engine oil VOLVO V60 RECHARGE 2021 Warranty and Maintenance Records Information
[x] Cancel search | Manufacturer: VOLVO, Model Year: 2021, Model line: V60 RECHARGE, Model: VOLVO V60 RECHARGE 2021Pages: 68, PDF Size: 1.9 MB
Page 46 of 68

44
WARRANTY
• Transmission Control Module (TCM) Software
• Turbocharger
HYBRID (T8) SPECIFIC Emission 
Components 
• AC Compressor (Electrical) 
• Active Brake Booster
• Battery Coolant Pump
• Battery Energy Control Module HW (BECM) 
• Battery Energy Control Module SW (BECM) 
• Booster Pedal Travel Sensor
• Brake Control Module (BCM2) 
• Brake Control Module Software 
• Chiller Shut-Off Valve
• Chiller Shut-Off Valve (Kit)
• Combined Inverter DC/DC (CIDD)
• Combined Inverter DC/DC Software  
(CIDD SW)
• Condensor
• Coolant Temperature Sensor (ED)
• Coolant Thermostat Kit (ED)
• Cooling Fan (Hybrid) 
• Electric Drive Coolant Pump
• Electric Oil Pump (EOP)
• Electric Oil Pump Control Module
• Electric Rear Axle Drive (ERAD)*
• Electric Vacuum Pump (EVP)
• Electric Vacuum Pump Control Unit (EVP)
• Electrical 3-Way Valve (ED)
• Rear AC with Shut-Off Valve
• High-Voltage Battery**
• Hybrid ED (Electric Drive) Radiator
• Integrated Starter Generator (C-ISG)
• Inverter Electric Motor HW
• Inverter SW
• On Board Charger (OBC) HW
• On Board Charger (OBC) SW
• Pedal Angle Sensor
• Pressure Sensor AC Hybrid
• Rotor Position Sensor (C-ISG)
• SRS Unit
• Steering Wheel Angle Sensor (SAS)
• Thermal Expansion Valve (TXV) with Shut-Off 
Valve
• Vacuum Sensor in Active Brake Booster
• Wheel Speed Sensor (Front)
• Wheel Speed Sensor (Rear) Miscellaneous items used in above systems
Manifolds, hoses, clamps, fittings, tubing, sealing 
gaskets or devices, pulleys, belts, fuel lines, wiring 
harnesses and mounting hardware and electronic 
controls (all models) used with the components 
listed above.
NOTE
Parts listed under the 2021 Emission Warranty 
Parts List – Federal – U.S. and Canada are 
only covered components when they apply to 
specific engine variants. Not all parts listed 
apply to all engine types.
NOTE
Model year 2021 vehicles with engine VIN 
code BR or BK sold and registered in California, 
Connecticut, Maine, Massachusetts, Maryland, 
New Jersey, New York, Oregon, Rhode Island 
or Vermont are classified as Transitional Zero 
Emissions (TZEV) vehicles. TZEV vehicles have 
a defects and performance emissions warranty 
on all emissions components, except the hybrid 
battery, for fifteen (15) years or 150,000 miles, 
whichever occurs first.
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.
** Covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first. 
Page 52 of 68

50
WARRANTY
fuel or fuels not recommended in your Owner’s 
Manual or this booklet. If the failure is covered 
under this warranty, Volvo shall be liable for 
diagnostic and repair expenses. If the failure is 
caused by a combination of warrantable and 
nonwarrantable conditions, the owner shall not be 
liable for the portion of diagnostic and repair costs 
relating to the warrantable condition. If the failure 
is caused by a nonwarrantable condition, the 
vehicle owner shall be liable for all diagnostic and 
repair expenses, but not to exceed the maximum 
permissible under the inspection program. The 
owner may choose to have the vehicle repaired at 
a facility other than a Volvo retailer; however, if a 
warrantable condition is found, the owner must 
bring the vehicle to an authorized Volvo retailer to 
have the repairs completed at no cost for parts, 
labor, and diagnosis. Volvo will not reimburse 
the owner for diagnostic costs incurred at the 
unauthorized service facility except in the case of 
an emergency.
What Is Not Warranted (applies to all 
models)
1.  Required maintenance services as specified in 
the article “Maintenance Service Operations” 
in this booklet. Items that affect emissions 
and require scheduled replacement are 
warranted up to their first replacement point 
[such as spark plugs, filters, belts, etc.]. 
Once these parts have been replaced at the 
scheduled replacement point, they are no 
longer covered by this Emission Warranty.
2.  Malfunctions in any part caused by misuse, 
improper adjustments (by other than a 
Volvo dealer during warranty repair work), 
modification, alteration, tampering or 
disconnection of system parts.
3.  Damage resulting from accidents, acts of 
nature, or events beyond the control of Volvo.
4.  The use of fuel and/or oil, or other fluids which 
do not meet the Volvo-approved standards 
as set forth in the Owner’s Manual or in the 
articles “Fuel requirements” and “Engine oil” 
in this booklet, may not be warranted. 5. 
Repairs on vehicles for which the true 
odometer mileage cannot be readily 
determined.
6.  Parts other than genuine Volvo replacement or 
remanufactured parts used for maintenance, 
repair or replacement affecting components of 
the emission control system.
7.   Any loss of time, inconvenience, loss of vehicle 
use or commercial loss.
   
Page 55 of 68

53
WARRANTY
2021 Model Year Emission Parts List
Hybrid models onlyHybrid models only purchased and registered in 
Delaware, Pennsylvania and Washington. The 
components listed in the chart below apply to 
  Hybrid models and are covered by the Long-Term 
Defect and Performance Warranty for seven (7) 
years or 70,000 miles, whichever occurs first.
ENGINE VIN CODE NUMBER
BK BR
AC Compressor (Electrical)  XX
Active Brake Booster XX
Battery Coolant Pump XX
Battery Energy Control Module HW (BECM)  XX
Brake Control Module (BCM2)  XX
Catalytic Converter*  XX
Charge Air Cooler XX
Combined Inverter DC/DC (CIDD) XX
Condenser XX
Cooling Fan (Hybrid)  XX
CVVT Timing Device (Exhaust/Intake) XX
Electric Drive Coolant Pump XX
Electric Oil Pump (EOP) XX
Electric Oil Pump Control Module XX
Electric Rear Axle Drive (ERAD)* XX