brake VOLVO V70 2001 Owner's Manual

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_08a.htm[4/4/2013 10:39:05 PM]
Replacement of rear turn signal and brake light bulbs
Switch off all lights and turn the ignition switch to position 0.
Using a screwdriver, carefully pry off the speaker grille.
Pull out the red tab in the speaker.
Then press on the black pin above the extracted red tab and twist out the speaker.
Twist the bulb holder counter-clockwise, and withdraw it.
Fit a new bulb.
Fit the bulb holder in place and twist it clockwise.
Refit the speaker and press in the red tab.
Press the speaker grille back into position.
pg. 115 Replacing bulbs
Front fog lights (option)
CAUTION:
Avoid touching the glass on the bulb with your fingers.
Switch off all lights and turn the ignition key to position 0.
Turn the bulb holder slightly counter-clockwise to release it.
Replace the bulb. The shape of the base of the bulb corresponds to the shape of the bulb holder.
Reinstall the bulb holder by turning it slightly clockwise. "TOP" on the holder should be upward.
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_08a.htm[4/4/2013 10:39:05 PM]
spray into the locks.
When washing or steam cleaning the engine, avoid spraying water or steam directly on the electrical components or
toward the rear side of the engine.
After cleaning the engine, the spark plug wells should be inspected for water and blown dry if necessary. Suitable
detergents: Special car washing detergents should be used. Mix according to manufacturer's instructions. Bumpers:
The bumpers are painted. Wash the bumpers with the same cleaning agent used on the rest of the car. Never clean the
bumpers with gasoline or paint thinner. Difficult spots can be removed with denatured alcohol. To avoid scratches, do
not dry the bumpers with paper.
WARNING!
When the car is driven immediately after being washed, apply the brakes several times in order to remove any
moisture from the brake linings.
Engine cleaning agents should not be used when the engine is warm. This constitutes a fire risk.
pg. 120 Washing the car, Cleaning the upholstery
Automatic washing - simple and quick
We do NOT recommend washing your car in an automatic wash during the first six months (because the
paint will not have hardened sufficiently).
An automatic wash is a simple and quick way to clean your car, but it is worth remembering that it may not be as
thorough as when you yourself go over the car with sponge and water. Keeping the underbody clean is most important,
especially in the winter. Some automatic washers do not have facilities for washing the underbody.
Before driving into an automatic wash, make sure that side view mirrors, auxiliary lamps, etc, are secure, otherwise
there is risk of the machine dislodging them.
Polishing and waxing
Normally, polishing is not required during the first year after delivery. However, waxing may be beneficial.
Before applying polish or wax the car must be washed and dried. Tar spots can be removed with kerosene or tar
remover. Difficult spots may require a fine rubbing compound.
After polishing, use liquid or paste wax.
Several commercially available products contain both polish and wax.
Waxing alone does not substitute for polishing of a dull surface.
A wide range of polymer-based car waxes can be purchased today. These waxes are easy to use and produce a long-
lasting, high-gloss finish that protects the bodywork against oxidation, road dirt and fading.
Do not polish or wax your car in direct sunlight (the surface of the car should not be warmer than 113° F (45° C).
Cleaning the upholstery
The fabric can be cleaned with soapy water or a detergent. For more difficult spots caused by oil, ice cream, shoe
polish, grease, etc., use a clothing/fabric stain remover.
The plastic in the upholstery can be cleaned with a soft cloth and mild soap solution.
Leather upholstery/suede-like upholstery (alcanteraª) can be cleaned with a soft cloth and mild soap solution. For
more difficult spots, Volvo offers a leather care kit.
Under no circumstances should gasoline, naphtha or similar cleaning agents be used on the plastic or the
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_08a.htm[4/4/2013 10:39:05 PM]
R = Replace
I = Inspect (Correct or Replace if necessary)
L = Lubricate
Maintenance Operationthousand miles 7.51522.5 3037.5 4552.5 6067.5 7582.5 90
(thousand km)(12)(24)(36) (48)(60) (72)(84)(96)(108) (120) (132)(144)
EMISSION SYSTEM MAINTENANCE
Engine
Fuel line filter
1
PCV nipple (orifice)/hoses, clean I I
Battery (check charge and electrolyte level) II II II II I II I
Brakes
Inspect brake pads, replace components as necessary I II II II I II I
Brake fluid level
2 - check
I I I I I I
Steering/suspension
Tires
3, check pressure, wear and condition I
I II II II I II I
Check power steering fluid level I I I I I
Body
Trunk/hood, hinges and latches L L L
Cabin air filter (see page 126
of the Owner's manual) R R R R R R
1) Replace at 105,000 miles (168,000 km)
2) Brake fluid should be changed at owner request every second year or 30,000 miles (48,000 km). The fluid
should be replaced once a year or every 15,000 miles (24,000 km) when driving under extremely hard
conditions (mountain driving, etc.).
3) Rotate tires at owner request.
The following items should be checked weekly by the driver (it takes only a few minutes):
Engine oil level, brake fluid level, radiator coolant level, operation of all lights, horns, windshield wipers, tire
pressure (all five tires), windshield washer fluid level
The following should also be carried out at regular intervals:
Washing (check all drain holes), polishing, cleaning

Contents | Top of Page
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_09.htm[4/4/2013 10:39:07 PM]
* The Vehicle Identification Number (VIN) should always be quoted in all correspondence concerning your vehicle
with the retailer and when ordering parts.
All specifications are subject to change without prior notice.
pg. 137 Dimensions and weights
Dimensions
Length 185.4 in. (471 cm), V70 XC -186.2 (473 cm)
Width 70.9 in. (180 cm), V70 XC - 73.2 in. (186 cm)
Height 57.5 in. (146 cm), V70 AWD - 58.7 in. (149 cm), V70 XC - 61.4 in. 156 cm)
Wheelbase 108.7 in. (276 cm), V70 XC - 108.7 in. (276 cm)
Track, front 61.4 in. (156 cm), V70 XC - 63.4 in. (161 cm)
Track, rear 61.4 in. (156 cm), V70 XC - 61 in. (155 cm)
Turning circle (between curbs) 35.8-39 ft. (10.9-11.9 m)
Cargo capacity 35.9 cu. ft. (1 m 3 )
* See also section "Trailer towing"
USACanada
Max roof load 220 lbs100 kg
Max trailer weight (w/o brakes) 1100 lbs500 kg
Max trailer weight (with brakes) 3300 lbs1500 kg
Max tongue weight * 165 lbs75 kg
WARNING!
When adding accessories, equipment, luggage and other cargo to your vehicle, the total loaded weight capacity of
the vehicle must not be exceeded.
Weights USACanada
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_09.htm[4/4/2013 10:39:07 PM]
Engine Oil
Meeting or exceeding ILSAC specification GF-2, including ACEA A1, API SJ, SJ/CF, and SJ/Energy Conserving.
Oil additives must not be used unless advised by an authorized Volvo retailer.
Volume:
Capacity (including oil filter): 6.1 US qts. (5.8 liters)
Capacity (including oil filter and oil cooler): 7.1 US qts. (6.7 liters)
Automatic Transmission Fluid
AW5: Only Volvo gearbox oil (1161540-8). Do not mix with other oils.
Volume: 7.9 US qts (7.5 liters)
Cooling system
Type: Positive pressure, closed system. The thermostat begins to open at 194 ¡F (90 ¡C)
Coolant: Volvo original coolant/antifreeze
All specifications are subject to change without prior notice.
Power steering fluid
ATF fluid
Volume:
Brake fluid
DOT 4+
Volume: 0.64 US qts (0.6 liters)
Climate control system - refrigerant (R 134a)
Oil: PAG
Volume: 2.2 lbs (1,000 g) R134a
Fuel
Minimum octane requirement - AKI 87 (RON 91)
Volume (fuel tank): 21.1 US gals (80 liters)*
Washer fluid reservoir
Volume: 4.7 US qts (4.5 liters)
* 18.5 US gals (70 liters) on V70 AWD, V70 XC and V70 with non-turbo engine.
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_09.htm[4/4/2013 10:39:07 PM]
Front parking lights5WW2.1x9.5d
Front direction indicators (yellow)21 WBAU 15d
Front fog lights H155 W-
Rear direction indicators (yellow)21WBAU 15 s
Tail lights 675WBA 15 s
Brake lights 115621WBA 15 s
Backup lights 115621WBA 15 s
Rear fog light/rear parking lights 21/4WBA 15 s
License plate light -5 WW 2.1x9.5d
Door step courtesy lights
Front -5WSV 8.5
Cargo area lights -5 WSV 8.5
Glove compartment light -2 WBA 9s
Vanity mirror lights -5 WW 2.1x9.5d
Instrument lighting -3 WW 2.1x9.5d
All specifications are subject to change without prior notice.
pg. 142 Volvo On Call
Your new Volvo comes with a four year ON CALL road assistance. Additional information, features, and
benefits are described in a separate information package in your glove compartment.
If you have misplaced your package, dial:
In the U.S.A.
1-800-63-VOLVO (1-800-638-6586)
In Canada:
1-800-263-0475
Volvo supports Voluntary Mechanic Certification by the A.S.E. (pertains to the USA only). Certified mechanics
have demonstrated a high degree of competence in specific areas. Besides passing exams each mechanic must
also have worked in the field for two or more years before a certificate is issued. These professional mechanics
are fully able to analyze vehicle problems and perform the necessary service procedures to keep your Volvo at
peak operating condition.
All specifications are subject to change without prior notice.
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_12.htm[4/4/2013 10:39:23 PM]
2 0 0 1
VOLVO V70
INDEX
pg. 178 - 181 Index
A
ABS 19
ABS - warning light27
Accessory lights29
Adjusting the steering wheel33
Advanced User Mode (AUM) - radio152
Air conditioning44 - 47
Air pump system125
Air vents42
Airbag (SIPS)8
Airbag (SRS)4
Alarm74, 75
Alarm - "panic" function74
All Wheel Drive (AWD) - towing91
All Wheel Drive - special tire information101
ALR/ELR14
Anti-lock Brake System (ABS)19
Anti-lock Brake System - warning light27
Antifreeze96, 125
Approach lighting70
Armrest (center) - 3-section rear seat59
Ashtray37, 53
Audio systems143
cassette deck156
CD player154
HU -413 - overview144
HU -613 - overview145
HU -803 - overview146
specifications159
AUM (Advanced User Mode) - radio152
Automatic car washing120
Automatic locking73
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_12.htm[4/4/2013 10:39:23 PM]
Automatic Locking Retractor (ALR)14
Automatic transmission82, 83, 138
Geartronic84, 85
Kickdown83, 84
Auxiliary socket29, 37
B
Backrest (center) - 3-section rear seat58
Battery96, 141
Battery maintenance132, 133
Replacing the battery133
Ventilation hose133
Booster cushion12, 16
bottle holder in rear seat56
Brake failure warning light26
Brake fluid131
Brake system18
Break-in period78
Bulbs (list)141
Bulbs - replacing112, 113, 114, 115, 116, 117
C
Capacities (oils and fluids)135
, 139
Cargo compartment cover65
Cargo compartment lighting61
Cargo eyelets62
Cargo net63
Catalytic converters - three-way98
Center armrest - 3-section rear seat59
Center backrest (3-section rear seat)58
Center console - switches29
Center head restraint - 3-section rear seat58
Center head restraint - rear seat3
Center seat head restraint57
Central locking buttons73
Chains - winter driving102
Changing wheels105, 106
Child booster cushion12, 16
Child Restraint Anchorages15
Child safety11, 12, 14, 16
Child safety locks - rear doors76
Climate controls44, 45, 46, 47
Climate system - general information43
Clock25
Clutch interlock81
Coat hanger55
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_12.htm[4/4/2013 10:39:23 PM]
Coin compartment53
Cold weather driving96
Combination filter44, 47
Coolant125
Cooling system - general information87
Courtesy light52
Courtesy lights (front) - replacing117
Courtesy lights - exterior70
Cruise control31
Cup holder53, 54
D
Detachable trailer hitch - installing93
Detachable trailer hitch - removing94
Dimensions137
Direction indicators34
Distributor ignition system140
Door step courtesy lights - replacing116
Doors and locks70
Drive belt125
Driving economy86
Driving mode indicator25
Driving mode W83, 85, 96
Driving with trunk open87
E
Economical driving86
Electric socket in cargo compartment61
Electrical system141
Electrical system - general information87
Electrically operated front seats50
Electrically operated sideview mirrors39
Electrically operated sun roof40
Electrically operated windows38
Electronic Brake Force Distribution19
Electronic Climate Control (ECC)44 - 47
Emergency Locking Retractor (ELR)14
Emergency towing90, 91
Emergency warning flashers36
Emissions systems124
Engine - specifications138
Engine - starting80
Engine compartment128
Engine oil78, 96, 129, 130
Extension of cargo compartment57
Exterior courtesy lights70
ProCarManuals.com

2001 VOLVO V70
http://new.volvocars.com/ownersdocs/2001/2001_V70/01v70_12.htm[4/4/2013 10:39:23 PM]
Exterior features - overview23
Extra seat65
F
Fog light - rear27
, 32
Fog lights - front32
Folding passenger's seat backrest51
Folding sideview mirrors29
Foldtable56
Four wheel drive - towing91
Front airbags - SRS4 - 7
Front airbags - SRS - warning light26
Front courtesy lights - replacing117
Front fog lights32
Front fog lights - replacing115
Front reading lights52
Front seats - adjusting50
Front seats - heated36
Front suspension140
Fuel78
Fuel filler cap79
Fuel gauge25
Fuel requirements78
Fuel system124, 140
Fuel tank cover4, 79
Fuel/emissions systems124
Fuses108 - 111
G
Gas cap79
Gasoline78
Gear indicator25
Geartronic (automatic transmission)84, 85
Generator141
Generator warning light26
Glove compartment - locking76
H
Hand brake37
Handgrip - V 70 XC67
Handling86
Hazard warning flashers36
Head restraint (center) - 3-section rear seat58
Head restraint - center rear3
Headlight bulbs - replacing112
Headlight wiper blades - replacing134
Headlights32
ProCarManuals.com