oil filter VOLVO V60 2014 Owners Manual

||
01 Introduction
01
20* Option/accessory, for more information, see Introduction.
A sophisticated air quality system, IAQS* (Interior Air Quality System) ensures that theincoming air is cleaner than the air in the traf-fic outside. The system consists of an electronic sensor and a carbon filter. The incoming air is moni-tored continuously and if there is an increasein the level of certain unhealthy gases such ascarbon monoxide then the air intake isclosed. Such a situation may arise in heavytraffic, queues and tunnels for example. The entry of nitrous oxides, ground-level ozone and hydrocarbons is prevented by thecarbon filter.
InteriorThe interior of a Volvo is designed to be plea-sant and comfortable, even for people withcontact allergies and for asthma sufferers.Extreme attention has been given to choosingenvironmentally-compatible materials.
Volvo workshops and the environmentRegular maintenance creates the conditionsfor a long service life and low fuel consump-tion for your car. In this way you contribute toa cleaner environment. When Volvo's work-shops are entrusted with the service andmaintenance of your car it becomes part ofour system. Volvo makes clear demandsregarding the way in which our workshopsare designed in order to prevent spills anddischarges into the environment. Our work-shop staff have the knowledge and the tools required to guarantee good environmentalcare.
Reducing environmental impactYou can easily help reduce environmentalimpact - here are a few tips: •
Avoid letting the engine idle - switch off the engine when stationary for longerperiods. Pay attention to local regula-tions.
• Drive economically - think ahead.
• Perform service and maintenance inaccordance with the owner's manual'sinstructions - follow the intervals recom-mended in the Service and WarrantyBooklet.
• If the car is equipped with an engineblock heater*, use it before starting fromcold - it improves starting capacity andreduces wear in cold weather and theengine reaches normal operating tem-perature more quickly, which lowers con-sumption and reduces emissions.
• High speed increases consumption con-siderably due to increased wind resis-tance - a doubling of speed increaseswind resistance 4 times.
• Always dispose of environmentally hazar-dous waste, such as batteries and oils, inan environmentally safe manner. Consulta workshop in the event of uncertaintyabout how this type of waste should bediscarded - an authorised Volvo work-shop is recommended. Following this advice can save money, the planet's resources are saved, and the car'sdurability is extended. For more informationand further advice, see Eco guide (p. 63),Economical driving (p. 305) and Fuel con-sumption (p. 403).
RecyclingAs a part of Volvo's environmental work, it isimportant that the car is recycled in an envi-ronmentally sound manner. Almost all of thecar can be recycled. The last owner of the caris therefore requested to contact a dealer forreferral to a certified/approved recyclingfacility.
Related information
•
The owner's manual and the environment (p. 21)
ProCarManuals.co’

08 Starting and driving
08
297
Fording
Fording means that the car is driven through a water-covered roadway. Fording must be car-ried out with great caution. The car can be driven through water at a maximum depth of 25 cm at a maximumspeed of 10 km/h. Extra caution should beexercised when passing through flowingwater. During driving in water, maintain a low speed and do not stop the car. When the water hasbeen passed, depress the brake pedal lightlyand check that full brake function is achieved.Water and mud for example can make thebrake linings wet resulting in delayed brakefunction. •Clean the electric contacts of the electric engine block heater and trailer couplingafter driving in water and mud.
• Do not let the car stand with water overthe sills for any long period of time - thiscould cause electrical malfunctions.IMPORTANT
Engine damage can occur if water enters the air filter. In depths greater than 25 cm, water could enter the transmission. This reduces thelubricating ability of the oils and shortensthe service life of these systems. In the event of the engine stalling in water, do not try restart - tow the car from thewater to a workshop - an authorised Volvoworkshop is recommended. Risk of enginebreakdown.
Related information
•Recovery (p. 316)
• Towing (p. 313)
Overheating
Under special conditions, for example hard driving in hilly terrain and hot climate, there isa risk that the engine and drive system mayoverheat - in particular with a heavy load. For information about overheating when driv- ing with a trailer, see Driving with a trailer (p.306). • Remove any auxiliary lamps from in front of the grille when driving in hot climates.
• If the temperature in the engine's coolingsystem is too high then a warning symbolis illuminated in the combined instrumentpanel's information display and a text message
High engine temp Stop safelyis shown there - stop the car in a safe way and allow the engine to run at idlingspeed for several minutes in order to cooldown.
• If the text message
High engine temp
Stop engine or Coolant level low, Stop
engine is shown then the engine must be
switched off after stopping the car.
• In the event of overheating in the gearbox a built-in protection function is activatedwhich, amongst other things, illuminatesa warning symbol in the combined instru-ment panel, and its display shows the text message
Transmission hot Reduce
speed or Transmission hot Stop safely- follow the recommendation given and lower the speed and stop the car in a safeway and allow the engine to run at idling
ProCarManuals.co’

10 Maintenance and service
10
343
Bonnet - opening and closing
The bonnet can be opened when the handle in the passenger compartment has beenturned clockwise and the lock by the grille hasbeen moved to the left.
The handle for bonnet opening is always on the left-hand side.
Turn the handle about 20-25 degrees clockwise. You will hear when the catchreleases.
Move the catch to the left and open the bonnet. (The catch hook is locatedbetween the headlamp and grille, seeillustration.)
WARNING
Check that the bonnet locks properly when closed.
Related information
•Engine compartment - checking (p. 344)
• Engine compartment - overview (p. 343)
Engine compartment - overview
The overview shows normal checking points.
Engine compartment 4 cyl. 2.0 l 1
The appearance of the engine compartment may differ depending on engine variant.
Filling engine oil
Coolant expansion tank
Radiator
Reservoir for brake and clutch fluid (located on the driver's side)
Battery
Relay and fuse box
Filling washer fluid
Air filter
1
Does not apply to the B4204T7 engine - see instead the following heading "Engine compartment except 4-cyl. 2.0 l".
ProCarManuals.co’

||
10 Maintenance and service
10
344
WARNING
The ignition system has very high voltage and output. The voltage in the ignition sys-tem is highly dangerous. The car's electri-cal system must always be in key position0 when work is being performed in the
engine compartment; see Key positions -functions at different levels (p. 70). Do not touch the spark plugs or ignition coil when the car's electrical system is inkey position II or when the engine is hot.
Engine compartment except 4 cyl. 2.0 l 2
The appearance of the engine compartment may differ depending on engine variant.
Coolant expansion tank
Power steering fluid reservoir
Engine oil dipstick
3
Radiator
Filling engine oil
Reservoir for brake and clutch fluid (located on the driver's side)
Battery
Relay and fuse box
Filling washer fluid
Air filter
WARNING
The ignition system has very high voltage and output. The voltage in the ignition sys-tem is highly dangerous. The car's electri-cal system must always be in key position0
when work is being performed in the
engine compartment; see Key positions -functions at different levels (p. 70). Do not touch the spark plugs or ignition coil when the car's electrical system is inkey position II or when the engine is hot.
Related information
• Bonnet - opening and closing (p. 343)
• Engine compartment - checking (p. 344)
Engine compartment - checking
Some oils and fluids should be checked at regular intervals.
Regular checkingCheck the following oils and fluids at regularintervals, e.g. when refuelling:
• Coolant
• Engine oil
• Power steering fluid (not cars with 4-cyl. 2.0 litre engine 4
)
• Washer fluid
WARNING
Remember that the radiator fan (located at the front of the engine compartment,behind the radiator) may start automati-cally some after the engine has beenswitched off. Always have the engine cleaned by a workshop. There is a risk of fire if theengine is hot.
Related information
• Bonnet - opening and closing (p. 343)
• Engine compartment - overview (p. 343)
• Coolant - level (p. 349)
• Engine oil - checking and filling (p. 346)
2
Also applies to the B4204T7 engine.3 Engines with electronic oil level sensor do not have a dipstick (5-cyl. diesel).
4 However, does apply to the B4204T7 engine.
ProCarManuals.co’

||
10 Maintenance and service
10
346
texts. Certain variants have both systems. Contact a Volvo dealer for more information. Change the engine oil and oil filter in accord- ance with the intervals specified in the Serv-ice and Warranty Booklet. Using oil of a higher than specified grade is permitted. If the car is driven in adverse con-ditions, Volvo recommends using an oil of ahigher grade; see Engine oil - adverse drivingconditions (p. 395). For filling capacities, see Engine oil - grade and volume (p. 396).
Related information
•Engine oil - checking and filling (p. 346)
Engine oil - checking and filling
The oil level is checked on certain engine vari- ants with the electronic oil level sensor, onother engine variants with the oil dipstick.
Engine with oil dipstick 5
G021734
Dipstick and filler pipe. Checking the oil level in a new car is espe- cially important before the first scheduled oilchange. Volvo recommends checking the oil level every 2 500 km. The most accurate measure-ments are made on a cold engine before star-ting. The measurement will be inaccurate iftaken immediately after the engine isswitched off. The dipstick will indicate thatthe level is too low because the oil has nothad time to flow down into the oil sump.
G021737
The oil level must be between the
MIN and MAX
marks.
Measurement and filling if required1. Ensure that the car is level. After switch-
ing off the engine it is important to wait 5 minutes to allow the oil time to run backto the sump.
2. Pull up and wipe the dipstick.
3. Re-insert the dipstick.
4. Pull it out and check the level.
5. If the level is close to MIN then 0.5 litres
should be added. If the level is signifi- cantly below, then an additional amountis required.
6. If required, check the level again, do it after driving a short distance. Then repeatsteps 1-4.
5Does not apply to the 4-cyl. 2.0 litre or 5-cyl. diesel, which have electronic oil level sensor. However, does apply to the B4204T7 engine.
ProCarManuals.co’

10 Maintenance and service
10
371
FunctionA
Solenoid clutch A/C (5, 6-cyl.); Valves (1.6 l, engine B4204T7;5-cyl., 6-cyl.); Engine controlmodule (6-cyl.); Solenoids (6-cyl. without turbo); Actuatormotors, intake manifold (6-cyl.without turbo); Mass air flowsensor (engine B4204T7; 5-cyl.petrol); Oil level sensor (5-cyl.diesel)10
Valves (4-cyl. 2.0 lB
); Oil pump
(4-cyl. 2.0 l petrol B
); Lambda-
sond, centre (4-cyl. 2.0 l pet- rol B
); Lambda-sond, rear (4-cyl.
2.0 l diesel)15
Lambda-sonds (1.6 l petrol, engine B4204T7); Lambda-sond (5-cyl. diesel); Controlmodule, radiator roller cover(1.6 l diesel, 5-cyl. diesel)10
Lambda-sond, front (4-cyl. 2.0 l B
); Lambda-sond, rear (4-
cyl. 2.0 l petrol B
); EVAP valve
(5, 6-cyl. petrol); Lambda- sonds (5, 6-cyl. petrol)15
FunctionA
Coolant pump (1.6 l petrol Start/Stop); Crankcase ventila-tion heater (5-cyl. petrol); Oilpump automatic gearbox(5-cyl.petrol Start/Stop)10
Ignition coils (4-cyl. 2.0 l pet- rol B
)15
Diesel filter heater20
Control module, radiator roller cover (5-cyl. petrol)5
Crankcase ventilation heater (5-cyl. diesel); Oil pump auto-matic gearbox (5-cyl. dieselStart/Stop)10
Solenoid clutch A/C (4-cyl. 2.0 l B
); Glow control module (4-
cyl. 2.0 l diesel); Oil pump (4- cyl. 2.0 l diesel)15
Coolant pump (4-cyl. 2.0 l pet- rol B
)50
Glow plugs (diesel)70
FunctionA
Cooling fan (1.6 l, 4-cyl. 2.0 l petrol, 5-cyl. petrol)60
Cooling fan (6-cyl., 4-cyl. 2.0 l diesel, 5-cyl. diesel)80
Power steering100
A For cars with the Start/Stop function this fuse location is empty - see instead Fuses - in the engine compartment'scold zone (p. 377).
B Does not apply to the B4204T7 engine.
C However, does apply to the B4204T7 engine.
Related information
• Fuses - under glovebox (p. 372)
• Fuses - in the control module under the glovebox (p. 374)
• Fuses - in cargo area (p. 376)
ProCarManuals.co’

11 Specifications
11
396
Engine oil - grade and volume
Engine oil grade and volume for each respec- tive engine alternative can be read in thetable. Volvo recommends:
EngineEngine codeAOil gradeVolume, incl. oil filter
(litres)
T6B6304T4Oil grade: ACEA A5/B5 Viscosity: SAE 0W–30approx 6.8
D4 AWDD5244T12approx. 5.9
D4 AWDD5244T17approx. 5.9
D3D5204T7approx. 5.9
D5D5244T11 Bapprox. 5.9
D5D5244T15Capprox. 5.9
D2D4162TOil grade: ACEA A5/B5 Viscosity: SAE 5W–30 When driving under adverse conditions, use ACEA A5/B5 SAE 0W-30.approx. 3.8
ProCarManuals.co’

11 Specifications
11
397
EngineEngine codeAOil gradeVolume, incl. oil filter
(litres)
T3B4164T3Certified and factory-filled oil: Oil grade WSS-M2C925-A
options for service: Oil grade: ACEA A5/B5 Viscosity: SAE 5W–30approx. 4.1
T4B4164Tapprox. 4.1
T4FB4164T2approx. 4.1
T4 DB5204T8Oil grade: ACEA A5/B5 Viscosity: SAE 0W–30approx 5.5
T5
DB5204T9approx 5.5
T5B4204T11Castrol Edge Professional V 0W-20 or 0w20 VCC RBS0-2AEapprox. 5.4
T6B4204T9approx. 5.4
D4D4204T5approx. 5.6
A
Engine code, component and serial number can be read on the engine; see Type designations (p. 386).
B Manual gearbox
C Automatic gearbox
D Only certain markets.
Related information
• Engine oil - adverse driving conditions (p. 395)
• Engine oil - checking and filling (p. 346)
ProCarManuals.co’

12 Alphabetical Index
12
431
Electrical socket...................................... 141
cargo area........................................... 144
Electrical system...................................... 410 Electric parking brake low battery voltage............................. 293
Electronic climate control - ECC............. 121Emergency equipment first aid kit........................................... 329
warning triangle.................................. 329
Emergency puncture repair..................... 333 action.................................................. 335
inflating the tyres................................ 337
rechecking.......................................... 336
Emergency puncture repair kit location............................................... 333
overview.............................................. 334
sealing fluid......................................... 338
Emissions of carbon dioxide................... 403 Engine deactivate........................................... 265
overheating......................................... 306
start..................................................... 264
Start/Stop........................................... 279
Engine and passenger compartment heater direct start/immediate stop................ 130
messages........................................... 132
timer.................................................... 130
Engine block heater......................... 129, 269 Engine compartment
coolant................................................ 349
oil........................................................ 345
overview.............................................. 343
power steering fluid............................ 351
Engine drag control................................. 176
Engine oil......................................... 345, 395 adverse driving conditions.................. 395
filter..................................................... 345
grade and volume............................... 396
Engine specifications............................... 393 Error messages Adaptive Cruise Control..................... 200
Driver Alert Control............................. 227
Lane Departure Warning..................... 232
LKA..................................................... 238
see Messages and symbols....... 200, 295
Error messages in BLIS........................... 257
ERS - Remote Start................................. 266
exhaust gases, toxic, sucked in.............. 298
External dimensions................................ 389
F
Fan ECC.................................................... 123
Fault tracing for the camera sensor......... 208 First aid.................................................... 329
First aid kit............................................... 329
Flexifuel.................................................... 269
Fluids, capacities............. 398, 399, 401, 402
Fluids and oils.......................... 398, 399, 401Fog lamp
rear........................................................ 85
Foot brake....................................... 290, 291
FOUR-C - Active chassis......................... 175
FSC, ecolabelling....................................... 21
Fuel.......................................... 301, 302, 304 fuel consumption................................ 403
fuel economy...................................... 328
fuel filter.............................................. 303
Fuel-driven heater direct start/immediate stop................ 130
timer.................................................... 130
Fuelling filling................................................... 300
fuel cap............................................... 300
fuel filler flap....................................... 300
fuel filler flap, manual opening............ 300
Fuel tank volume................................................ 402
Fuse box.................................................. 367
Fuses....................................................... 367 cargo area........................................... 376
ProCarManuals.co’

12 Alphabetical Index
12
434
M
Main/dipped beam, see Lighting............... 81
Main beam, automatic activation.............. 82maintenanceRustproofing....................................... 381
Manual gearbox....................................... 271 GSI - Gear selector assistance........... 272
Towing and recovery.......................... 314
trailer................................................... 308
Manual gear positions (Geartronic).......... 273
Max. roof load.......................................... 390
Memory function in seat............................ 73Menus Combined instrument panel............... 100
menu overview.................................... 101
Messages................................................ 102 Information display............................. 101
Messages and symbols Adaptive Cruise Control..................... 200Collision Warning with Auto
Brake.......................................... 211, 222
Driver Alert Control............................. 227Engine block heater and passenger
compartment heater........................... 132
Lane Departure Warning..................... 232
LKA..................................................... 238
Messages in BLIS.................................... 257 Meters
fuel gauge....................................... 59, 61
speedometer................................... 59, 61
tachometer..................................... 59, 61
misting attending to the windows................... 115
Misting condensation in headlamps............... 379
Mood lighting............................................. 89
MY CAR................................................... 103
O
Oil, see also Engine oil..................... 395, 396
Oil level low.............................................. 345
Output...................................................... 393
outside temperature gauge....................... 67
Overheating............................................. 306
Owner's manual, ecolabelling.................... 21
P
PACOS....................................................... 30
Paddle on the steering wheel.................... 77 Paintwork
colour code......................................... 383
damage and touch-up........................ 383
Panel lighting............................................. 79
Panic function.......................................... 152
PAP - Active Park Assist.......................... 247
Park Assist............................................... 240 backward............................................ 241
fault indicator...................................... 243
function............................................... 240
parking assistance sensors................ 243
Park assist camera.................................. 244 settings............................................... 246
Parking brake........................................... 293
Passenger compartment filter................. 117
Passenger compartment heater.............. 129PCC – Personal Car Communicator functions............................................. 151
range........................................... 154, 159
Pedestrian detection................................ 212
Petrol grade............................................. 302
Pinch protection, sunroof........................ 100
Pocket park assist - PAP......................... 247
Polishing.................................................. 380
Position/parking lamps.............................. 80
Power guide............................................... 63
ProCarManuals.co’