brake VOLVO XC70 2007 Service Manual

2007 Volvo XC70
pg. 203 Maintenance and servicing
Replacing bulbs
Replacing bulbs in the tail light cluster
All bulbs in the tail light cluster can be replaced from inside the carg\
o area.
1. Turn signal
2. Brake light
3. Parking light
4. Fog light (left side only)
5. Backup light
To replace a bulb
- Switch off all lights and turn ignition key to position 0.
- Open the access panel.
- Twist the bulb holder counterclockwise and remove it.
- Press the bulb inward, twist it counterclockwise and extract it.
- Fit a new bulb.
- Fit the bulb holder in place and twist it clockwise.
- Refit the sound insulation and put the access panel back in place.
NOTE: If the message indicating a burned out bulb remains in the information \
display after the bulb has
been replaced, consult an authorized Volvo retailer.
Replacing turn signal and brake light bulbs
- Switch off all lights and turn the ignition switch to position 0.
- Using a screwdriver, carefully pry off the speaker grille.
- Pull out the red tab in the speaker.
- Then press on the black pin above the extracted red tab and twist out \
the speaker.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (27 of 38)12/30/200\
6 5:51:43 PM

2007 Volvo XC70
- Twist the bulb holder counterclockwise, and withdraw it.
- Fit a new bulb.
- Fit the bulb holder in place and twist it clockwise.
- Refit the speaker and press in the red tab.
- Press the speaker grille back into position.
High level brake light
These bulbs are of a special type. We recommend that you ask your Volvo \
retailer to replace this bulb.
pg. 204 Maintenance and servicing
Replacing bulbs
License plate lights
- Switch off the ignition.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (28 of 38)12/30/200\
6 5:51:43 PM

2007 Volvo XC70
8. Alarm siren5
9. Brake light switch feed 5
10. Instrument panel, climate system, power driver's seat (option),
occupant weight sensor 10
11. 12-volt sockets - front and rear seats 15
12. -
13. -
14. Headlight wipers (V70 R) 15
15. ABS, STC/DSTC 5
16. Power steering, Active Bi-Xenon headlights (option) 10
17. Driver's side front foglight (option) 7.5
18. Passenger's side front foglight (option) 7.5
19. -
20. -
21. Transmission control module, reverse gear block (M66) 10
22. Driver's side high beam 10
23. Passenger's side high beam 10
24. -
25. -
26. -
27. -
28. Power passenger's seat (option), audio system 5
29. -
30. -
31. -
32. -
33. Vacuum pump 20
34. Washer pump - headlight wipers (V70 R) 15
35. -
36. -
pg. 208 Maintenance and servicing
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (33 of 38)12/30/200\
6 5:51:44 PM

2007 Volvo XC70
Fuses in the cargo area
The fuses in the cargo area are located behind the panel on the driver's\
side of the cargo compartment.
When replacing a blown fuse, be sure to replace it with a new one of the\
same color and amperage
(written on the fuse). No. Amperage
1. Backup lights 10
2. Parking lights, foglights, cargo area lighting, license plate lightin\
g,
brake lights 20
3. Accessory control module 15
4. -
5. Rear Electronic Module 10
6. CD-changer (option), Navigation system (option) 7.5
7. Trailer wiring (30-feed) 15
8. 12-volt socket - cargo area 15
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (36 of 38)12/30/200\
6 5:51:44 PM

2007 Volvo XC70
9. Rear passenger's side door - power window, power window cutout
function 20
10. Rear driver's side door - power window, power window cutout
function 20
11. -
12. -
13. -
14. Subwoofer (option) 15
15. -
16. -
17. Accessory audio 5
18. -
19. Tailgate wiper 15
pg. 210 Maintenance and servicing
Fuses
No.Amperage
20. Trailer wiring (15-feed) 20
21. -
22. -
23. All Wheel Drive 7.5
24. Four-C chassis system (option) 15
25. -
26. Park assist (option) 5
27. Main fuse: trailer wiring, Four-C, park assist, All Wheel Drive 30
28. Central locking system 15
29. Driver's side trailer lighting: parking lights, turn signal 25
30. Passenger's side trailer lighting: parking light, brake light, fog
light, turn signal 25
31. Main fuse: fuses 37 and 38 40
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (37 of 38)12/30/200\
6 5:51:44 PM

2007 Volvo XC70
Fluids and cooling system
Fluids
Transmission
1

Different types of oil should never be mixed.
Power steering
Grade: Volvo synthetic power steering fluid (Pentosin CHF 11S) P/N 1161529 o\
r equivalent.
Brake fluid
Fluid type: DOT 4+ boiling point >536 °F (280 °C).
Cooling system

The thermostat begins to open at 194 °F (90 °C).
1. The transmission oil does not normally need to be changed during the \
service life of the vehicle. However, it
may be necessary to replace the oil if the vehicle is often driven in ar\
eas of sustained temperature extremes (hot
or cold), when towing a trailer over long distances, for prolonged driv\
ing in mountainous areas, or if the vehicle
is often driven short distances in temperatures under 40°F (5°C)\
.
pg. 219 Specifications
Three way catalytic converter
Three-way catalytic converter cautions
l Keep your engine properly tuned. Certain engine malfunctions, particular\
ly involving the electrical,
fuel or distributor ignition systems, may cause unusually high three-way\
catalytic converter
temperatures. Do not continue to operate your vehicle if you detect engi\
ne misfire, noticeable loss of
file:///K|/ownersdocs/2007/2007_XC70/07xc70_10.htm (7 of 11)12/30/2006\
5:51:45 PM

2007 Volvo XC70
2 0 0 7
VOLVO XC70
Index

pg. 247-250 Index
A
A/C (air conditioning)
77-82
ABS
2, 49, 137
Accessory installation (special warnings)
6
Active Bi-Xenon headlights (ABL)
55
Air conditioning
77-82
Air distribution
75, 78
Air quality sensor
79
Air vents
75
Alarm
116
All Wheel Drive
134
All Wheel Drive -towing
143
Anti-lock Brake System (ABS)
2, 49
Audio system
226
AUTO (climate control)
77
Automatic transmission
130
Automatic transmission - kickdown
131
Automatic transmission - Sport mode
133
Average speed
61
AWD
134
B
Battery
187, 195
replacing
197
file:///K|/ownersdocs/2007/2007_XC70/07xc70_12.htm (1 of 9)12/30/2006 \
5:51:48 PM

2007 Volvo XC70
Belt check 188
Black Box (Vehicle Event Data)
184
Blower (fan)
77
Booster cushion (integrated)
40
Brake circuit
136
Brake fluid
193
Brake light
203
Brake system
48, 136
Bulbs
198
C
Capacities
216
Capacity weight
167
Carbon monoxide warning
122
Catalytic converter
219
Central locking system - remote control
111
Changing coolant
188
Check Engine warning light
48
Child safety
28
child restraints
31
Child safety lock
115
Climate system
74
Clock
46
Cold weather precautions
151
Coolant
192
changing
188, 192
checking level of
188
Cooling system
218
Courtesy light
88
Cruise control
62
Curb weight
167
Current fuel consumption
61
D
file:///K|/ownersdocs/2007/2007_XC70/07xc70_12.htm (2 of 9)12/30/2006 \
5:51:48 PM

2007 Volvo XC70
K
Keylock
2, 125
Kickdown
131
L
Label information
213
Load carriers
148 -150
Locking steering wheel
126
Locking the car
114
Long distance trips
152
Low beam bulb, changing
199
Low beam headlights
57
M
Maintenance services
184
Maintenance, periodic
185
Malfunction indicator light
48
Manual transmission
129
Moonroof
70
Multifilter with air quality sensor
79
O
Occupant Weight Sensor
18
Octane rating
121
Odometer
46
Oil pressure
48
Oil quality
190
Owner maintenance
185
P
P Park
130, 132
Paint - color code
182
Park assist
153
Parking brake
48, 64
Parking light bulb, changing
200
Periodic owner-performed maintenance
185
file:///K|/ownersdocs/2007/2007_XC70/07xc70_12.htm (5 of 9)12/30/2006 \
5:51:48 PM