as well as braking too hard.
•Drive with the correct air pressure in the
tyres and check this regularly - select ECO
tyre pressure for best results, see the tyre
pressure table on page 366.
•Choice of tyres can affect fuel consump-
tion - seek advice on suitable tyres from a
dealer.
See further information and more advice on
pages 12 and 270.
See page 274 for general information on fuel.
1Official fuel consumption figures are based on two standardised driving cycles in a laboratory environment ("EU driving cycles") all in accordance with EU Directive 80/1268/EEC (Euro 4), EU Regulation
no 692/2008 (Euro 5) and UN ECE Regulation no 101. The regulations cover the driving cycles for urban driving and extra-urban driving. - Urban driving - the measurement starts with cold starting
the engine. The driving is simulated. - Extra-urban driving - the car is accelerated and braked at speeds between 0-120 km/h. The driving is simulated. - Cars with the D5 engine and 6-speed manual
transmission or DRIVe engine and 6-speed manual transmission, are started in 2nd gear. The value for combined driving, which is given in the table, according to legislation, is a combination of
urban driving and extra-urban driving. CO
2 emission - to calculate the carbon dioxide emissions from the two driving cycles, the exhaust gases are collected. These are then analysed and give the
value for CO2 emissions.
ProCarManuals.com

09 Specifications
Symbols in the display 09
382* Option/accessory, for more information, see Introduction.
General
There are a variety of different symbols in the
display in the car. The symbols are divided into
warning, indicator and information symbols.
Shown below are the most common symbols
with their meanings and a reference to where
in the manual further information can be found.
For more information on symbols and text
messages, see pages 74, 76 and 142.
- Red warning symbol, illuminates when
a fault has been indicated which could affect
the safety and/or driveability of the car. At the
same time an explanatory text is displayed in
the information display.
- Yellow information symbol, illuminates
in combination with text in the information dis-
play, when a deviation in any of the car's sys-
tems has occurred. The yellow symbol infor-
mation can also illuminate in combination with
other symbols.
Symbols in the display
Indicator and warning symbols in the
combined instrument panel
SymbolMeaningPage
Low oil pres-
sure76
Parking
brake76, 133, 135
Airbags -
SRS19, 76
Seatbelt
reminder16, 76
Alternator
not charging76
Fault in the
brake system76, 132
Warning,
safety mode19, 30, 76, 77,
121
Indicator and information symbols in the
combined instrument panel
SymbolMeaningPage
Fault in the ABL
system*74, 89
Emissions sys-
tem74
Fault in the ABS
system74, 132
Rear fog lamp on74, 90
Stability system,
DSTC, Trailer
stability assist74, 169, 288
Stability system,
sport mode74, 169
Engine pre-
heater (diesel)74
Low level in fuel
tank74, 163
Information,
read display text74
Main beam on74, 89
ProCarManuals.com

09 Specifications
Symbols in the display 09
384* Option/accessory, for more information, see Introduction.
SymbolMeaningPage
Driver Alert System*200
Driver Alert Sys-
tem*, Lane Depar-
ture Warning*201, 203
Driver Alert Sys-
tem*, Lane Depar-
ture Warning*203
Driver Alert Sys-
tem*, Time for a
break201
Information symbols in the roof console
display
SymbolMeaningPage
Seatbelt reminder18
Airbag, passenger
seat, activated22, 23
Airbag, passenger
seat, deactivated23
ProCarManuals.com

10 Alphabetical Index
10
386
A
ACC – Adaptive cruise control................. 175
Active Bending Lights (ABL)...................... 89
Active chassis – FOUR-C........................170
Active Xenon headlamps........................... 89
Adaptation............................................... 115
Adapting driving characteristics.............. 170
Adaptive cruise control............................ 175
fault tracing......................................... 182
radar sensor........................................ 181
Adaptive cruise control fault tracing........ 182
Additional heater (Diesel)......................... 165
Adjusting headlamp pattern...................... 93
halogen headlamp................................ 94
Adjusting the steering wheel...................... 87
Airbag
activating/deactivating, PACOS........... 22
driver's and front passenger side......... 20
key switch off........................................ 22
AIRBAG ..................................................... 20
Airbag system ........................................... 19
Air conditioning........................................ 159
general................................................ 152Air conditioning, AC................................. 159
Air distribution.................................. 154, 161
Air quality system IAQS .......................... 159
Air vents................................................... 154
Alarm.......................................................... 65
alarm indicator...................................... 65
alarm signals......................................... 66
arming................................................... 65
checking the alarm............................... 49
deactivate............................................. 65
deactivating a triggered alarm.............. 66
reduced alarm level.............................. 66
Alcolock................................................... 108
Allergy and asthma inducing sub-
stances.................................................... 153
All-wheel drive, AWD............................... 130
All Wheel Drive (AWD).............................. 130
Approach light, duration......................48, 93
Audio
settings....................................... 226, 227
surround.....................................220, 227
audio system .......................................... 222
Audio system........................................... 220
functions............................................. 226
overview.............................................. 222Audio volume .......................................... 223
phone.................................................. 254
phone/media player............................ 254
ring signal, phone............................... 254
Auto
climate control settings...................... 158
Automatic car washes.............................344
Automatic gearbox.................................. 117
manual gear positions (Geartronic)..... 118
towing and recovery........................... 289
trailer................................................... 284
Automatic locking...................................... 61
Automatic relocking................................... 59
Auxiliary heater........................................ 165
AUX input......................................... 222, 240
AWD, All-wheel drive............................... 130
B
Backrest..................................................... 82
front seat, lowering............................... 82
Backrest rear seat, lowering...................... 85
Bag holder .............................................. 279
ProCarManuals.com

10 Alphabetical Index
10
387
Battery.............................................327, 369
maintenance....................................... 327
remote control ................................... 250
remote control key/PCC....................... 53
start assistance................................... 116
symbols on the battery....................... 328
warning symbols................................. 328
Bioethanol E85........................................ 275
Blind spot (BLIS)...................................... 211
Blind Spot Information System, BLIS...... 211
Bluetooth
Ÿ
handsfree ........................................... 251
media ................................................. 243
microphone off ..................................253
streaming audio ................................. 243
transfer call to mobile ........................ 253
Bonnet, opening...................................... 312
Brake and clutch fluid..............................317
Brake light.................................................. 90
Brakes...................................................... 131
anti-lock braking system, ABS........... 131
brake light............................................. 90
brake system...................................... 131
electric parking brake......................... 133
Emergency Brake Assistance, EBA ... 131
emergency brake lights........................ 90filling brake fluid.................................. 318
symbols in the combined instrument
panel...................................................132
Bulbs, see Lighting.................................. 319
C
Calls
incoming............................................. 253
operation............................................. 253
Camera sensor................................189, 195
Car care................................................... 344
Car care, leather upholstery.................... 346
Cargo area
cargo cover......................................... 281
lighting.................................................. 92
loading................................................278
mounting points.................................. 279
safety grille.......................................... 281
safety net............................................ 280
Cargo cover............................................. 281
Car upholstery......................................... 346
Car wash.................................................. 344
Catalytic converter................................... 274
recovery..............................................290CD ........................................................... 236
Centre console........................................ 144
Chassis settings......................................170
Checking and topping up the coolant..... 316
Checking the engine oil level................... 313
Children..................................................... 31
child safety locks.................................. 38
child seats and side airbags................. 24
location in the car.................................31
safety.................................................... 31
Child safety locks...................................... 64
Child seat................................................... 31
Child seats................................................. 31
integrated two-stage booster cushion. 36
ISOFIX fixture system for child seats. . . 38
recommended...................................... 33
size classes for child seats with the ISO-
FIX fixture system................................. 38
upper mounting points for child seats. . 42
Cigarette lighter socket............................ 216
City Safety™............................................ 188
Cleaning
automatic car washes......................... 344
car wash............................................. 344
rims..................................................... 345
ProCarManuals.com