VOLVO XC60 2019 Warranty and Maintenance Records Information

9
SERVICE AND MAINTENANCE
Oil viscosity
Incorrect viscosity oil can shorten engine life under
normal use. SAE 5W-30 will provide good fuel
economy and engine protection. See the viscosity
chart.Viscosity chartExtreme engine operation
Volvo oil VCC RBS0-2AE/SAE 0W20 is
recommended for extreme driving conditions.
Turbocharger Operating TipsIn order to maximize the efficiency and operation
of your vehicle, the following points should be
observed:
1. Oil change and filter replacement every
10,000 miles/16,000 km, or at a time interval
based on the type of driving and conditions as
detailed in your Owner’s Manual. You should
maintain a record of these services (repair
order receipts).
2. Do not use engine oil additives as they
may adversely affect the engine.
CAUTION
Never race the engine immediately after
starting. Oil flow may not reach some
lubricating points fast enough to prevent
turbocharger damage.
Before switching off the engine, let it operate
at idle for a short time to allow the spinning of
the turbocharger compressor’s turbine vanes to
slow. After hard driving, this idle time should last
a couple of minutes, during which the vanes will
slow and the compressor will cool down while
still receiving oil lubrication. If the turbine vanes
are spinning at high speeds when the engine is
switched off, there is a great risk of heat damage
and/or turbine seizure due to lack of lubrication.Do not race the engine just prior to switching
off!

10
SERVICE AND MAINTENANCEMaintenance Service OperationsNon-hybrid models onlyService operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Engine
Engine oil and filter, replaceXXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check
for leaks
A
XXXXXXX
Service Reminder Indicator (SRI), resetXXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damageXXX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B. XXX
Spark plugs, replaceXX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agentXXXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
C
X
Timing belt tensioner & idler pulley, replace
C
X
Steering, Front and Rear Suspension
Power steering fluid level, check/adjustXXXXXXXXXXXXXXX

11
SERVICE AND MAINTENANCE
Service operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Steering/front suspension, check for wear
according to: Wheel angles checkXXX
Rear suspension, check for wear according
to: Wheel angles checkXXX
Transmission, Driveshaft and Differential
Automatic transmission fluid level, check/
adjust
D
XXX
Final drive/bevel gear, visual inspection
(AWD models only)
E
XXX
Driveshaft joints, check for wear/playXXX
Driveshafts, check rubber bootsXXX
Propeller shaft, pilot bearing and universal
joints, check wear (AWD models only)XXX
Controls and Lighting
Washer fluid level, check/adjustXXXXXXXXXXXXXXX
Check all wiper blades and washers for
headlights and windshields for function and
signs of wearXXXXXXXXXXXXXXX
External lighting, checkXXXXXXXXXXXXXXX
Headlights, fog lights, check and alignXXXXXXX


12
SERVICE AND MAINTENANCEService operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Horn, check functionXXXXXXXXXXXXXXX
Body
Cabin air filter, replace
F
XXXXXXX
Clean inside of windshield in front of camera
(vehicles with camera for collision warning)XXXXXXXXXXXXXXX
Seatbelts
Seatbelts, check functionXXXXXXXXXXXXXXX
Brake System
Brake fluid level, check & adjustXXXXXXXXXXXXXXX
Brake fluid, replace
G
XXX
Parking brake, check/adjustXXXXXXXXXXXXXXX
Brake pads/discs, checkXXXXXXXXXXXXXXX
Brake hoses and lines, check for damage/
leaksXXX
Wheels and Tires
Wheels and tires, check wear and conditionXXXXXXXXXXXXXXX
Wheels and tires check inflation pressureXXXXXXX
Tire inflator kit
H


13
SERVICE AND MAINTENANCE
Service operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Spare tire check for damage, wear, and tire
pressure
I
XXXXXXXXXXXXXXX
Check and replace parts or software, as required by Volvo Car USA, LLC, that are covered under the terms of the Volvo New Car Warranty.
A In the event of a leak from the transmission, check the oil level.
B May be necessary to change more frequently when driving in dusty/dirty areas.
C Replace at 150,000 miles/240,000 kilometers or 10 years, whichever comes first.
D Check automatic transmission fluid level only if an external leak is identified. Volvo recommends changing transmission fluid every 50,000 miles/80,000 kilometers, only on vehicles used for towing,
or when a message appears in the instrument panel text window.
E Only check the level if there is leakage.
F Recommended to replace at least once a year or more often in heavy traffic or dirty/dusty areas.
G Recommended to replace every 3 years or 40,000 miles (if driven in mountainous areas or humid climates – every one year) at owner’s request.
H Check expiration date label every four years for replacement date on vehicles with this equipment.
I Check spare tire pressure (where applicable) every two years or every 40,000 miles/64,000 kilometers.


14
SERVICE AND MAINTENANCEHybrid models onlyService operation Schedule of services
Hybrid Models miles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Engine
Engine oil and filter, replaceXXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check
for leaks
A
XXXXXXX
Service Reminder Indicator (SRI), resetXXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damageXXX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B.XXX
Spark plugs, replaceXX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agentXXXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
C
X
Timing belt tensioner & idler pulley, replace
C
X
Steering, Front and Rear Suspension
Power steering fluid level, check/adjustXXXXXXXXXXXXXXX 

15
SERVICE AND MAINTENANCE
Service operation Schedule of services
Hybrid Models miles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Steering/front suspension, check for wear
according to: Wheel angles checkXXX
Rear suspension, check for wear according
to: Wheel angles checkXXX
Transmission, Driveshaft and Differential
Automatic transmission fluid level, check/
adjust
D
XXX
Final drive/bevel gear, visual inspection
(AWD models only)
E
XXX
Driveshaft joints, check for wear/playXXX
Driveshafts, check rubber bootsXXX
Propeller shaft, pilot bearing and universal
joints, check wear (AWD models only))XXX
Controls and Lighting
Washer fluid level, check/adjustXXXXXXXXXXXXXXX
Check all wiper blades and washers for
headlights and windshields for function and
signs of wearXXXXXXXXXXXXXXX
External lighting, checkXXXXXXXXXXXXXXX
Headlights, fog lights, check and alignXXXXXXX


16
SERVICE AND MAINTENANCEService operation Schedule of services
Hybrid Models miles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Horn, check functionXXXXXXXXXXXXXXX
Body
Cabin air filter, replace
F
XXXXXXX
Clean inside of windshield in front of camera
(vehicles with camera for collision warning)XXXXXXXXXXXXXXX
Seatbelts
Seatbelts, check functionXXXXXXXXXXXXXXX
Brake System
Brake fluid level, check & adjustXXXXXXXXXXXXXXX
Brake fluid, replace
G
XXX
Parking brake, check/adjustXXXXXXXXXXXXXXX
Brake pads/discs, checkXXXXXXXXXXXXXXX
Brake hoses and lines, check for damage/
leaksXXX
Wheels and Tires
Wheels and tires, check wear and conditionXXXXXXXXXXXXXXX
Wheels and tires check inflation pressureXXXXXXX 

17
SERVICE AND MAINTENANCE
Service operation Schedule of services
Hybrid Models miles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Tire inflator kit
H
Check and replace parts or software, as required by Volvo Car USA, LLC, that are covered under the terms of the Volvo New Car Warranty.A In the event of a leak from the transmission, check the oil level.
B May be necessary to change more frequently when driving in dusty/dirty areas.
C Replace at 150,000 miles/240,000 kilometers or 10 years, whichever comes first.
D Check automatic transmission fluid level only if an external leak is identified. Volvo recommends changing transmission fluid every 50,000 miles/80,000 kilometers, only on vehicles used for towing,
or when a message appears in the instrument panel text window.
E Only check the level if there is leakage.
F Recommended to replace at least once a year or more often in heavy traffic or dirty/dusty areas.
G Recommended to replace every 3 years or 40,000 miles (if driven in mountainous areas or humid climates – every one year) at owner’s request.
H Check expiration date label every four years for replacement date on vehicles with this equipment.

18
SERVICE AND MAINTENANCEMaintenance/Service recordsThe following pages contain the service interval
records section.A Word About Your Service Records After each service is performed, your authorized
Volvo retailer will validate the appropriate record
section by entering the date serviced, mileage,
representative signature, and the retailer stamp.
NOTE
It is your responsibility, and extremely important
for you to retain documentation of all service or
warranty repairs to your Volvo (including work
performed by you as well as by non-authorized
repair facility), in the event that questions
regarding warranty coverage arise.Volvo Genuine Parts... Keep Your Volvo a
VolvoRegardless of where you service your Volvo, make
sure Volvo Genuine Parts are used to assure the
safety and high quality of your vehicle.
From oil filters to replacement lamps, from
complete assemblies to useful accessories, all
Volvo Genuine Parts are rigorously tested to
ensure the reliability and durability you have come
to expect from Volvo products.
You won’t have to worry about compromising the
special safety features originally built into your
Volvo when you insist on using only Volvo Genuine
Parts for all service, maintenance, and repairs
performed on your vehicle.Volvo Genuine Parts are available at authorized
Volvo retailers located throughout North America.
Experienced and knowledgeable people will help
you be certain that your Volvo remains a Volvo.
Maintenance Service No. 1Carried out
miles/km
Date
MileageRetailer Authorized Signature
SIGNATURE
Retailer Stamp
STAMP